Please wait a minute...
《材料导报》期刊社  2018, Vol. 32 Issue (10): 1618-1622    https://doi.org/10.11896/j.issn.1005-023X.2018.10.009
  材料研究 |
镍铝青铜基冷喷涂Cu402F与Cu涂层的力学性能
陈正涵,孙晓峰,李占明,史玉鹏
陆军装甲兵学院装备维修与再制造工程系,北京 100072
Mechanical Properties of Cold Sprayed Cu402F and Cu Coating Deposited on Nickel Aluminum Bronze
CHEN Zhenghan, SUN Xiaofeng, LI Zhanming, SHI Yupeng
Department of Equipment Maintenance and Remanufacturing, Academy of Armored Forces Engineering, Beijing 100072
下载:  全 文 ( PDF ) ( 5425KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 针对镍铝青铜合金在实际工况中的常见失效形式,采用冷喷涂技术在镍铝青铜9442合金上制备了紫铜和Cu402F修复涂层。使用OM以及SEM观察了涂层表面与截面的微观形貌,使用XRD对涂层进行表征,使用拉伸试验机、纳米压痕试验仪、摩擦磨损试验机测试了涂层的结合强度、显微硬度、弹性模量和摩擦学性能。结果表明:冷喷涂Cu402F涂层和紫铜涂层较为致密,厚度约为900 μm;Cu402F涂层和紫铜涂层平均结合强度分别为34.37 MPa和18.6 MPa,显微硬度分别为5.79 GPa、 2.11 GPa,弹性模量分别为198.23 GPa、138.54 GPa;Cu402F涂层摩擦系数、磨损率较低,减摩耐磨性能优于紫铜涂层。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
陈正涵
孙晓峰
李占明
史玉鹏
关键词:  镍铝青铜  冷喷涂  力学性能    
Abstract: Aiming at common failure modes of nickel aluminum bronze propeller in actual working condition, copper and Cu402F coating were deposited on nickel aluminum bronze 9442# alloy by cold spraying. Surface and cross-section morphology of coating were observed by OM and SEM; the phases of coating were tested by XRD; bonding strength, micro-hardness, elasticity modulus and tribologic properties were analyzed by tensile testing machine, nano indentation testing machine and friction and wear tester. The results revealed that Cu402F and copper coating was compact, which were 900 μm, the average bonding strength were 34.37 MPa and 18.6 MPa, micro-hardness were 5.79 GPa and 2.11 GPa, and elasticity modulus were 198.23 GPa and 138.54 GPa respectively. Friction coefficient and wear rate of Cu402F coating were lower, tribology properties was better than copper coating.
Key words:  nickel aluminum bronze    cold spray    mechanical property
               出版日期:  2018-05-25      发布日期:  2018-07-06
ZTFLH:  TB301  
基金资助: 军队科研基金项目
通讯作者:  孙晓峰:通信作者,男,1977年生,博士,副研究员,主要研究方向为材料加工工程 E-mail:sxfll9999@126.com   
作者简介:  陈正涵:1993年生,硕士研究生,主要研究方向为材料加工工程 E-mail:czhmaterial@foxmail.com
引用本文:    
陈正涵,孙晓峰,李占明,史玉鹏. 镍铝青铜基冷喷涂Cu402F与Cu涂层的力学性能[J]. 《材料导报》期刊社, 2018, 32(10): 1618-1622.
CHEN Zhenghan, SUN Xiaofeng, LI Zhanming, SHI Yupeng. Mechanical Properties of Cold Sprayed Cu402F and Cu Coating Deposited on Nickel Aluminum Bronze. Materials Reports, 2018, 32(10): 1618-1622.
链接本文:  
http://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2018.10.009  或          http://www.mater-rep.com/CN/Y2018/V32/I10/1618
1 刘道新.材料的腐蚀与防护[M].西安:西北工业大学出版社,2006:307.
2 Guo Zeliang, Fang Liang, Tang Wenxin. A review of corrosion properties of copper-alloys used in seawater pumps[J]. Materials Review,2003,17(8):22(in Chinese).
郭泽亮,方亮,汤文新.海水泵用铜合金的腐蚀性能评述[J].材料导报,2003,17(8):22.
3 Sun Feilong, Li Xiaogang, Lu Lin,et al. Corrosion behavior of copper alloys in deep ocean environment of South China Sea[J]. Acta Metallurgica Sinica,2013,49(10):1211.
4 Ji Yangyang, Tian Guizhong, Zhou Honggen. Development and present situation of marine propeller advance manufacturing techno-logy[J]. Ship Science and Technology,2015,37(5):9(in Chinese).
季洋阳,田桂中,周宏根.船用螺旋桨先进制造技术研究进展[J].舰船科学技术,2015,37(5):9.
5 兰现卿,韦玮,谭洪武,等.船舶铜质螺旋桨的修复技术[J].黄河水利职业技术学院学报,2011,23(1):24.
6 Zou Jiasheng, Luo Xinfeng, Ji Zuchun, et al. Study on welding properties of copper alloy for warship propeller[J]. Journal of Jiangsu University of Science and Technology (Natural Science Edition),2006,20(3):81(in Chinese).
邹家生,罗新峰,姬祖春,等.舰船螺旋桨用铜合金焊接性研究[J].江苏科技大学学报(自然科学版),2006,20(3):81.
7 Li C J. The state-of-art of research and development on cold spraying in China[J]. China Surface Engineering,2009,22(4):5(in Chinese).
李长久.中国冷喷涂研究进展[J].中国表面工程,2009,22(4):5.
8 Lupoi R, O'Neill W. Powder stream characteristics in cold spray nozzles [J]. Surface & Coatings Technology,2011,206(6):1069.
9 Kumar S, Arjuna Rao A. Influence of coating defects on the corrosion behavior of cold sprayed refractory metals[J]. Applied Surface Science,2017,396:760.
10 Assadi H, Kreye H, Gartner F. Cold spray—A materials perspective[J]. Acta Materialia,2016,116:382.
11 Chen Sida. Repair technology of copper alloy properller[J]. China Ship Repairing,1996(5):7(in Chinese).
陈斯达.铜合金螺旋桨修理技术[J].中国修船,1996(5):7.
12 Hedda Nordby Krogstad, Roy Johnsen. Corrosion properties of nickel-aluminium bronze in natural seawater—Effect of galvanic coupling to UNS S31603[J]. Corrosion Science,2017,121:43.
13 Li Wenya, Li Changjiu, Wang Yuyue, et al. Eeffct of parameters of cold sprayed Cu particles on its impacting behavior[J]. Acta Metallurgica Sinica,2005,41(3):282(in Chinese).
李文亚,李长久,王豫跃,等.冷喷涂Cu粒子参量对其碰撞变形行为的影响[J].金属学报,2005,41(3):282.
14 Zhang Huabing. Behaviors of particles and microstructures, mecha-nical properties of coating in cold spray[D]. Shanghai: Shanghai Jiao Tong University,2006(in Chinese).
章华兵.冷喷涂粒子变形结合行为及涂层组织力学性能研究[D].上海:上海交通大学,2006.
15 刘家浚.材料磨损原理及其耐磨性[M].北京:清华大学出版社,1993:53.
[1] 刘印, 王昌, 于振涛, 盖晋阳, 曾德鹏. 医用镁合金的力学性能研究进展[J]. 材料导报, 2019, 33(z1): 288-292.
[2] 张长亮, 卢一平. 氮元素对Ti2ZrHfV0.5Mo0.2高熵合金组织及力学性能的影响[J]. 材料导报, 2019, 33(z1): 329-331.
[3] 晁代义, 徐仁根, 孙有政, 赵巍, 吕正风, 程仁策, 邵文柱. 850 ℃时效处理对2205双相不锈钢组织与力学性能的影响[J]. 材料导报, 2019, 33(z1): 369-372.
[4] 任秀秀, 朱一举, 赵省向, 韩仲熙, 姚李娜. 四种含能晶体微观力学性能与摩擦性能的关系[J]. 材料导报, 2019, 33(z1): 448-452.
[5] 薛晓武, 王新闻, 刘红波, 卿宁. 水性聚碳酸酯型聚氨酯的制备及性能[J]. 材料导报, 2019, 33(z1): 488-490.
[6] 杨康, 赵为平, 赵立杰, 梁宇, 薛继佳, 梅莉. 固化湿度对复合材料层合板力学性能的影响与分析[J]. 材料导报, 2019, 33(z1): 223-224.
[7] 平学龙, 符寒光, 孙淑婷. 激光熔覆制备硬质颗粒增强镍基合金复合涂层的研究进展[J]. 材料导报, 2019, 33(9): 1535-1540.
[8] 薛翠真, 申爱琴, 郭寅川. 基于孔结构参数的掺CWCPM混凝土抗压强度预测模型的建立[J]. 材料导报, 2019, 33(8): 1348-1353.
[9] 孙娅, 吴长军, 刘亚, 彭浩平, 苏旭平. 合金元素对CoCrFeNi基高熵合金相组成和力学性能影响的研究现状[J]. 材料导报, 2019, 33(7): 1169-1173.
[10] 李响, 毛萍莉, 王峰, 王志, 刘正, 周乐. 长周期有序堆垛相(LPSO)的研究现状及在镁合金中的作用[J]. 材料导报, 2019, 33(7): 1182-1189.
[11] 郭丽萍, 谌正凯, 陈波, 杨亚男. 生态型高延性水泥基复合材料的可适性设计理论与可靠性验证Ⅰ:可适性设计理论[J]. 材料导报, 2019, 33(5): 744-749.
[12] 赵立臣, 谢宇, 张喆, 王铁宝, 王新, 崔春翔. ZnO纳米棒/多孔锌泡沫的制备及其压缩和抗菌性能[J]. 材料导报, 2019, 33(4): 577-581.
[13] 何秀兰, 杜闫, 巩庆东, 郑威, 柳军旺. 凝胶-发泡法制备多孔Al2O3陶瓷及其力学性能[J]. 材料导报, 2019, 33(4): 607-610.
[14] 董天顺, 郑晓东, 李国禄, 王海斗, 周秀锴, 李亚龙. 大气等离子喷涂Fe基涂层及其氩弧重熔层的组织与力学性能[J]. 材料导报, 2019, 33(4): 678-683.
[15] 高文杰, 杨自春, 李昆锋, 费志方, 陈国兵, 赵爽. 聚酰亚胺纤维增强SiO2气凝胶的制备及表征[J]. 材料导报, 2019, 33(4): 714-718.
[1] Bingwei LUO,Dabo LIU,Fei LUO,Ye TIAN,Dongsheng CHEN,Haitao ZHOU. Research on the Two Typical Infrared Detection Materials Serving at Low Temperatures: a Review[J]. Materials Reports, 2018, 32(3): 398 -404 .
[2] Huimin PAN,Jun FU,Qingxin ZHAO. Sulfate Attack Resistance of Concrete Subjected to Disturbance in Hardening Stage[J]. Materials Reports, 2018, 32(2): 282 -287 .
[3] Siyuan ZHOU,Jianfeng JIN,Lu WANG,Jingyi CAO,Peijun YANG. Multiscale Simulation of Geometric Effect on Onset Plasticity of Nano-scale Asperities[J]. Materials Reports, 2018, 32(2): 316 -321 .
[4] Xu LI,Ziru WANG,Li YANG,Zhendong ZHANG,Youting ZHANG,Yifan DU. Synthesis and Performance of Magnetic Oil Absorption Material with Rice Chaff Support[J]. Materials Reports, 2018, 32(2): 219 -222 .
[5] Ninghui LIANG,Peng YANG,Xinrong LIU,Yang ZHONG,Zheqi GUO. A Study on Dynamic Compressive Mechanical Properties of Multi-size Polypropylene Fiber Concrete Under High Strain Rate[J]. Materials Reports, 2018, 32(2): 288 -294 .
[6] XU Zhichao, FENG Zhongxue, SHI Qingnan, YANG Yingxiang, WANG Xiaoqi, QI Huarong. Microstructure of the LPSO Phase in Mg98.5Zn0.5Y1 Alloy Prepared by Directional Solidification and Its Effect on Electromagnetic Shielding Performance[J]. Materials Reports, 2018, 32(6): 865 -869 .
[7] ZHOU Rui, LI Lulu, XIE Dong, ZHANG Jianguo, WU Mengli. A Determining Method of Constitutive Parameters for Metal Powder Compaction Based on Modified Drucker-Prager Cap Model[J]. Materials Reports, 2018, 32(6): 1020 -1025 .
[8] WANG Tong, BAO Yan. Advances on Functional Polyacrylate/Inorganic Nanocomposite Latex for Leather Finishing[J]. Materials Reports, 2017, 31(1): 64 -71 .
[9] HUANG Dajian, MA Zonghong, MA Chenyang, WANG Xinwei. Preparation and Properties of Gelatin/Chitosan Composite Films Enhanced by Chitin Nanofiber[J]. Materials Reports, 2017, 31(8): 21 -24 .
[10] YUAN Xinjian, LI Ci, WANG Haodong, LIANG Xuebo, ZENG Dingding, XIE Chaojie. Effects of Micro-alloying of Chromium and Vanadium on Microstructure and Mechanical Properties of High Carbon Steel[J]. Materials Reports, 2017, 31(8): 76 -81 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed