地质聚合物基防护涂料及其性能提升技术的研究进展

doi:10.11896/cldb.21110045

材料导报

2022, Vol. 36

Issue (19): 21110045-7 https://doi.org/10.11896/cldb.21110045

高分子与聚合物基复合材料

地质聚合物基防护涂料及其性能提升技术的研究进展

徐海燕¹, 杨雪雷¹, 王爱国¹, 朱颖灿², 刘开伟¹, 黄濛¹, 王星尧¹

1 安徽建筑大学安徽省先进建筑材料重点实验室,合肥 230022
2 南昆士兰大学未来材料中心,图文巴 4350

Research Progress of Geopolymer-based Protective Coating and Its Performance Improvement Technology

XU Haiyan¹, YANG Xuelei¹, WANG Aiguo¹, ZHU Yingcan², LIU Kaiwei¹, HUANG Meng¹, WANG Xingyao¹

1 Anhui Key Laboratory of Advanced Building Materials, Anhui Jianzhu University, Hefei 230022, China
2 Centre for Future Materials, University of Southern Queensland, Toowoomba, QLD 4350, Australia

摘要
参考文献
相关文章
推荐阅读
Metrics

下载:

全文 ( PDF ) ( 8354KB )
输出: BibTeX | EndNote (RIS)

摘要地质聚合物基防护涂料是一种以地质聚合物为成膜物质且性能优越的新型无机涂料。但硅铝质原料和激发剂种类繁多使地质聚合物基防护涂料固化成膜机理复杂,表干时间、粘结强度和耐侵蚀性存在差异,同时受环境温湿度影响较大。在工程应用中应根据实际需求及环境条件,对硅铝质原料,激发剂种类、模数及掺量,外加剂和配比等方面进行优选。同时,地质聚合物也存在一些缺点,如收缩大、易开裂和易碳化等,一定程度上也限制了其在工程中的广泛应用。本文分别阐述了高钙、低钙和无钙三种不同体系地质聚合物基防护涂料固化成膜的影响因素,详细分析了硅铝质原料、激发剂和固化条件等对地质聚合物基防护涂料表干时间、粘结强度和耐侵蚀性的影响,并针对地质聚合物基防护涂料的存在问题,阐述了硅铝质原料复掺、掺入纳米粒子、层状双金属氢氧化物(LDHs)和聚合物改性等技术措施对地质聚合物基防护涂料性能的改善作用。

	服务
	把本文推荐给朋友
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	徐海燕
	杨雪雷
	王爱国
	朱颖灿
	刘开伟
	黄濛
	王星尧

关键词: 地质聚合物基防护涂料硅铝质原料碱性激发剂提升技术

Abstract: Geopolymer-based protective coating (GPC) is a new type of inorganic coating with excellent properties and geopolymers as film forming material. However, due to the wide variety of silicon-aluminum materials and activators, the curing mechanism of GPC is complicated, with differences in surface drying time, adhesion strength and erosion resistance. Notably, the environmental temperature and humidity affect these performances. In engineering applications, actual needs and environmental conditions should be considered to optimize the selection of silica-aluminum raw materials, activator types, modulus and dosage, admixture and ratio. At the same time, geopolymers also have some disadvantages, such as high shrinkage, brittle cleavage and carbonation, which also limit its wide application in engineering to a certain extent. This article describes the influence factors of curing film formation of GPC of high calcium, low calcium and noncalcium, analyzes the effects of aluminosilicate material, activator and curing conditions on the surface drying time, adhesion strength and erosion resistance of GPC. This paper indicates the improvement effect of strategies on the performance of GPC to handle the existing problems, such as adding aluminosilicate raw materials, nanoparticles, LDHs and organic polymers.

Key words: geopolymer-based protective coating (GPC) aluminosilicate material alkali-activation improvement technology

出版日期: 2022-10-10 发布日期: 2022-10-12

ZTFLH:

TU528.041

基金资助: 国家自然科学基金(52278236;52172013);安徽省重点研究与开发计划项目(202004b11020033;202104a07020018);安徽建筑大学科研储备库培育项目(2021XMK02)

通讯作者: wag3134@126.com

作者简介: 徐海燕,安徽建筑大学教授、硕士研究生导师。2006年毕业于北京工业大学,获材料物理与化学博士学位。主持国家自然科学基金项目、教育部科学技术研究重点项目等省部级以上项目多项。主要研究方向为新型功能材料/建筑功能材料/固体废弃物综合利用。发表高水平学术论文60余篇。
王爱国,安徽建筑大学教授、硕士研究生导师。2010年毕业于南京工业大学,获材料学博士学位。主持国家自然科学基金项目、安徽省重点研发计划等省部级以上项目10余项。主要研究方向为高性能水泥基材料/建筑功能材料/固体废弃物综合利用。发表高水平学术论文80余篇。

引用本文:

徐海燕, 杨雪雷, 王爱国, 朱颖灿, 刘开伟, 黄濛, 王星尧. 地质聚合物基防护涂料及其性能提升技术的研究进展[J]. 材料导报, 2022, 36(19): 21110045-7.
XU Haiyan, YANG Xuelei, WANG Aiguo, ZHU Yingcan, LIU Kaiwei, HUANG Meng, WANG Xingyao. Research Progress of Geopolymer-based Protective Coating and Its Performance Improvement Technology. Materials Reports, 2022, 36(19): 21110045-7.

链接本文:

http://www.mater-rep.com/CN/10.11896/cldb.21110045 或 http://www.mater-rep.com/CN/Y2022/V36/I19/21110045

1 Ding Z, Li Y Y, Xu M R, et al. Construction and Building Materials, 2020, 251, 118874.
2 Afshar A, Mihut D, Baqersad J, et al. Surface and Coatings Technology, 2019, 367, 41.
3 Georgy L, Anton K, Tatiana N. Construction and Building Materials, 2021, 288, 123115.
4 Xu R S, He T S, Yang R H, et al. Construction and Building Materials, 2020, 237, 117521.
5 Cheng X W, Tang R C, Guan J P, et al. Progress in Organic Coatings, 2020, 141, 105539.
6 Min J, Park J H, Sohn H K, et al. Journal of Industrial and Engineering Chemistry, 2012, 18, 655.
7 Zheng S X, Li J H. Journal of Sol-Gel Science and Technology, 2010, 54,174.
8 Deng X R, Zhang Q H, Lei X Y, et al. Journal of Sol-Gel Science and Technology, 2015, 73, 242.
9 Li Y Z, Chen G C, Zhu S Z, et al. Bulletin of Materials Science, 2019, 42(5), 200.
10 Huang X L, Yu L, Dong Y S. Corrosion Science, 2021, 182, 109256.
11 Almutairi A L, Tayeh B A, Adesina A, et al. Case Studies in Construction Materials, 2021, 15, e00733.
12 Lo K W, Lin K L, Cheng T W, et al. Construction and Building Mate-rials, 2017, 143, 455.
13 Provis J L, Duxson P, Harrex R M, et al. Global Nest Journal, 2009, 11(2), 147.
14 Sharkawi A, Taman M, Afefy M H, et al. Structures, 2020, 27, 330.
15 Firdous R, Stephan D, Djobo J N Y. Construction and Building Mate-rials, 2018, 190, 1251.
16 Singh N B, Saxena S K, Kumar M. Materials Today, 2018, 5, 9035.
17 Zhang Z H, Yao X, Zhu H J. Applied Clay Science, 2010, 49, 1.
18 Lyu X S, Wang K T, He Y, et al. Construction and Building Materials, 2019, 214, 441.
19 Okoye F N, Durgaprasad J, Singh N B. Data in Brief, 2015, 5, 739.
20 Muhammad A A A, Khalifeh M, Agonafir M B. Journal of Petroleum Science and Engineering, 2020, 191, 107128.
21 Juengsuwattananon K, Winnefeld F, Chindaprasirt P, et al. Construction and Building Materials, 2019, 226, 406.
22 Króla M, Rożeka P, Chlebda D, et al. Solid State Sciences, 2019, 94, 114.
23 Rakhimova N R, Rakhimov R Z. Journal of Materials Research and Technology, 2018, 8(1), 1522.
24 Wang A G, Wang X Y, Sun D S, et al. Materials Reports, 2021, 35(13), 5 (in Chinese).
王爱国, 王星尧, 孙道胜, 等. 材料导报, 2021, 35(13), 5.
25 Zhang Z H. Synthesis, performances and reaction mechanism of meta-kaolin-based geopolymer. Ph. D. Thesis, Nanjing University of Technology, China, 2010 (in Chinese).
张祖华. 偏高岭土基无机聚合物的制备、性能与反应机理. 博士学位论文, 南京工业大学, 2010.
26 Luukkonen T, Abdollahejad Z, Yliniemi J, et al. Cement and Concrete Research, 2018, 103, 21.
27 Zhu Y C, Zhang Z H, Liu Y, et al. Bulletin of the Chinese Ceramic Society, 2020, 287(8), 2458 (in Chinese).
朱颖灿, 张祖华, 刘意, 等. 硅酸盐通报, 2020, 287(8), 2458.
28 Wang A G, Zheng Y, Zhang Z H, et al. Materials Reports A:Review Papers, 2019, 33(8), 2552 (in Chinese).
王爱国, 郑毅, 张祖华, 等. 材料导报:综述篇, 2019, 33(8), 2552.
29 Leong H Y, Ong D E L, Sanjayan J G. Construction and Building Mate-rials, 2016, 106, 500.
30 Hounsi A D, Lecomte-Nana G, Djétéli G, et al. Ceramics International, 2014, 40, 8953.
31 Chen X, Wang J, Zhu G R, et al. Bulletin of the Chinese Ceramic Society, 2017, 36(9), 2994 (in Chinese).
陈潇, 王杰, 朱国瑞, 等. 硅酸盐通报, 2017, 36(9), 2994.
32 Wang Y C, Zhao J P. Journal of Alloys and Compounds, 2018, 743, 108.
33 Lahoti M, Wong K K, Tan K H, et al. Materials and Design, 2018, 154, 8.
34 Fu C Q, Ye H L, Zhu K Q, et al. Cement and Concrete Composites, 2020, 114, 103721.
35 Phavongkham V, Wattanasiriwech S, Wattanasiriwech D. Ceramics International, 2021, 47(10), 13374.
36 Zheng W Z, Zou M N, Wang Y. Journal of Building Structures, 2019, 40(1), 28 (in Chinese).
郑文忠, 邹梦娜, 王英. 建筑结构学报, 2019, 40(1), 28.
37 Singh N B, Middendorf B. Construction and Building Materials, 2020, 237, 117455.
38 Cho Y K, Yoo S W, Jung S H, et al. Construction and Building Mate-rials, 2017, 145, 253.
39 Zhang D W, Zhao K F, Xie F Z, et al. Construction and Building Mate-rials, 2020, 250, 118881.
40 Bocullo V, Vitola L, Vaiciukyniene D, et al. Materials Chemistry and Physics, 2021, 258, 123846.
41 Cao D G, Su D G, Song G S. Journal of the Chinese Ceramic Society, 2004(8), 1036 (in Chinese).
曹德光, 苏达根, 宋国胜. 硅酸盐学报, 2004(8), 1036.
42 Firdous R, Stephan D. Construction and Building Materials, 2019, 219, 31.
43 Bondar D, Lynsdale C J, Milestone N B, et al. Cement and Concrete Composites, 2011, 33, 251.
44 Khan M I, Azizlin K, Sufian S, et al. Ceramics International, 2015, 41, 2794.
45 Yao X, Zhang Z H, Zhu H J, et al. Thermochimica Acta, 2009, 493, 49.
46 Duan Y F, Wang P M, Yang K R. New Building Materials, 2006(1), 22 (in Chinese).
段瑜芳, 王培铭, 杨克锐. 新型建筑材料, 2006(1), 22.
47 Kumar R, Kumar S, Mehrotra S P. Resources Conservation and Recycling,2008, 52 (2), 157.
48 Nuaklong P, Wongsa A, Sata V, et al. Heliyon, 2019, 5(9), e02513.
49 Singh B, Ishwarya G, Gupta M, et al. Construction and Building Mate-rials, 2015, 85, 78.
50 Li N, Shi C J, Wang Q, et al. Materials and Structures, 2017, 50(3), 178.
51 Arnoult M, Perronnet M, Autef A, et al. Journal of Non-Crystalline Solids, 2018, 495, 59.
52 Chang J J. Cement and Concrete Research, 2003, 33, 1005.
53 Mu S, Liu J P, Lin W, et al. Construction and Building Materials, 2017, 148, 846.
54 Songpiriyakij S, Pulngern T, Pungpremtrakul P, et al. Materials and Design, 2011, 32, 3021.
55 Chen L J, Zhang D, Xing S J, et al. New Building Materials, 2001(12), 41 (in Chinese).
陈立军, 张丹, 邢士俊, 等. 新型建筑材料, 2001(12), 41.
56 Aguirre-Guerrero A M, de Gutiérrez R M. Construction and Building Materials, 2021, 268, 121098.
57 Aguirre-Guerrero A M, Robayo-Salazar R A, Gutiérrez R M. Applied Clay Science, 2017, 135, 437.
58 Phoo-ngernkham T, Sata V, Hanjitsuwan S, et al. Construction and Buil-ding Materials, 2015, 98, 482.
59 Zhang Z H, Yao X, Zhu H J. Applied Clay Science, 2010, 49, 7.
60 Hu S G , Wang H X, Zhang G Z, et al. Cement and Concrete Composites, 2008, 30, 239.
61 Vidal L, Joussein E, Absi J, et al. Ceramics International, 2017, 43, 1819.
62 Yong S L, Feng D W, Lukey G C, et al. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2007, 302(1), 411.
63 Gupta R, Tomar A S, Mishra D, et al. Microporous and Mesoporous Materials, 2021, 317, 110995.
64 Temuujina J, Minjigmaa A, Rickard W, et al. Journal of Hazardous Materials, 2010, 180, 748.
65 Temuujina J, Minjigmaa A, Rickard W, et al. Applied Clay Science, 2009, 46, 265.
66 Huseien G F, Mirza J, Ismail M, et al. Renewable and Sustainable Energy Reviews, 2017, 80, 54.
67 Zhang H Y,Kodur V, Qi S L, et al. Cement and Concrete Composites, 2015, 58, 40.
68 Chindaprasirt P, Rattanasak U. Construction and Building Materials, 2016, 112, 956.
69 Duan P , Yan C J, Luo W J, et al. Materials Letters, 2016, 164, 172.
70 Duxson P, Provis J L, Lukey G C,et al. Cement and Concrete Research, 2007, 37, 1590.
71 Wu Y G, Lu B W, Bai T, et al. Construction and Building Materials, 2019, 224, 930.
72 Al-Majidi M H, Lampropoulos A P, Cundy A B, et al. Construction and Building Materials, 2018, 164, 603.
73 Zheng J R. New Building Materials, 2004(5), 54 (in Chinese).
郑娟荣. 新型建筑材料, 2004(5), 54.
74 Liang G W, Zhu H J, Zhang Z, et al. Construction and Building Mate-rials, 2019, 222, 872.
75 Liu H, Jing W, Qin L L, et al. Construction and Building Materials, 2022, 315, 125709
76 Watolla M B, Gluth G J G, Sturm P, et al. Journal of Ceramic Science and Technology, 2017, 8(3), 351.
77 Bhardwaj P, Gupta R, Mishra D, et al. Silicon, 2020, 12, 487.
78 Wang Y C, Zhao J P, Chen J L. Construction and Building Materials, 2020, 239, 117814
79 Rovnaník P, Šimonová H, Topolárˇ L, et al. Procedia Engineering, 2016, 151, 321.
80 Gu Y M, Fang Y H. Journal of the Chinese Ceramic Society, 2012, 40(1), 76 (in Chinese).
顾亚敏, 方永浩. 硅酸盐学报, 2012, 40(1), 76.
81 Srinivasamurthy L, Chevali V S, Zhang Z H, et al. Construction and Building Materials, 2021, 283, 122678.
82 Wang Y G, Liu X M, Zhang W, et al. Journal of Cleaner Production, 2020, 244, 118852.
83 Zhang P, Wang K X, Wang J, et al. Journal of Cleaner Production, 2021, 294, 126193.
84 Zulkifly K, Yong H C, Ming L Y, et al. Construction and Building Materials, 2021, 270, 121486.
85 Wang S F, Ma X, Zhang Z H, et al. Materials Reports B:Research Papers, 2018, 32(8), 2757 (in Chinese).
王顺风, 马雪, 张祖华, 等. 材料导报:研究篇, 2018, 32(8), 2757.
86 Babaee M, Castel A. Cement and Concrete Research, 2018, 111, 56.
87 Chen K Y, Wu D Z, Yi M, et al. Construction and Building Materials, 2021, 281, 122566.
88 Zidi Z, Ltifi M, Zafar I. Journal of Building Engineering, 2021, 33, 101586.
89 Krishnan U, Sanalkumar A, Yang E H. Cement and Concrete Composites, 2021, 115, 103847.
90 Sun K K, Peng X Q, Wang S P, et al. Construction and Building Mate-rials, 2020, 253, 118952.
91 Abbasi S M, Ahmadi H,Khalaj G, et al. Ceramics International, 2016, 42, 15171.
92 Luo Z Y, Li W G,Gan Y X,et al. Cement and Concrete Composites, 2021, 117, 103883.
93 Assaedi H, Alomayri T, Kaze C R, et al. Construction and Building Materials, 2020, 252, 119137.
94 Li F P, Liu L S, Yang Z M,et al. Journal of Hazardous Materials, 2021, 401, 123339.
95 Adak D, Sarkar M, Mandal S. Construction and Building Materials, 2014, 70, 453.
96 Wang J B, Du P, Zhou Z H, et al. Construction and Building Materials, 2019, 220, 110.
97 Khater H M, Abd el Gawaad H A. Construction and Building Materials, 2016, 102, 329.
98 Li Q. Preparation and application technology of nanomaterials, Chemical Industry Press, China, 2008, pp. 121(in Chinese).
李群. 纳米材料的制备与应用技术, 化学工业出版社, 2008, pp. 121.
99 Rashad A M. Construction and Building Materials, 2014, 52, 437.
100 Gao K,Lin K L,Wang D Y et al. Construction and Building Materials, 2014, 53, 503.
101 Qing Y, Zenan Z, Deyu K, et al. Construction and Building Materials, 2007, 21, 539.
102 Du H, Dai Pang S. Construction and Building Materials, 2019, 224, 317.
103 Phoo-ngernkham T, Chindaprasirt P, Sata V, et al. Materials and Design, 2014, 55, 58.
104 Behfarnia K, Rostami M. Construction and Building Materials, 2017, 131, 205.
105 Kai M F, Zhang L W, Liew K M. Carbon, 2020, 161, 772.
106 Fogden S, Verdejo R, Cottam B. Chemical Physics Letters, 2008, 460, 162.
107 Verdejo R, Lamoriniere S, Cottam B, et al. Chemical Communications, 2007, 43(5), 513.
108 Shao L, Tobias G, Salzmann C G, et al. Chemical Communications, 2007, 47(47), 5090.
109 Yuan J K, He P G, Jia D C, et al. Journal of the European Ceramic So-ciety, 2017, 37, 2219.
110 Zhu Y Y, Geng J, Li D. Concrete, 2019(9), 21 (in Chinese).
朱月圆, 耿健, 李东. 混凝土, 2019(9), 21.
111 Wang A G, Lyu B C, Duan P, et al. Materials Reports B:Research Papers, 2018, 32(5), 1707 (in Chinese).
王爱国, 吕邦成, 段平, 等. 材料导报:研究篇, 2018, 32(5), 1707.
112 Liu T, Chen Y X, Yu Q L, et al. Construction and Building Materials, 2020, 250, 118865.
113 Reeb C, Pierlot C, Davy C, et al. Ceramics International, 2021, 47, 7369.
114 Afridi S, Sikandar M A, Waseem M, et al. Construction and Building Materials, 2019, 217, 530.
115 Chen X, Zhu G R, Zhou M K, et al. Construction and Building Mate-rials, 2018, 167, 216.

[1]	楚英杰, 王爱国, 孙道胜, 刘开伟, 马瑞, 吴修胜, 郝发军. 骨料特性影响混凝土体积稳定性的研究进展[J]. 材料导报, 2022, 36(5): 20110088-10.
[2]	张耀君, 张叶, 韩智超, 贺攀阳, 陈浩. 地质聚合物原位转化沸石分子筛的研究进展[J]. 材料导报, 2020, 34(23): 23033-23041.
[3]	王爱国, 楚英杰, 徐海燕, 刘开伟, 马瑞, 董伟伟, 孙道胜. 碱式硫酸镁水泥的研究进展及性能提升技术[J]. 材料导报, 2020, 34(13): 13091-13099.

[1]	Wei ZHOU, Xixi WANG, Yinlong ZHU, Jie DAI, Yanping ZHU, Zongping SHAO. A Complete Review of Cobalt-based Electrocatalysts Applying to Metal-Air Batteries and Intermediate-Low Temperature Solid Oxide Fuel Cells[J]. Materials Reports, 2018, 32(3): 337 -356 .
[2]	Dongyong SI, Guangxu HUANG, Chuanxiang ZHANG, Baolin XING, Zehua CHEN, Liwei CHEN, Haoran ZHANG. Preparation and Electrochemical Performance of Humic Acid-based Graphitized Materials[J]. Materials Reports, 2018, 32(3): 368 -372 .
[3]	Yunzi LIU,Wei ZHANG,Zhanyong SONG. Technological Advances in Preparation and Posterior Treatment of Metal Nanoparticles-based Conductive Inks[J]. Materials Reports, 2018, 32(3): 391 -397 .
[4]	Bingwei LUO,Dabo LIU,Fei LUO,Ye TIAN,Dongsheng CHEN,Haitao ZHOU. Research on the Two Typical Infrared Detection Materials Serving at Low Temperatures: a Review[J]. Materials Reports, 2018, 32(3): 398 -404 .
[5]	Yingke WU,Jianzhong MA,Yan BAO. Advances in Interfacial Interaction Within Polymer Matrix Nanocomposites[J]. Materials Reports, 2018, 32(3): 434 -442 .
[6]	Zhengrong FU,Xiuchang WANG,Qinglin JIN,Jun TAN. A Review of the Preparation Techniques for Porous Amorphous Alloys and Their Composites[J]. Materials Reports, 2018, 32(3): 473 -482 .
[7]	Fangyuan DONG,Shansuo ZHENG,Mingchen SONG,Yixin ZHANG,Jie ZHENG,Qing QIN. Research Progress of High Performance ConcreteⅡ: Durability and Life Prediction Model[J]. Materials Reports, 2018, 32(3): 496 -502 .
[8]	Lixiong GAO,Ruqian DING,Yan YAO,Hui RONG,Hailiang WANG,Lei ZHANG. Microbial-induced Corrosion of Concrete: Mechanism, Influencing Factors,Evaluation Indices, and Proventive Techniques[J]. Materials Reports, 2018, 32(3): 503 -509 .
[9]	Ningning HE,Chenxi HOU,Xiaoyan SHU,Dengsheng MA,Xirui LU. Application of SHS Technique for the High-level Radioactive Waste Disposal[J]. Materials Reports, 2018, 32(3): 510 -514 .
[10]	Haoran CHEN, Yingdong XIA, Yonghua CHEN, Wei HUANG. Low-dimensional Perovskites: a Novel Candidate Light-harvesting Material for Solar Cells that Combines High Efficiency and Stability[J]. Materials Reports, 2018, 32(1): 1 -11 .

Viewed

Full text

Abstract

Cited

Shared

Discussed