Please wait a minute...
材料导报  2019, Vol. 33 Issue (18): 3089-3095    https://doi.org/10.11896/cldb.18080064
  金属与金属基复合材料 |
预腐蚀对夹层结构自冲铆接头疲劳特性的影响
丁文有, 何晓聪, 刘佳沐, 刘洋
昆明理工大学机电工程学院,昆明 650500
Effect of Pre-corrosion on Fatigue Performance of Sandwich Structure Self-piercing Riveted Joint
DING Wenyou, HE Xiaocong, LIU Jiamu, LIU Yang
Faculty of Mechanical and Electrical Engineering, Kunming University of Science and Technology, Kunming 650500
下载:  全 文 ( PDF ) ( 5114KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 探究了周期浸润环境下以AA5052-O铝合金为基板的夹层结构自冲铆接头的耐蚀性能,并对不同预腐蚀时间下的试样进行了疲劳性能测试,依据三参数经验公式采用S-N曲线拟合法拟合出各试样的S-N曲线,分析了预腐蚀对接头疲劳寿命的影响规律;此外,采用扫描电子显微镜对接头的疲劳断口进行观测,研究了接头的损伤特性和微观疲劳失效机理。结果表明:预腐蚀会使接头产生多个疲劳源并加速裂纹的扩展,接头疲劳裂纹易在预腐蚀缺陷处萌生;腐蚀损伤和机械损伤存在竞争关系,预腐蚀显著影响了接头在低应力水平下的疲劳寿命,总体来讲,接头的疲劳寿命随预腐蚀时间的延长而缩短;接头疲劳失效形式有铆孔区下板断裂和铆孔区一侧的下板断裂,接头疲劳源区断口呈现准解理特征。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
丁文有
何晓聪
刘佳沐
刘洋
关键词:  自冲铆  AA5052-O铝合金  周浸腐蚀  断口形貌  疲劳性能    
Abstract: The corrosion resistance of sandwich structure self-piercing riveted joint with AA5052-O aluminum alloy as substrate in periodic immersion environment was explored, fatigue performance tests were carried out on samples under different pre-corroded time. According to the three empirical parameters, the S-N curves of samples were fitted by S-N curve fitting method, and the influence of pre-corrosion on the fatigue life of joints was analyzed. In addition, the fatigue fracture was observed by scanning electron microscopy to study the damage characteristics and the micro fatigue failure mechanism of the joints. The results show that pre-corrosion can cause multiple fatigue sources on the joint and accelerate the crack pro-pagation, fatigue cracks of joints are easy to initiate at the defects caused by pre-corrosion. There is a competitive relationship between corrosion damage and mechanical damage during the tests, pre-corrosion significantly affects the fatigue life of joints at low stress levels. In general, the fatigue life of the joint decreases with the increase of the pre-corrosion time. Fatigue failure patterns of the joint include the fracture of the lower plate in the riveting region and the fracture of the lower plate on side of the riveting region. The fatigue source fracture of the joint emerges the characteristics of quasi-cleavage fracture.
Key words:  self-piercing riveting (SPR)    AA5052-O aluminum alloy    periodical immersed corrosion    fracture morphology    fatigue property
               出版日期:  2019-09-25      发布日期:  2019-07-31
ZTFLH:  TG405  
基金资助: 国家自然科学基金(51565022);国家自然科学基金青年基金(51565023)
通讯作者:  xiaocong_he@126.com   
作者简介:  丁文有,2019年6月毕业于昆明理工大学,获得工程硕士学位,主要从事薄板材料连接新技术领域的研究。
何晓聪,工学博士,教授,博士生导师,昆明理工大学创新制造技术研究所所长。2003年获得英国曼彻斯特大学博士学位,主要从事薄板材料连接新技术,机械系统绿色设计制造领域的研究,在国内外重要期刊发表文章200多篇。
引用本文:    
丁文有, 何晓聪, 刘佳沐, 刘洋. 预腐蚀对夹层结构自冲铆接头疲劳特性的影响[J]. 材料导报, 2019, 33(18): 3089-3095.
DING Wenyou, HE Xiaocong, LIU Jiamu, LIU Yang. Effect of Pre-corrosion on Fatigue Performance of Sandwich Structure Self-piercing Riveted Joint. Materials Reports, 2019, 33(18): 3089-3095.
链接本文:  
http://www.mater-rep.com/CN/10.11896/cldb.18080064  或          http://www.mater-rep.com/CN/Y2019/V33/I18/3089
[1] Guo R C, Wu N, Zhang G R. Advanced Materials Research, 2011, 341-342,226.
[2] Zhao L, He X, Xing B, et al. Journal of Materials Processing Technology, 2017, 249,246.
[3] Hirsch F, Müller S, Machens M, et al. Journal of Materials Processing Technology, 2017, 241(3),164.
[4] Calabrese L, Bonaccorsi L, Proverbio E, et al. Materials & Design, 2013, 46(46),849.
[5] Zuo F J. Research on fatigue life prediction and reliability methods of mechanical structures. Master’s Thesis, University of Electronic Science and Technology, China, 2016(in Chinese).左芳君. 机械结构的疲劳寿命预测与可靠性方法研究. 硕士学位论文,电子科技大学, 2016.
[6] Calabrese L, Proverbio E, Bella G D, et al. Engineering Structures, 2015, 82,33.
[7] Calabrese L, Proverbio E, Pollicino E, et al. British Corrosion Journal, 2015, 50(1),10.
[8] Huang L, Shi Y, Guo H, et al. International Journal of Fatigue, 2016, 88,96.
[9] Zhao L, He X, Xing B, et al. Materials & Design, 2015, 87,1010.
[10] Ling D. Weibull distribution model and its application in mechanical relia-bility. Master’s Thesis, University of Electronic Science and Technology, China, 2011(in Chinese).凌丹. 威布尔分布模型及其在机械可靠性中的应用研究. 硕士学位论文, 电子科技大学, 2011.
[11] Tan X F, Xie L Y, Ma H Y, et al. Acta Aeronautica et Astronautica Sinica, 2017, 38(2),171(in Chinese).谭秀峰, 谢里阳, 马洪义,等. 航空学报, 2017, 38(2),171.
[12] Gao Z T, Fu H M, Liang M X. Journal of Beijing University of Aeronautics and Astronautics, 1987(1),120(in Chinese).高镇同, 傅惠民, 梁美训. 北京航空航天大学学报, 1987(1),120.
[13] Zhong Q P, Zhao Z H. Fractography, Higher Education Press, China, 2006(in Chinese).钟群鹏, 赵子华. 断口学, 高等教育出版社, 2006.
[14] Zhou R X.Configuration forces between cracks and inclusions and shielding effect of mode II crack tip plastic zone. Master’s Thesis, Shanghai Jiao Tong University, China, 2012(in Chinese).周荣欣. 裂纹与夹杂之间的构型力及Ⅱ型裂纹裂尖塑性区的屏蔽效应. 硕士学位论文,上海交通大学,2012.
[15] Ding W Y, He X C, Xing B Y, et al. Ordnance Materials Science and Engineering, 2018,41(3),81(in Chinese).丁文有,何晓聪,邢保英,等. 兵器材料科学与工程,2018,41(3),81.
[1] 邓云华, 陶军, 马旭颐. TC4钛合金刚性拘束热自压扩散连接接头疲劳性能分析[J]. 材料导报, 2019, 33(9): 1449-1454.
[2] 黎国猛, 梁益龙, 范航京, 张雄菲, 朱勇. 水射流喷丸预处理对42CrMo钢氮化后接触疲劳性能的影响[J]. 材料导报, 2019, 33(18): 3107-3112.
[3] 靳文豪, 邢保英, 何晓聪, 曾凯, 余康. 不同腐蚀环境下铝合金自冲铆接头静力学性能研究[J]. 材料导报, 2019, 33(16): 2725-2728.
[4] 吕政桦, 申爱琴, 李悦, 郭寅川, 喻沐阳. 基于遗传优化的乳化沥青冷再生混合料的疲劳性能及机理研究[J]. 材料导报, 2019, 33(16): 2704-2709.
[5] 刘洋, 庄蔚敏, 施宏达. 自冲铆接头疲劳性能影响因素研究进展[J]. 材料导报, 2019, 33(11): 1825-1830.
[6] 赵伦, 何晓聪, 张先炼, 丁燕芳, 刘洋, 邓聪. TA1钛合金自冲铆接头力学性能及微动行为[J]. 材料导报, 2018, 32(20): 3579-3583.
[7] 王志远, 邢志国, 王海斗, 李国禄, 刘珂璟, 邢壮. 重载齿轮弯曲疲劳寿命测试方法研究现状[J]. 材料导报, 2018, 32(17): 3051-3059.
[8] 刘洋, 何晓聪, 邢保英, 邓聪, 张先炼. 泡沫金属夹层板自冲铆接头的疲劳性能及失效机理[J]. 《材料导报》期刊社, 2018, 32(14): 2431-2436.
[9] 赵伦, 何晓聪, 张先炼, 张龙, 高爱凤. 轻合金自冲铆微动磨损及疲劳性能研究[J]. 《材料导报》期刊社, 2017, 31(6): 72-75.
[10] 张越, 何晓聪, 张龙, 张先炼. 钛合金压印接头疲劳性能与微观分析[J]. 《材料导报》期刊社, 2017, 31(6): 81-85.
[11] 高古辉, 桂晓露, 谭谆礼, 白秉哲. Mn-Si-Cr系无碳化物贝氏体/马氏体复相高强钢的研究进展*[J]. 《材料导报》期刊社, 2017, 31(21): 74-81.
[12] 张先炼, 何晓聪, 赵伦, 邢保英, 程强. TA1异质自冲铆接头力学性能及失效机理*[J]. 《材料导报》期刊社, 2017, 31(20): 92-95.
[13] 赵伦, 何晓聪, 张先炼, 张龙, 程强. TA1钛合金单搭自冲铆接头微动磨损机理*[J]. 《材料导报》期刊社, 2017, 31(2): 73-76.
[14] 崔海坡, 张梦雪, 张阿龙. 碳纤维复合材料假脚冲击后疲劳性能影响因素分析*[J]. 《材料导报》期刊社, 2017, 31(18): 150-154.
[15] 赵伦, 何晓聪, 邢保英, 张先炼, 邰加琪. 铝合金自冲铆接微动行为研究*[J]. 《材料导报》期刊社, 2017, 31(14): 105-108.
[1] Dongyong SI, Guangxu HUANG, Chuanxiang ZHANG, Baolin XING, Zehua CHEN, Liwei CHEN, Haoran ZHANG. Preparation and Electrochemical Performance of Humic Acid-based Graphitized Materials[J]. Materials Reports, 2018, 32(3): 368 -372 .
[2] Ming HE,Yao DOU,Man CHEN,Guoqiang YIN,Yingde CUI,Xunjun CHEN. Preparation and Characterization of Feather Keratin/PVA Composite Nanofibrous Membranes by Electrospinning[J]. Materials Reports, 2018, 32(2): 198 -202 .
[3] Xu LI,Ziru WANG,Li YANG,Zhendong ZHANG,Youting ZHANG,Yifan DU. Synthesis and Performance of Magnetic Oil Absorption Material with Rice Chaff Support[J]. Materials Reports, 2018, 32(2): 219 -222 .
[4] ZHANG Wenpei, LI Huanhuan, HU Zhili, QIN Xunpeng. Progress in Constitutive Relationship Research of Aluminum Alloy for Automobile Lightweighting[J]. Materials Reports, 2017, 31(13): 85 -89 .
[5] JIN Chenxin, XU Guojun, LIU Liekai, YUE Zhihao, LI Xiaomin,TANG Hao, ZHOU Lang. Effects of Bulk Electrical Resistivity and Doping Type of Silicon on the Electrochemical Performance of Lithium-ion Batteries with Silicon/Graphite Anodes[J]. Materials Reports, 2017, 31(22): 10 -14 .
[6] QI Yaping, LUO Faliang, WANG Kezhi, SHEN Zhiyuan, WU Xuejian, WANG Diran. Effect of TMC-300 on the Performance of PLLA/PPC Alloy[J]. Materials Reports, 2018, 32(10): 1672 -1677 .
[7] Huimin PAN,Jun FU,Qingxin ZHAO. Sulfate Attack Resistance of Concrete Subjected to Disturbance in Hardening Stage[J]. Materials Reports, 2018, 32(2): 282 -287 .
[8] LI Jiawei, LI Dayu, GU Yixin, XIAO Jinkun, ZHANG Chao, ZHANG Yanjun. Research Progress of Regulating Anatase Phase of TiO2 Coatings Deposited by Thermal Spray[J]. Materials Reports, 2017, 31(3): 26 -31 .
[9] ZHANG Le, ZHOU Tianyuan, CHEN Hao, YANG Hao, ZHANG Qitu, SONG Bo, WONG Chingping. Advances in Transparent Nd∶YAG Laser Ceramics[J]. Materials Reports, 2017, 31(13): 41 -50 .
[10] Bingwei LUO,Dabo LIU,Fei LUO,Ye TIAN,Dongsheng CHEN,Haitao ZHOU. Research on the Two Typical Infrared Detection Materials Serving at Low Temperatures: a Review[J]. Materials Reports, 2018, 32(3): 398 -404 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed