Please wait a minute...
《材料导报》期刊社  2018, Vol. 32 Issue (10): 1618-1622    https://doi.org/10.11896/j.issn.1005-023X.2018.10.009
  材料研究 |
镍铝青铜基冷喷涂Cu402F与Cu涂层的力学性能
陈正涵,孙晓峰,李占明,史玉鹏
陆军装甲兵学院装备维修与再制造工程系,北京 100072
Mechanical Properties of Cold Sprayed Cu402F and Cu Coating Deposited on Nickel Aluminum Bronze
CHEN Zhenghan, SUN Xiaofeng, LI Zhanming, SHI Yupeng
Department of Equipment Maintenance and Remanufacturing, Academy of Armored Forces Engineering, Beijing 100072
下载:  全 文 ( PDF ) ( 5425KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 针对镍铝青铜合金在实际工况中的常见失效形式,采用冷喷涂技术在镍铝青铜9442合金上制备了紫铜和Cu402F修复涂层。使用OM以及SEM观察了涂层表面与截面的微观形貌,使用XRD对涂层进行表征,使用拉伸试验机、纳米压痕试验仪、摩擦磨损试验机测试了涂层的结合强度、显微硬度、弹性模量和摩擦学性能。结果表明:冷喷涂Cu402F涂层和紫铜涂层较为致密,厚度约为900 μm;Cu402F涂层和紫铜涂层平均结合强度分别为34.37 MPa和18.6 MPa,显微硬度分别为5.79 GPa、 2.11 GPa,弹性模量分别为198.23 GPa、138.54 GPa;Cu402F涂层摩擦系数、磨损率较低,减摩耐磨性能优于紫铜涂层。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
陈正涵
孙晓峰
李占明
史玉鹏
关键词:  镍铝青铜  冷喷涂  力学性能    
Abstract: Aiming at common failure modes of nickel aluminum bronze propeller in actual working condition, copper and Cu402F coating were deposited on nickel aluminum bronze 9442# alloy by cold spraying. Surface and cross-section morphology of coating were observed by OM and SEM; the phases of coating were tested by XRD; bonding strength, micro-hardness, elasticity modulus and tribologic properties were analyzed by tensile testing machine, nano indentation testing machine and friction and wear tester. The results revealed that Cu402F and copper coating was compact, which were 900 μm, the average bonding strength were 34.37 MPa and 18.6 MPa, micro-hardness were 5.79 GPa and 2.11 GPa, and elasticity modulus were 198.23 GPa and 138.54 GPa respectively. Friction coefficient and wear rate of Cu402F coating were lower, tribology properties was better than copper coating.
Key words:  nickel aluminum bronze    cold spray    mechanical property
出版日期:  2018-05-25      发布日期:  2018-07-06
ZTFLH:  TB301  
基金资助: 军队科研基金项目
通讯作者:  孙晓峰:通信作者,男,1977年生,博士,副研究员,主要研究方向为材料加工工程 E-mail:sxfll9999@126.com   
作者简介:  陈正涵:1993年生,硕士研究生,主要研究方向为材料加工工程 E-mail:czhmaterial@foxmail.com
引用本文:    
陈正涵,孙晓峰,李占明,史玉鹏. 镍铝青铜基冷喷涂Cu402F与Cu涂层的力学性能[J]. 《材料导报》期刊社, 2018, 32(10): 1618-1622.
CHEN Zhenghan, SUN Xiaofeng, LI Zhanming, SHI Yupeng. Mechanical Properties of Cold Sprayed Cu402F and Cu Coating Deposited on Nickel Aluminum Bronze. Materials Reports, 2018, 32(10): 1618-1622.
链接本文:  
https://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2018.10.009  或          https://www.mater-rep.com/CN/Y2018/V32/I10/1618
1 刘道新.材料的腐蚀与防护[M].西安:西北工业大学出版社,2006:307.
2 Guo Zeliang, Fang Liang, Tang Wenxin. A review of corrosion properties of copper-alloys used in seawater pumps[J]. Materials Review,2003,17(8):22(in Chinese).
郭泽亮,方亮,汤文新.海水泵用铜合金的腐蚀性能评述[J].材料导报,2003,17(8):22.
3 Sun Feilong, Li Xiaogang, Lu Lin,et al. Corrosion behavior of copper alloys in deep ocean environment of South China Sea[J]. Acta Metallurgica Sinica,2013,49(10):1211.
4 Ji Yangyang, Tian Guizhong, Zhou Honggen. Development and present situation of marine propeller advance manufacturing techno-logy[J]. Ship Science and Technology,2015,37(5):9(in Chinese).
季洋阳,田桂中,周宏根.船用螺旋桨先进制造技术研究进展[J].舰船科学技术,2015,37(5):9.
5 兰现卿,韦玮,谭洪武,等.船舶铜质螺旋桨的修复技术[J].黄河水利职业技术学院学报,2011,23(1):24.
6 Zou Jiasheng, Luo Xinfeng, Ji Zuchun, et al. Study on welding properties of copper alloy for warship propeller[J]. Journal of Jiangsu University of Science and Technology (Natural Science Edition),2006,20(3):81(in Chinese).
邹家生,罗新峰,姬祖春,等.舰船螺旋桨用铜合金焊接性研究[J].江苏科技大学学报(自然科学版),2006,20(3):81.
7 Li C J. The state-of-art of research and development on cold spraying in China[J]. China Surface Engineering,2009,22(4):5(in Chinese).
李长久.中国冷喷涂研究进展[J].中国表面工程,2009,22(4):5.
8 Lupoi R, O'Neill W. Powder stream characteristics in cold spray nozzles [J]. Surface & Coatings Technology,2011,206(6):1069.
9 Kumar S, Arjuna Rao A. Influence of coating defects on the corrosion behavior of cold sprayed refractory metals[J]. Applied Surface Science,2017,396:760.
10 Assadi H, Kreye H, Gartner F. Cold spray—A materials perspective[J]. Acta Materialia,2016,116:382.
11 Chen Sida. Repair technology of copper alloy properller[J]. China Ship Repairing,1996(5):7(in Chinese).
陈斯达.铜合金螺旋桨修理技术[J].中国修船,1996(5):7.
12 Hedda Nordby Krogstad, Roy Johnsen. Corrosion properties of nickel-aluminium bronze in natural seawater—Effect of galvanic coupling to UNS S31603[J]. Corrosion Science,2017,121:43.
13 Li Wenya, Li Changjiu, Wang Yuyue, et al. Eeffct of parameters of cold sprayed Cu particles on its impacting behavior[J]. Acta Metallurgica Sinica,2005,41(3):282(in Chinese).
李文亚,李长久,王豫跃,等.冷喷涂Cu粒子参量对其碰撞变形行为的影响[J].金属学报,2005,41(3):282.
14 Zhang Huabing. Behaviors of particles and microstructures, mecha-nical properties of coating in cold spray[D]. Shanghai: Shanghai Jiao Tong University,2006(in Chinese).
章华兵.冷喷涂粒子变形结合行为及涂层组织力学性能研究[D].上海:上海交通大学,2006.
15 刘家浚.材料磨损原理及其耐磨性[M].北京:清华大学出版社,1993:53.
[1] 薛赞, 晋玺, 毛周朱, 兰爱东, 王大雨, 乔珺威. 热机械处理提高Cr47Ni33Co10Fe10多组元共晶合金力学性能[J]. 材料导报, 2025, 39(3): 23120100-6.
[2] 刘晓楠, 张春晓, 王世合, 张高展, 毛继泽, 曹少华, 刘国强. 养护制度对添加纳米SiO2超高性能混凝土动静态力学性能的影响[J]. 材料导报, 2025, 39(2): 23070188-7.
[3] 景宏君, 张超伟, 高萌, 丁仁红, 李毅民, 康明珂, 周子涵, 朱韶峰. 骨架密实型水泥稳定煤矸石级配设计与性能研究[J]. 材料导报, 2025, 39(2): 22040252-7.
[4] 曹雷刚, 侯鹏宇, 杨越, 蒙毅, 刘园, 崔岩. AlCoCrFeNix高熵合金高温热处理微观组织演变及力学性能[J]. 材料导报, 2025, 39(2): 23120247-7.
[5] 马豪达, 白银, 陈波, 葛龙甄, 白延杰, 张丰. 水胶比和橡胶掺量对砂浆力学性能及能量演化规律的影响[J]. 材料导报, 2025, 39(1): 23120226-7.
[6] 王子健, 孙舒蕾, 肖寒, 冉旭东, 陈强, 黄树海, 赵耀邦, 周利, 黄永宪. 搅拌摩擦固相沉积增材制造研究现状[J]. 材料导报, 2024, 38(9): 22100039-16.
[7] 白云官, 吉小超, 李海庆, 魏敏, 于鹤龙, 张伟. 原位合成的钛合金@CNTs粉体SPS制备TiC/Ti复合材料的微结构与性能[J]. 材料导报, 2024, 38(9): 22120175-7.
[8] 邝亚飞, 李永斌, 张艳, 陈峰华, 孙志刚, 胡季帆. SPS烧结Ni-Mn-In合金的马氏体相变和力学性能研究[J]. 材料导报, 2024, 38(9): 23110107-6.
[9] 王艳, 高腾翔, 张少辉, 李文俊, 牛荻涛. 不同形态回收碳纤维水泥基材料的力学与导电性能[J]. 材料导报, 2024, 38(9): 23010043-9.
[10] 常川川, 李菊, 李晓红, 金俊龙, 张传臣, 季亚娟. 热处理对同质异态TC17钛合金线性摩擦焊接头的影响[J]. 材料导报, 2024, 38(8): 22080152-5.
[11] 郑思铭, 李蔚, 杨函瑞, 陈松, 魏取福. 3D打印聚乳酸的改性研究与应用进展[J]. 材料导报, 2024, 38(8): 22100107-10.
[12] 郑琨鹏, 葛好升, 李正川, 刘贵应, 田光文, 王万值, 徐国华, 孙振平. 河砂与石英砂对蒸养超高性能混凝土(UHPC)性能的影响及机理[J]. 材料导报, 2024, 38(7): 22040216-6.
[13] 吕晶, 赵欢, 张金翼, 席培峰. 冻融循环作用下不同含水率灰土的细微观结构与宏观力学性能[J]. 材料导报, 2024, 38(7): 22110321-7.
[14] 刘斌, 索超, 李忠华, 蒯泽宙, 陈彦磊, 唐秀. 选区激光熔化成形铜合金研究进展[J]. 材料导报, 2024, 38(7): 22080129-11.
[15] 凌子涵, 王利卿, 张震, 赵占勇, 白培康. 镁合金电弧增材技术基本工艺及工艺因素影响综述[J]. 材料导报, 2024, 38(7): 22090013-9.
[1] Yanzhen WANG, Mingming CHEN, Chengyang WANG. Preparation and Electrochemical Properties Characterization of High-rate SiO2/C Composite Materials[J]. Materials Reports, 2018, 32(3): 357 -361 .
[2] Yimeng XIA, Shuai WU, Feng TAN, Wei LI, Qingmao WEI, Chungang MIN, Xikun YANG. Effect of Anionic Groups of Cobalt Salt on the Electrocatalytic Activity of Co-N-C Catalysts[J]. Materials Reports, 2018, 32(3): 362 -367 .
[3] Qingshun GUAN,Jian LI,Ruyuan SONG,Zhaoyang XU,Weibing WU,Yi JING,Hongqi DAI,Guigan FANG. A Survey on Preparation and Application of Aerogels Based on Nanomaterials[J]. Materials Reports, 2018, 32(3): 384 -390 .
[4] Lijing YANG,Zhengxian LI,Chunliang HUANG,Pei WANG,Jianhua YAO. Producing Hard Material Coatings by Laser-assisted Cold Spray:a Technological Review[J]. Materials Reports, 2018, 32(3): 412 -417 .
[5] Zhiqiang QIAN,Zhijian WU,Shidong WANG,Huifang ZHANG,Haining LIU,Xiushen YE,Quan LI. Research Progress in Preparation of Superhydrophobic Coatings on Magnesium Alloys and Its Application[J]. Materials Reports, 2018, 32(1): 102 -109 .
[6] Wen XI,Zheng CHEN,Shi HU. Research Progress of Deformation Induced Localized Solid-state Amorphization in Nanocrystalline Materials[J]. Materials Reports, 2018, 32(1): 116 -121 .
[7] Xing LIANG, Guohua GAO, Guangming WU. Research Development of Vanadium Oxide Serving as Cathode Materials for Lithium Ion Batteries[J]. Materials Reports, 2018, 32(1): 12 -33 .
[8] Hao ZHANG,Yongde HUANG,Yue GUO,Qingsong LU. Technological and Process Advances in Robotic Friction Stir Welding[J]. Materials Reports, 2018, 32(1): 128 -134 .
[9] Laima LUO, Mengyao XU, Xiang ZAN, Xiaoyong ZHU, Ping LI, Jigui CHENG, Yucheng WU. Progress in Irradiation Damage of Tungsten and Tungsten AlloysUnder Different Irradiation Particles[J]. Materials Reports, 2018, 32(1): 41 -46 .
[10] Fengsen MA,Yan YU,Jie ZHANG,Haibo CHEN. A State-of-the-art Review of Cytotoxicity Evaluation of Biomaterials[J]. Materials Reports, 2018, 32(1): 76 -85 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed