Please wait a minute...
材料导报  2024, Vol. 38 Issue (17): 22060053-4    https://doi.org/10.11896/cldb.22060053
  无机非金属及其复合材料 |
涂覆时间对聚合物水泥基钢筋涂层粘接性能的影响机理
胡家宇1,2, 徐菲1, 钱文勋1,*, 肖怀前3, 葛津宇1, 李嘉明1
1 南京水利科学研究院材料结构研究所,南京 210029
2 江苏省水利建设工程有限公司,江苏 扬州 225000
3 江苏省淮沭新河管理处,江苏 淮安 223001
Mechanism of Resting Time on Bond Performance of Polymer Cement-based Coating on Steel Bar
HU Jiayu1,2, XU Fei1, QIAN Wenxun1,*, XIAO Huaiqian3, GE Jinyu1, LI Jiaming1
1 Materials & Structural Engineering Department, Nanjing Hydraulic Research Institute, Nanjing 210029, China
2 Jiangsu Water Conservancy Construction Engineering Co., Ltd., Yangzhou 225000, Jiangsu, China
3 Jiangsu Huaishuxin River Administration Bureau, Huai'an 223001, Jiangsu, China
下载:  全 文 ( PDF ) ( 8630KB )     补充信息
输出:  BibTeX | EndNote (RIS)      
摘要 为探明由涂层胶凝进程引发的界面过渡区(ITZ)物相经时演变对聚合物水泥基涂层与混凝土保护层间粘接性能的影响机理,制备丙乳与P·O 52.5水泥质量比1∶2的涂层,测试不同涂覆时间下钢筋的握裹力,分析了钢筋涂层与保护层ITZ组成物相的微观形貌及经时演化特征。研究表明:不超过3 h的涂覆时间有利于聚合物水泥基涂层与保护层ITZ中水化硅酸钙(CSH)凝胶的聚合,进而提高钢筋的粘接性能。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
胡家宇
徐菲
钱文勋
肖怀前
葛津宇
李嘉明
关键词:  聚合物水泥基涂层  界面过渡区  钢筋握裹力  CSH凝胶  微观分析    
Abstract: To investigate the influence mechanism of the phase evolution of interfacial transition zone (ITZ) caused by the coating gelation process on the bonding properties of polymer-cement based coating and concrete protective layer, a coating with a mass ratio of 1∶2 between acrylate emulsion and P·O 52.5 cement was prepared, and the bonding strength of coated steel bar under different cementing time was tested. The microstructure and time-evolution characteristics of the ITZ components in reinforcement coating and protective coating were characterized. The results show that shorter resting time (＜3 h) is beneficial to the polymerization of polymer-cement based coating and calcium silicate hydrate (CSH) between the ITZ, and then improve the bonding properties of coated steel bars.
Key words:  polymer cement-based coating    interfacial transition zone (ITZ)    bonding strength of steel bars    CSH    microscope analysis
出版日期:  2024-09-10      发布日期:  2024-09-30
ZTFLH:  TB37  
基金资助: 国家重点研发计划(2021YFB2600704);国家自然科学基金(52109161);新沂河海口枢纽水利科技项目(HKZJG-KY-01)
通讯作者:  *钱文勋,博士,正高级工程师。现任南京水利科学研究院材料结构研究所副所长,兼任中国土木工程学会混凝土及预应力混凝土分会、江苏省水力发电工程学会和南京硅酸盐学会理事,江苏省“333高层次人才培养工程”中青年科学技术带头人。长期从事水(港)工新材料的研究。主持国家“十三五”重点研发计划专项课题2项,作为专题负责人和项目负责人完成国家自然科学基金重点和面上项目各1项。参与编写《水工混凝土试验规范》《水工混凝土外加剂技术规程》等多部行业规范。wxqian@nhri.cn   
作者简介:  胡家宇,硕士,工程师。南京水利科学研究院材料结构研究所毕业,指导教师为钱文勋正高级工程师。现就职于江苏省水利建设工程有限公司,主研方向钢筋混凝土耐腐蚀新材料。发表学术论文3篇,授权发明专利1项。
引用本文:    
胡家宇, 徐菲, 钱文勋, 肖怀前, 葛津宇, 李嘉明. 涂覆时间对聚合物水泥基钢筋涂层粘接性能的影响机理[J]. 材料导报, 2024, 38(17): 22060053-4.
HU Jiayu, XU Fei, QIAN Wenxun, XIAO Huaiqian, GE Jinyu, LI Jiaming. Mechanism of Resting Time on Bond Performance of Polymer Cement-based Coating on Steel Bar. Materials Reports, 2024, 38(17): 22060053-4.
链接本文:  
https://www.mater-rep.com/CN/10.11896/cldb.22060053  或          https://www.mater-rep.com/CN/Y2024/V38/I17/22060053
1 Chen X D, Yu A P, Liu G Y, et al. Journal of Building Material, 2019, 22(6), 894(in Chinese).
陈宣东, 虞爱平, 刘光焰, 等. 建筑材料学报, 2019, 22(6), 894.
2 Li S Y, Wang Y L, Liu Z Y, et al. Journal of the Chinese Ceramic Society, 2019, 47(11), 1621(in Chinese).
李世宇, 王玉龙, 刘志勇, 等. 硅酸盐学报, 2019, 47(11), 1621.
3 Yan D M, Chen G D, Tang F J, et al. Scientia Sinica (Technologica), 2015, 45(3), 293(in Chinese).
闫东明, 陈根达, 唐福建, 等. 中国科学:技术科学, 2015, 45(3), 293.
4 Tang F, Chen G, Brow R K. Cement and Concrete Research, 2016, 82, 58.
5 Deng Y, Fan H, Zhang J. Journal of the Chinese Ceramic Society, 2008(9), 1251(in Chinese).
邓永丽, 樊慧庆, 张洁. 硅酸盐学报, 2008(9), 1251.
6 Shang H S, Wang W Z, Li X H, et al. Journal of Building Material, 2021, 24(2), 348(in Chinese).
商怀帅, 王玮钊, 刘孝华, 等. 建筑材料学报, 2021, 24(2), 348.
7 Ilango N K, Gujar P G, Nagesh A K,et al. Cement and Concrete Composites, 2021, 115, 103856.
8 Liang R, Liu Q, Hou D, et al. Cement and Concrete Research, 2022, 152, 106675.
9 Zhang G F, Wang S X, Lu X P, et al. Journal of Building Material, 2019, 22(2), 173(in Chinese).
张国防, 王顺祥, 陆小培, 等. 建筑材料学报, 2019, 22(2), 173.
10 Jo Y K, Jeong S H, Kim W K. Advanced Materials Research, 2013, 687, 175.
11 Wang M, Wang R, Zheng S, et al. Cement and Concrete Research, 2015, 69, 62,
12 Ma D D, Ma Q Y, Huang K, et al. Chinese Journal of Geotechnical Engineering, 2021, 43(3), 572(in Chinese).
马冬冬, 马芹永, 黄坤, 等. 岩土工程学报, 2021, 43(3), 572.
13 Wang L, He Z, Zhang B, et al. Journal of Building Materials, 2011, 14(4), 447(in Chinese).
王磊, 何真, 张博, 等. 建筑材料学报, 2011, 14(4), 447.
14 Zhou Y, Tang L, Liu J, et al. Cement and Concrete Research, 2019, 125, 105891.
15 Zhao L. Effect of PC modified GO on the reinforcement of cement composites. Ph. D. Thesis, Southeast University, China, 2018 (in Chinese).
赵丽. PC改性GO对水泥基复合材料的强化及其机理研究. 博士学位论文, 东南大学, 2018.
[1] 姜彦杰, 刘浩天, 刘海峰, 车佳玲, 杨维武. 硫酸盐冻融后沙漠砂混凝土单轴受压力学性能试验研究[J]. 材料导报, 2025, 39(7): 23110222-11.
[2] 夏晋, 郑宇航, 汪雨青. 基于多尺度模型的混凝土有效电阻率与几何代表尺寸研究[J]. 材料导报, 2025, 39(4): 24020001-7.
[3] 王闯闯, 庞学玉, 汪海阁, 黄贤斌, 吕开河, 孙金声. 240 ℃下水合陶瓷体系的耐高温性能及其影响因素[J]. 材料导报, 2025, 39(21): 24100050-7.
[4] 武军, 丁亚红, 郭猛, 郭书奇. 再生混凝土模型界面过渡区断裂行为与数值模拟[J]. 材料导报, 2025, 39(18): 24080157-8.
[5] 薛刚, 刘毅, 牟一飞. 基于3D细观模型的混凝土单轴拉压应力应变关系影响因素研究[J]. 材料导报, 2025, 39(15): 24060161-8.
[6] 郭寅川, 樊鹏龙, 申爱琴, 戴晓倩, 姚超, 杨雪瑞, 李震南. 轮载-动水耦合作用下玄武岩纤维路面混凝土性能衰减及机理研究[J]. 材料导报, 2025, 39(13): 24010002-8.
[7] 汪德才, 魏家伟, 胡磊, 张庆, 董是, 杨澜, 成凯. 路面基层混合料煤矸石掺配方式及耐久性试验研究[J]. 材料导报, 2025, 39(11): 24010125-10.
[8] 崔潮, 李渊, 党颖泽, 王岚, 彭晖. 碱-矿渣-偏高岭土基地聚物与骨料的界面粘结机理[J]. 材料导报, 2025, 39(1): 23110101-8.
[9] 朱本清, 余红发, 巩旭, 吴成友, 麻海燕. 除冰盐冻融作用下混凝土界面粘结强度与界面过渡区细观力学性能的关系[J]. 材料导报, 2024, 38(5): 22070190-7.
[10] 董健苗, 何其, 周铭, 王振宇, 庄佳桥, 邹明璇, 李万金. 石墨烯水泥砂浆抗碳化试验及预测模型分析[J]. 材料导报, 2024, 38(5): 22070184-6.
[11] 曹梦媛, 于素慧, 袁健, 王炜, 张少辉, 王艳. CO2养护煤矸石粗骨料性能研究[J]. 材料导报, 2024, 38(14): 23030104-8.
[12] 边晨, 郭君渊, 肖建庄, 赵长军. 纳米偏高岭土及细骨料对UHPC力学性能的影响[J]. 材料导报, 2023, 37(23): 22070261-5.
[13] 冯春花, 崔卜文, 郭晖, 张文艳, 朱建平. 水泥浆-碳化协同增强再生混凝土骨料研究[J]. 材料导报, 2023, 37(21): 22060098-5.
[14] 邱继生, 朱梦宇, 周云仙, 高徐军, 李蕾蕾. 粉煤灰对煤矸石混凝土界面过渡区的改性效应[J]. 材料导报, 2023, 37(2): 21050280-7.
[15] 朱丽华, 刘海林, 韩伟. 基于细观尺度的再生混凝土多相导热系数理论模型[J]. 材料导报, 2023, 37(12): 21110080-7.
[1] LI Jiawei, LI Dayu, GU Yixin, XIAO Jinkun, ZHANG Chao, ZHANG Yanjun. Research Progress of Regulating Anatase Phase of TiO2 Coatings Deposited by Thermal Spray[J]. Materials Reports, 2017, 31(3): 26 -31 .
[2] . Adhesion in SBS Modified Asphalt Containing Warm Mix Additive and
Aggregate System Based on Surface Free Theory[J]. Materials Reports, 2017, 31(4): 115 -120 .
[3] JIA Zhihong, WENG Yaoyao, DING Lipeng, CHENG Tao, LIU Yingying, LIU Qing. Sn Microalloying for Aluminum Alloys: Strengthening Effects and Mechanisms[J]. Materials Reports, 2017, 31(9): 123 -127 .
[4] DING Yutian, DOU Zhengyi, GAO Yubi, GAO Xin, LI Haifeng, LIU Dexue. In-situ Observation of Solidification Process of GH3625 Superalloy at Different Cooling Rates[J]. Materials Reports, 2017, 31(24): 150 -155 .
[5] JIN Chenxin, XU Guojun, LIU Liekai, YUE Zhihao, LI Xiaomin,TANG Hao, ZHOU Lang. Effects of Bulk Electrical Resistivity and Doping Type of Silicon on the Electrochemical Performance of Lithium-ion Batteries with Silicon/Graphite Anodes[J]. Materials Reports, 2017, 31(22): 10 -14 .
[6] LIU Guoyi, LIU Yuanjun, ZHAO Xiaoming. A Study on Protecting Efficiency to the Radiative Heat of the Outer Fabric for the Fire Proximity Suits[J]. Materials Reports, 2017, 31(22): 116 -120 .
[7] ZHANG Wangxi, WANG Yanzhi, LIANG Baoyan, LI Qiquan, LUO Wei, SUN Changhong, CHENG Xiaozhe, SUN Yuzhou. Review on the Development of Nanodiamonds Used as Functional Materials[J]. Materials Reports, 2018, 32(13): 2183 -2188 .
[8] CHEN Tao, XUE Songbai, SUN Zijian, ZHAI Peizhuo, CHEN Weizhong, GUO Peipei. Short-circuit Transition Control Technology for CO2 Gas Shielded Welding: Research Status and Prospect[J]. Materials Reports, 2019, 33(9): 1431 -1442 .
[9] WANG Huifen, LIU Gang, CAO Kangli, YANG Biqi, XU Jun, LAN Shaofei, ZHANG Lixin. Development Status of Carbon Nanotube Materials and Their Application Prospects in Spacecraft[J]. Materials Reports, 2019, 33(z1): 78 -83 .
[10] RONG Hui, WEI Guanqi, ZHANG Lei, ZHANG Ying, XU Rui, NING Caizhen, WANG Xueping. Consolidation of Municipal Solid Waste Incineration Fly Ash by Microbial Cementing Material: Effect and Mechanism[J]. Materials Reports, 2019, 33(22): 3757 -3761 .
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed