Please wait a minute...
材料导报  2021, Vol. 35 Issue (20): 20087-20091    https://doi.org/10.11896/cldb.20080286
  金属与金属基复合材料 |
交变荷载和氯盐环境作用下钢绞线的腐蚀疲劳性能研究
喻宣瑞, 姚国文, 范伟庆
重庆交通大学土木工程学院,重庆 400074
Experimental on the Corrosion Fatigue Behavior of Steel Strands Under the Couple Effect of Variable Load and Choride Environment
YU Xuanrui, YAO Guowen, FAN Weiqing
School of Civil Engineering, Chongqing Jiaotong University, Chongqing 400074, China
下载:  全 文 ( PDF ) ( 4456KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 为探寻交变荷载和氯盐环境对拉索中各钢绞线力学性能的影响,进而预测不同腐蚀区绞线的疲劳寿命,本研究通过盐雾腐蚀试验来模拟钢绞线在交变荷载和氯盐环境共同作用下的腐蚀情况,考虑不同应力幅对钢绞线腐蚀疲劳寿命的影响,并运用灰度处理方法,对钢绞线腐蚀程度进行量化分区,便于分析不同腐蚀区钢绞线的破坏模式。研究结果表明:拉索外侧钢绞线比拉索内侧钢绞线更容易腐蚀,其腐蚀程度与所施加应力幅相关,应力幅越大,钢绞线腐蚀程度越高,开裂韧性值越低,易发生脆性破坏。随着应力幅值降低,钢绞线开裂韧性值提高,钢绞线破坏模式由脆性破坏转变为延性破坏。此外,通过疲劳试验,基于三参数法,提出不同腐蚀程度的钢绞线的疲劳寿命预测模型,为进一步探究拉索疲劳腐蚀机理提供参考。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
喻宣瑞
姚国文
范伟庆
关键词:  交变荷载  氯盐环境  钢绞线  腐蚀疲劳寿命  灰度理论  破坏模式    
Abstract: In order to explore the effects caused by variable load and chloride environment on the mechanical properties of each steel strand in cables even to predict their corrosion fatigue life. In this paper, a salt spray corrosion test is set up to simulate the corrosion process of steel strands under the couple effect of chloride environment and variable load with different stress amplitude. and the corrosion laws of steel strands are obtained by proposing grayscale analysis on the cables. The corrosion degrees of the steel strands are divided according to the gray treatment solution. The results show that The steel strand outside of the cable is more likely to corrode than the steel strand inside of the cable,and the corrosion degree is related to the stress amplitude. with the stress amplitude applied on the steel strand increased, the corrosion degree of wires seemed to be se-riously, the cracking toughness is lower than before, and the brittleness failure is easy to occur. With the decrease of stress amplitude, the crac-king toughness of steel strand increases, and the failure mode of steel strand will be changed from brittle failure mode to ductile failure mode. Additionally, the steel strands corrosion fatigue predicted model of different corrosion grades are obtained by the three-parameter method, which contributes to the prediction and evaluation of the fatigue life of corrosion cables.
Key words:  the variable load    the chlorine salt environment    steel strands    fatigue corrosion life    the gray scale theory    the failure mode
               出版日期:  2021-10-25      发布日期:  2021-11-12
ZTFLH:  U445.7  
基金资助: 国家重点研发计划(2017YFC0806001)
通讯作者:  990020050526@cqjtu.edu.cn   
作者简介:  喻宣瑞,男,博士,重庆交通大学土木工程学院,主要从事桥梁健康检测、桥梁耐久性研究。参加万州二桥、合江大桥等监测项目,发表论文10余篇。
姚国文,博士、教授、博士研究生导师,重庆交通大学土木工程学院副院长,山区桥梁及隧道工程国家重点实验室副主任,交通运输部青年科技英才。主要从事桥梁智能建造与智慧运维、桥梁长期性能与检测加固、工程结构环境力学试验技术方面的教学与科研工作,主持国家自然科学基金重大科研仪器研制项目、面上项目等20余项国家级、省部级课题的研究,完成500余座桥梁检测、加固、设计、监控等技术服务工作,获教育部、重庆市科技进步一等奖2项,发表学术论文120余篇。
引用本文:    
喻宣瑞, 姚国文, 范伟庆. 交变荷载和氯盐环境作用下钢绞线的腐蚀疲劳性能研究[J]. 材料导报, 2021, 35(20): 20087-20091.
YU Xuanrui, YAO Guowen, FAN Weiqing. Experimental on the Corrosion Fatigue Behavior of Steel Strands Under the Couple Effect of Variable Load and Choride Environment. Materials Reports, 2021, 35(20): 20087-20091.
链接本文:  
http://www.mater-rep.com/CN/10.11896/cldb.20080286  或          http://www.mater-rep.com/CN/Y2021/V35/I20/20087
1 Mayrbaurl R M, Camo S. Journal of Bridge Engineering,2001,6(6),645.
2 Faber M H, Engelund S, Rackwitz R, et al. Structural Safety,2003,25(2),201.
3 Nakamura S, Suzumura I, Tarui K. Structural Engineering International,2012,14(1),50.
4 Rebak P B, Perez T. Engineering Structural,2017,14(1),89.
5 Yu X R, Yao G W, Gu L F, et al. Matericals,2020,2,1303.
6 Codaro E N, Nakazato R Z, Horovistiz A L. Materials Science & Engineering A,2008,10(3),189.
7 Mahmoud K M. Theoretical and Applied Fracture Mechanics,2007,48(2),152.
8 Paolo C. Experimental Mechanics,1988,28(4),346.
9 Dolly E, Wei R. Fatigue & Fracture of Engineering Materials & Structures,2000,23(7),555.
10 Yang S C, Yao G W, Zhang J Q. Advances in Mechanical Engineering,2017,9(12),168.
11 ASTIM G85-94. International helping our world work better, West Conshohocken, PA, USA,2011.
12 Xu J, Chen W. Journal of Constructional Steel Research,2013,85,40.
13 Zheng X L, Xie X, Li X Z, et al. Journal of Civil Engineering,2017,3,105.
[1] 杨燕, 谭康豪, 覃英宏. 混凝土内氯离子扩散影响因素的研究综述[J]. 材料导报, 2021, 35(13): 13109-13118.
[2] 方文, 王海宾, 张朝磊, 王宏斌, 马晓艺. 预应力钢绞线用大规格82B盘条冬季时效期的系统控制[J]. 材料导报, 2019, 33(14): 2408-2412.
[3] 杨世聪,姚国文,张劲泉,史康. 加速盐雾环境中钢绞线的腐蚀疲劳特征[J]. 《材料导报》期刊社, 2018, 32(12): 1988-1993.
[4] 杨医博, 杨凯越, 吴志浩, 林少群, 丘广宏, 燕哲, 彭章锋, 林燕姿, 郭文瑛, 王恒昌. 配筋超高性能混凝土用作免拆模板对短柱力学性能影响的实验研究*[J]. CLDB, 2017, 31(23): 120-124.
[1] Wei ZHOU, Xixi WANG, Yinlong ZHU, Jie DAI, Yanping ZHU, Zongping SHAO. A Complete Review of Cobalt-based Electrocatalysts Applying to Metal-Air Batteries and Intermediate-Low Temperature Solid Oxide Fuel Cells[J]. Materials Reports, 2018, 32(3): 337 -356 .
[2] Yanzhen WANG, Mingming CHEN, Chengyang WANG. Preparation and Electrochemical Properties Characterization of High-rate SiO2/C Composite Materials[J]. Materials Reports, 2018, 32(3): 357 -361 .
[3] Yimeng XIA, Shuai WU, Feng TAN, Wei LI, Qingmao WEI, Chungang MIN, Xikun YANG. Effect of Anionic Groups of Cobalt Salt on the Electrocatalytic Activity of Co-N-C Catalysts[J]. Materials Reports, 2018, 32(3): 362 -367 .
[4] Dongyong SI, Guangxu HUANG, Chuanxiang ZHANG, Baolin XING, Zehua CHEN, Liwei CHEN, Haoran ZHANG. Preparation and Electrochemical Performance of Humic Acid-based Graphitized Materials[J]. Materials Reports, 2018, 32(3): 368 -372 .
[5] Huanchun WU, Fei XUE, Chengtao LI, Kewei FANG, Bin YANG, Xiping SONG. Fatigue Crack Initiation Behaviors of Nuclear Power Plant Main Pipe Stainless Steel in Water with High Temperature and High Pressure[J]. Materials Reports, 2018, 32(3): 373 -377 .
[6] Miaomiao ZHANG,Xuyan LIU,Wei QIAN. Research Development of Polypyrrole Electrode Materials in Supercapacitors[J]. Materials Reports, 2018, 32(3): 378 -383 .
[7] Qingshun GUAN,Jian LI,Ruyuan SONG,Zhaoyang XU,Weibing WU,Yi JING,Hongqi DAI,Guigan FANG. A Survey on Preparation and Application of Aerogels Based on Nanomaterials[J]. Materials Reports, 2018, 32(3): 384 -390 .
[8] Yunzi LIU,Wei ZHANG,Zhanyong SONG. Technological Advances in Preparation and Posterior Treatment of Metal Nanoparticles-based Conductive Inks[J]. Materials Reports, 2018, 32(3): 391 -397 .
[9] Bingwei LUO,Dabo LIU,Fei LUO,Ye TIAN,Dongsheng CHEN,Haitao ZHOU. Research on the Two Typical Infrared Detection Materials Serving at Low Temperatures: a Review[J]. Materials Reports, 2018, 32(3): 398 -404 .
[10] Lanyan LIU,Jun SONG,Bowen CHENG,Wenchi XUE,Yunbo ZHENG. Research Progress in Preparation of Lignin-based Carbon Fiber[J]. Materials Reports, 2018, 32(3): 405 -411 .
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed