Please wait a minute...
《材料导报》期刊社  2018, Vol. 32 Issue (10): 1707-1710    https://doi.org/10.11896/j.issn.1005-023X.2018.10.026
  材料研究 |
层状双氢氧化物改善地聚物抗氯离子渗透性能研究
王爱国1,吕邦成1,段 平2,3,武悦悦2,刘开伟1
1 安徽建筑大学先进建筑材料安徽省重点实验室, 合肥230022;
2 中国地质大学材料与化学学院, 武汉 430074;
3 中国地质大学纳米矿物材料与应用教育部工程研究中心, 武汉 430074
Improved Chloride Ion Penetration Resistance of Geopolymer by Adding Calcined Layered Double Hydroxides
WANG Aiguo1, LYU Bangcheng1, DUAN Ping2,3, WU Yueyue2, LIU Kaiwei1
1 Anhui Key Laboratory of Advanced Building Materials, Anhui Jianzhu University, Hefei 230022;
2 Faculty of Materials Science and Chemistry, China University of Geosciences, Wuhan 430074;
3 Engineering Research Center of Nano-Geomaterials of Ministry of Education, China University of Geosciences, Wuhan 430074
下载:  全 文 ( PDF ) ( 2842KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 本文提出利用经煅烧处理的层状双氢氧化物(LDHs)材料的阴离子交换与结构重建特性改善地聚物抗氯离子渗透性能。借助XRD与TEM分析表征了层状双氢氧化物经煅烧和氯离子插层后组成和结构的变化,采用电位滴定仪测试了NaCl溶液浸泡后地聚物样品距表面不同深度处的氯离子浓度演变规律,并通过SEM与MIP研究了煅烧处理的层状双氢氧化物对地聚物微结构的影响。结果表明:层状双氢氧化物经煅烧处理后在NaCl溶液中可通过吸附Cl-实现层状结构复原。煅烧处理的层状双氢氧化物可以提高地聚物的抗氯离子渗透性能,其3%的掺量可以减少地聚物氯离子渗透量44%,且有利于地聚物形成密实的浆体结构。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
王爱国
吕邦成
段 平
武悦悦
刘开伟
关键词:  地聚物  氯离子渗透  层状双氢氧化物(LDHs)  煅烧    
Abstract: The present work developed a new approach to improve the chloride ion penetration resistance of geopolymer based on ion-exchange and structure regeneration of the calcined layered double hydroxides (LDHs). XRD and TEM analyses were used to characterize the changes in composition and structure of LDHs which experienced calcination and Cl- intercalation. A potentiometric titrant was employed to measure the concentration variation of chloride ions at different depths to the geopolymer specimen surface after immersion test in NaCl solution. The effect of calcined LDHs on the microstructures of geopolymer was investigated by SEM and MIP. The experimental results show that after reaction with saturated NaCl solution, the dispersed and layered structure is redisco-vered, which exhibits the structure regeneration of calcined LDHs by means of Cl- adsorption. The chloride ion concentration profile demonstrates the improved chloride ion penetration resistance which can be attributed to the addition of calcined LDHs, as 3% calcined LDHs reduces the chloride ion concentration by nearly 44%. Meanwhile, we also observed a denser microstructure in the calcined-LDHs-contained geopolymer specimen.
Key words:  geopolymer    chloride ion penetration    layered double hydroxides(LDHs)    calcination
出版日期:  2018-05-25      发布日期:  2018-07-06
ZTFLH:  TU528  
引用本文:    
王爱国,吕邦成,段 平,武悦悦,刘开伟. 层状双氢氧化物改善地聚物抗氯离子渗透性能研究[J]. 《材料导报》期刊社, 2018, 32(10): 1707-1710.
WANG Aiguo, LYU Bangcheng, DUAN Ping, WU Yueyue, LIU Kaiwei. Improved Chloride Ion Penetration Resistance of Geopolymer by Adding Calcined Layered Double Hydroxides. Materials Reports, 2018, 32(10): 1707-1710.
链接本文:  
https://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2018.10.026  或          https://www.mater-rep.com/CN/Y2018/V32/I10/1707
1 Safehian M, Ramezanianpour A A. Assessment of service life mo-dels for determination of chloride penetration into silica fume concrete in the severe marine environmental condition [J]. Construction and Building Materials,2013,48:287.
2 Diamanti M V, Brenna A, Bolzoni F, et al. Effect of polymer modified cementitious coatings on water and chloride permeability in concrete[J]. Construction and Building Materials,2013,49:720.
3 Ismail I, Bernal S A, Provis J L, et al. Influence of fly ash on the water and chloride permeability of alkali-activated slag mortars and concretes [J]. Construction and Building Materials,2013,48:1187.
4 Li X, Li C, Zhang H. Relationship between the free and total chloride diffusivity in concrete [J]. Cement and Concrete Research,2002,32(2):323.
5 Yang C, Cho S. An electrochemical method for accelerated chloride migration test of diffusion coefficient in cement-based materials [J]. Materials Chemistry and Physics,2003,81(1):116.
6 Gruber K, Ramlochan T, Boddy A, et al. Increasing concrete durability with high reactivity metakaolin[J]. Cement & Concrete Composites,2001,23(6):479.
7 Bernal J, Fenaux M, Moragues A, et al. Study of chloride penetration on concretes exposed to high-mountain weather conditions with presence of deicing salts [J]. Construction and Building Materials,2016,127:971.
8 Cavani C, Trfiro E, Vaccari A. Hydrotalcite-type anionic clays: Preparation, properties and applications [J]. Catalysis Today,1991,11(2):173.
9 Khan I A, Ohare D. Intercalation chemistry of layered double hydroxides: Recent developments and applications [J]. Journal of Materials Chemistry,2002,12:3191.
10 Carlino S. The intercalation of carboxylic acids into layered double hydroxides: A critical evaluation and review of the different methods [J]. Solid State Ionics,1997,98:73.
11 Gardner E A, Yun S K, Kwon T, et al. Layered double hydroxides pillared by macroplyoxometalates [J]. Applied Clay Science,1998,13:479.
12 Raki L, Rancourt D G, Detellier C. Preparation, characterization, and Moessbauer spectroscopy of organic anion intercalated pyroaurite-like layered double hydroxides[J]. Chemistry of Materials,1995,7:221.
13 He P G, Wang M R, Fu S, et al. Effects of Si/Al ratio on the structure and properties of metakaolin based geopolymer [J]. Ceramics International,2016,42(13):14416.
14 Zhang Z H, Provis J L, Reid A, et al. Mechanical, thermal insulation, thermal resistance and acoustic absorption properties of geopolymer foam concrete [J]. Cement & Concrete Composites,2015,62:97.
15 Zhang Z H, Provis J L, Reid A, et al. Geopolymer foam concrete: An emerging material for sustainable construction [J]. Construction and Building Materials,2014,56:113.
16 Shao N N, Liu Z, Xu Y Y, et al. Fabrication of hollow microspheres filled fly ash geopolymer composites with excellent strength and low density [J]. Materials Letters,2015,161:451.
17 Luo X, Xu J Y, Li W M, et al. Effect of alkali-activator types on the dynamic compressive deformation behavior of geopolymer concrete [J]. Materials Letters,2014,124:310.
18 Tennakoon C, Shayan A, Sanjayan J G, et al. Chloride ingress and steel corrosion in geopolymer concrete based on long term tests [J]. Materials & Design,2017,116:287.19 Badar M S, Kunal K P, Bernal S A, et al. Corrosion of steel bars induced by accelerated carbonation in low and high calcium fly ash geopolymer concretes [J]. Construction and Building Materials,2014,61:79.
20 Ren D M, Yan C J, Duan P, et al. Durability performances of wollastonite, tremolite and basalt fiber-reinforced metakaolin geopolymer composites under sulfate and chloride attack[J] Construction and Building Materials,2017,134:56.
21 Meyn M, Beneke K, Lagaly G. Anion-exchange reactions of layered double hydroxides [J]. Inorganic Chemistry,1990,29:5201.
22 Olanrewaju J, Newalkar B L, Mancino C, et al. Simplified synthesis of nitrate form of layered double hydroxide [J]. Materials Letters,2000,15(6):307.
23 Nakayama H, Wada N, Tsuhako M. Intercalation of amino acids and peptides into Mg-Al layered double hydroxide by reconstruction method [J]. International Journal of Pharmaceutics,2003,269(2):469.
24 Wang G A, Wang C C, Chen C Y. Preparation and characterization of layered double hydroxides-PMMA nanocomposites by solution polymerization [J]. Journal of Inorganic and Organometallic Polymers and Materials,2005,15(2):239.
[1] 孔德茹, 刘靖, 杨晓林, 孙冬兰, 张进康. 溶胶-凝胶-燃烧法中双功能络合剂对掺铝氧化锌性能影响的研究[J]. 材料导报, 2025, 39(1): 23100131-7.
[2] 崔潮, 李渊, 党颖泽, 王岚, 彭晖. 碱-矿渣-偏高岭土基地聚物与骨料的界面粘结机理[J]. 材料导报, 2025, 39(1): 23110101-8.
[3] 周宏元, 母崇元, 王小娟, 李润琳, 曹万林. 地聚物再生混凝土抗压强度的离散性分析[J]. 材料导报, 2025, 39(1): 23100132-8.
[4] 朱艳, 刘海龙, 贾仕奎, 李云峰, 首浩. Fe3O4/g-C3N4复合异质结的构建及紫外光降解罗丹明B[J]. 材料导报, 2024, 38(23): 23080020-7.
[5] 侯圣举, 李树国, 何超, 陈扬, 但建明, 周阳, 李相国, 吕阳. 再生微粉-电石渣制备硅酸盐水泥熟料及其水化性能研究[J]. 材料导报, 2024, 38(22): 23120044-6.
[6] 郑建岚, 王晓敏, 张建全. 含氯再生骨料混凝土抗氯离子渗透性能的研究[J]. 材料导报, 2024, 38(18): 23050208-6.
[7] 吴浪, 鲍蓉, 戴健, 雷斌. 石灰石-煅烧黏土-水泥(LC3)体系的水化动力学模型[J]. 材料导报, 2024, 38(15): 23020253-6.
[8] 宋天诣, 曲星宇, 潘竹. 地聚物的耐高温性能研究进展[J]. 材料导报, 2023, 37(8): 21060242-9.
[9] 孙滢斐, 张攀, 胡敬平, 杨家宽, 侯慧杰. 地聚物在重金属铅固化中的研究进展[J]. 材料导报, 2023, 37(7): 21080091-7.
[10] 宋学锋, 陆伟宁. 转化方式对粉煤灰地聚物原位转化沸石及其Pb2+吸附性能的影响[J]. 材料导报, 2023, 37(6): 21070249-7.
[11] 王痛快, 赵琪, 雷婷, 杨文伟. GFRP管-石粉地聚物混凝土-钢管组合短柱轴压性能研究[J]. 材料导报, 2023, 37(23): 22050256-9.
[12] 刘新宇, 刘惠, 王新杰, 朱平华, 陈春红, 周心磊. 氧化石墨烯改性地聚物再生混凝土的抗硫酸溶蚀性能研究[J]. 材料导报, 2023, 37(21): 22010212-6.
[13] 周梅, 白金婷, 郭凌志, 张玉琢. 基于响应曲面法的煤矸石地聚物注浆材料配比优化[J]. 材料导报, 2023, 37(20): 22020068-9.
[14] 梁永宸, 石宵爽, 张聪, 张滔, 王晓琪. 粉煤灰地聚物混凝土性能与环境影响的综合评价[J]. 材料导报, 2023, 37(2): 21060162-6.
[15] 樊晋源, 李茂森, 段平, 陈伟, 张祖华. 氧化石墨烯增强地聚物抗硫酸盐侵蚀性能研究[J]. 材料导报, 2023, 37(13): 22030196-5.
[1] Lanyan LIU,Jun SONG,Bowen CHENG,Wenchi XUE,Yunbo ZHENG. Research Progress in Preparation of Lignin-based Carbon Fiber[J]. Materials Reports, 2018, 32(3): 405 -411 .
[2] Haoqi HU,Cheng XU,Lijing YANG,Henghua ZHANG,Zhenlun SONG. Recent Advances in the Research of High-strength and High-conductivity CuCrZr Alloy[J]. Materials Reports, 2018, 32(3): 453 -460 .
[3] Yanchun ZHAO,Congyu XU,Xiaopeng YUAN,Jing HE,Shengzhong KOU,Chunyan LI,Zizhou YUAN. Research Status of Plasticity and Toughness of Bulk Metallic Glass[J]. Materials Reports, 2018, 32(3): 467 -472 .
[4] Xinxing ZHOU,Shaopeng WU,Xiao ZHANG,Quantao LIU,Song XU,Shuai WANG. Molecular-scale Design of Asphalt Materials[J]. Materials Reports, 2018, 32(3): 483 -495 .
[5] Yongtao TAN, Lingbin KONG, Long KANG, Fen RAN. Construction of Nano-Au@PANI Yolk-shell Hollow Structure Electrode Material and Its Electrochemical Performance[J]. Materials Reports, 2018, 32(1): 47 -50 .
[6] Ping ZHU,Guanghui DENG,Xudong SHAO. Review on Dispersion Methods of Carbon Nanotubes in Cement-based Composites[J]. Materials Reports, 2018, 32(1): 149 -158 .
[7] Fangyuan DONG,Shansuo ZHENG,Mingchen SONG,Yixin ZHANG,Jie ZHENG,Qing QIN. Research Progress of High Performance ConcreteⅠ:Raw Materials and Mix Proportion Design Method[J]. Materials Reports, 2018, 32(1): 159 -166 .
[8] Guiqin HOU,Yunkai LI,Xiaoyan WANG. Research Progress of Zinc Ferrite as Photocatalyst[J]. Materials Reports, 2018, 32(1): 51 -57 .
[9] Jianxiang DING,Zhengming SUN,Peigen ZHANG,Wubian TIAN,Yamei ZHANG. Current Research Status and Outlook of Ag-based Contact Materials[J]. Materials Reports, 2018, 32(1): 58 -66 .
[10] Jing WANG,Hongke LIU,Pingsheng LIU,Li LI. Advances in Hydrogel Nanocomposites with High Mechanical Strength[J]. Materials Reports, 2018, 32(1): 67 -75 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed