Please wait a minute...
《材料导报》期刊社  2017, Vol. 31 Issue (12): 115-120    https://doi.org/10.11896/j.issn.1005-023X.2017.012.024
  材料研究 |
矿物掺合料对聚羧酸减水剂与水泥相容性的影响*
李志坤1,2, 彭家惠1, 杨再富3
1 重庆大学材料科学与工程学院, 重庆400045;
2 重庆市建筑科学研究院, 重庆400016;
3 重庆建工建材物流有限公司, 重庆 401122
Effect of Mineral Admixtures on the Compatibility of Polycarboxylate Superplasticizer and Cement
LI Zhikun1,2, PENG Jiahui1, YANG Zaifu3
1 College of Materials Science & Engineering, Chongqing University, Chongqing 400045;
2 Chongqing Construction Science Research Institute, Chongqing 400016;
3 Chongqing Construction Engineering Building Materials & Logistics Co.LTD, Chongqing 401122
下载:  全 文 ( PDF ) ( 1481KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 高性能减水剂与水泥适应性差会导致混凝土流动性和坍落度损失过快,矿物掺合料将影响高性能减水剂与水泥的相容性。对比研究矿物掺合料种类和掺量对水泥净浆、砂浆和混凝土流动性的影响;采用TOC法测试了矿物掺合料对聚羧酸减水剂吸附量的影响;分析了矿物掺合料影响聚羧酸减水剂与水泥相容性的机理。结果表明,粉煤灰和矿渣对提高水泥净浆流动性具有一定的叠加效应,可用胶砂减水率的加权平均值进行量化;硅灰对水泥浆体流动性的不利影响远大于粉煤灰和矿渣的辅助减水分散作用,不利于改善聚羧酸减水剂与水泥的相容性;粉煤灰和矿渣增加聚羧酸减水剂在水泥体系中的吸附量;粉煤灰和矿渣对聚羧酸减水剂在混凝土中的减水分散效果有改善作用但不显著。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
李志坤
彭家惠
杨再富
关键词:  掺合料  聚羧酸减水剂  叠加效应  流动性  相容性  有效吸附量    
Abstract: Quick loss of fluidity and slump is commonly happened in concrete due to poor compatibility between superplasticizer and cement, which can be affected by the use of mineral admixtures. The effects of fly ash, slag and silica fume on fluidity of cement pastes, mortars and concretes were studied, and their effects on the content of polycarboxylate superplasticizer adsorbed on cement were tested by TOC method. Then, the compatibility between polycarboxylate superplasticizer and cement affected by fly ash, slag and silica fume was analysed. The results show that the beneficial impact of fly ash combined with slag on the fluidity of cement paste could be regarded as a superposition effect and quantified by the weighted average of the water-reducing rate. Silica fume has an adverse effect which is greater than the additional water-reducing effect of fly ash and slag on the fluidity of cement paste, which is unfavourable to the compatibility between polycarboxylate superplasticizer and cement. Fly ash and slag increase the effective adsorption content, resulting in good dispersion or high water reducing by polycarboxylate superplasticizer. There exists additional water-reducing effect induced by fly ash and slag in concrete but not obviously.
Key words:  admixture    polycarboxylate superplasticizer    superimposed effect    fluidity    compatibility    effective absorption content
出版日期:  2017-06-25      发布日期:  2018-05-08
ZTFLH:  TU528.04  
基金资助: *国家自然科学基金面上项目(51272295);重庆市建筑材料与制品工程技术研究中心能力提升项目(CSTC2014PT-GC50001)
通讯作者:  彭家惠:通讯作者,男,1962年生,博士,教授,主要从事建筑材料研究 E-mail:pengjh@cqu.edu.cn   
作者简介:  李志坤:男,1976年生,博士研究生,教授级高工,主要研究方向为混凝土外加剂的制备及应用技术 E-mail:lzk.cqu@163.com
引用本文:    
李志坤, 彭家惠, 杨再富. 矿物掺合料对聚羧酸减水剂与水泥相容性的影响*[J]. 《材料导报》期刊社, 2017, 31(12): 115-120.
LI Zhikun, PENG Jiahui, YANG Zaifu. Effect of Mineral Admixtures on the Compatibility of Polycarboxylate Superplasticizer and Cement. Materials Reports, 2017, 31(12): 115-120.
链接本文:  
https://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2017.012.024  或          https://www.mater-rep.com/CN/Y2017/V31/I12/115
1 Ma B, Ma M, Shen X, et al. Compatibility between a polycarboxylate superplasticizer and the belite-rich sulfoaluminate cement: Setting time and the hydration properties [J]. Construct Build Mater,2014,51:47.
2 Bahurudeen A, Marckson A V, Kishore A, et al. Development of sugarcane bagasse ash based Portland pozzolana cement and evaluation of compatibility with superplasticizers[J]. Construct Build Mater,2014,68:465.
3 Nagrockiene D, Pundienè I, Kicaite A. The effect of cement type and plasticizer addition on concrete properties[J]. Construct Build Mater,2013,45:324.
4 Mardani-Aghabaglou A, Boyacc1 O C, Hosseinnezhad H, et al. Effe-ct of gypsum type on properties of cementitious materials containing high range water reducing admixture[J]. Cem Concr Compos,2016,68:15.
5 Mardani-Aghabaglou A, Tuyan M, Yc1lmaz G, et al. Effect of di-fferent types of superplasticizer on fresh, rheological and strength properties of self-consolidating concrete[J]. Construct Build Mater,2013,47:1020.
6 Alonso M M, Palacios M, Puertas F. Compatibility between polycarboxylate-based admixtures and blended-cement pastes[J]. Cem Concr Compos,2013,35(1):151.
7 Sun Yuan, Sun Zhenping. Study on the effect of admixtures on the compatibility between cement and water reducer[J]. Cement,2003(6):7(in Chinese).
孙媛, 孙振平. 混合材对水泥与减水剂适应性的影响研究[J]. 水泥,2003(6):7.
8 Burgos-Montes O, Alonso M M, Puertas F. Viscosity and water demand of limestone-and fly ash-blended cement pastes in the presence of superplasticisers[J]. Construct Build Mater,2013,48:417.
9 Wan Huiwen, Tang Chungang, Zhang Yu. Effects of mineral admixtures and superplasticizer on rhelogical performance of cement paste[J]. J Wuhan University of Technology,2007,29(12):11(in Chinese).
万惠文, 唐春刚, 张瑜. 矿物掺合料与高效减水剂对浆体流变性的影响[J]. 武汉理工大学学报,2007,29(12):11.
10 Schröfl C, Gruber M, Plank J. Preferential adsorption of polycarboxylate superplasticizers on cement and silica fume in ultra-high performance concrete (UHPC)[J]. Cem Concr Res,2012,42(11):1401.
11 Tkaczewska E. Effect of the superplasticizer type on the properties of the fly ash blended cement[J]. Construct Build Mater,2014,70:388.
12 Toledano-Prados M, Lorenzo-Pesqueira M, González-Fonteboa B, et al. Effect of polycarboxylate superplasticizers on large amounts of fly ash cements[J]. Construct Build Mater,2013,48:628.
13 Huang Haibin, Ma Changquan, Wang Zhengshan. Study of suita-bility of naphthalene efficient superplasticizer with cement and fly ash mixture[J]. Coal Ash,2008,20(2):38(in Chinese).
黄海滨, 马长全, 王振山. 萘系高效减水剂与水泥、粉煤灰等掺合料适应性的试验研究[J]. 粉煤灰,2008,20(2):38.
14 Wang Shichao, Yu Liming, Hu Xiaowei. Analysis of factors of affecting suitability of concrete additives and cement admixture[J]. Coal Ash,2007,19(4):47(in Chinese).
王士超, 俞黎明, 虎孝伟. 混凝土外加剂与水泥、掺合料适应性的影响因素分析[J]. 粉煤灰,2007,19(4):47.
15 Burgos-Montes O, Palacios M, Rivilla P, et al. Compatibility between superplasticizer admixtures and cements with mineral additions[J]. Construct Build Mater,2012,31:300.
16 Hallal A, Kadri E H, Ezziane K, et al. Combined effect of mineral admixtures with superplasticizers on the fluidity of the blended cement paste[J]. Construct Build Mater,2010,24(8):1418.
17 Ezziane K, Ngo T T, Kaci A. Evaluation of rheological parameters of mortar containing various amounts of mineral addition with polycarboxylate superplasticizer[J]. Construct Build Mater,2014,70:549.
18 Jalal M, Pouladkhan A, Harandi O F, et al. Comparative study on effects of class F fly ash, nano silica and silica fume on properties of high performance self compacting concrete[J]. Construct Build Mater,2015,94:90.
[1] 王振峰, 伞宏赡, 田萌萌, 徐志超, 关意佳, 杨志波. 植入体表面光响应抗菌涂层的研究进展[J]. 材料导报, 2025, 39(3): 23100105-9.
[2] 丁鉴峒, 谌阳, 宋坤, 张立佳, 孟赟慧, 李晓白, 潘梦瑶, 马洪伟. 纤维素基光子晶体的研究进展[J]. 材料导报, 2025, 39(1): 24100081-9.
[3] 苏悦, 闫楠, 白晓宇, 付林, 张启军, 梁斌, 王保栋, 王立彬, 张英杰, 张安琪. 预拌流态固化土的工程特性研究进展及应用[J]. 材料导报, 2024, 38(9): 23070212-7.
[4] 谭洪波, 孔祥辉, 贺行洋, 李懋高, 苏英, 蹇守卫, 杨进. 化学外加剂对粉煤灰湿法细化活化的影响[J]. 材料导报, 2024, 38(5): 22100005-7.
[5] 张迎新, 杨康, 李日军, 高江帆, 杨永凤. 新型矿用灭火材料——凝胶干水粉体的制备及灭火实验研究[J]. 材料导报, 2024, 38(24): 23100151-10.
[6] 邱靖, 胡剑, 陈绵, 衣玉玮. 表面自纳米化医用金属材料的研究进展[J]. 材料导报, 2024, 38(23): 23070239-10.
[7] 郑建岚, 王雅思, 陈僖, 张旺城. 含氯再生骨料混凝土中钢筋抗锈蚀性能试验研究[J]. 材料导报, 2024, 38(22): 23110219-7.
[8] 向顺成, 郑廷祥, 高英力, 史威, 蒋震, 何彦琪, 曾维. 聚氨酯改性聚羧酸盐的合成及与水泥净浆的相互作用[J]. 材料导报, 2024, 38(21): 23040167-7.
[9] 田小平, 王长龙, HidayatiAsrah, Lim Chung Han, 平浩岩, 齐洋, 马锦涛, 荆牮霖, 刘治兵, 郑永超, 翟玉新, 刘枫. 钒钛铁尾矿制备绿色建筑材料的研究进展[J]. 材料导报, 2024, 38(19): 23070040-10.
[10] 郑建岚, 王晓敏, 张建全. 含氯再生骨料混凝土抗氯离子渗透性能的研究[J]. 材料导报, 2024, 38(18): 23050208-6.
[11] 关虓, 龙行, 丁莎, 张鹏鑫. 煤矸石粉混凝土冻融损伤模型与劣化机制[J]. 材料导报, 2024, 38(16): 22080144-9.
[12] 吴浪, 鲍蓉, 戴健, 雷斌. 石灰石-煅烧黏土-水泥(LC3)体系的水化动力学模型[J]. 材料导报, 2024, 38(15): 23020253-6.
[13] 刘筱涵, 杨培, 周晓燕. 等离子体改性增强农林生物质复合材料界面相容性研究进展[J]. 材料导报, 2024, 38(13): 23030072-11.
[14] 赵茜, 邢云颖, 王修云, 杨芝乐, 张雷. 天然气管道掺氢输送相容性研究现状[J]. 材料导报, 2024, 38(12): 22110125-7.
[15] 董煜, 刘跃军, 崔玲娜, 刘小超, 范淑红, 李霞. 拉伸对PA6/PET/AX8900薄膜直线易撕裂性能的影响[J]. 材料导报, 2023, 37(9): 21050030-8.
[1] Yanzhen WANG, Mingming CHEN, Chengyang WANG. Preparation and Electrochemical Properties Characterization of High-rate SiO2/C Composite Materials[J]. Materials Reports, 2018, 32(3): 357 -361 .
[2] Yimeng XIA, Shuai WU, Feng TAN, Wei LI, Qingmao WEI, Chungang MIN, Xikun YANG. Effect of Anionic Groups of Cobalt Salt on the Electrocatalytic Activity of Co-N-C Catalysts[J]. Materials Reports, 2018, 32(3): 362 -367 .
[3] Qingshun GUAN,Jian LI,Ruyuan SONG,Zhaoyang XU,Weibing WU,Yi JING,Hongqi DAI,Guigan FANG. A Survey on Preparation and Application of Aerogels Based on Nanomaterials[J]. Materials Reports, 2018, 32(3): 384 -390 .
[4] Lijing YANG,Zhengxian LI,Chunliang HUANG,Pei WANG,Jianhua YAO. Producing Hard Material Coatings by Laser-assisted Cold Spray:a Technological Review[J]. Materials Reports, 2018, 32(3): 412 -417 .
[5] Zhiqiang QIAN,Zhijian WU,Shidong WANG,Huifang ZHANG,Haining LIU,Xiushen YE,Quan LI. Research Progress in Preparation of Superhydrophobic Coatings on Magnesium Alloys and Its Application[J]. Materials Reports, 2018, 32(1): 102 -109 .
[6] Wen XI,Zheng CHEN,Shi HU. Research Progress of Deformation Induced Localized Solid-state Amorphization in Nanocrystalline Materials[J]. Materials Reports, 2018, 32(1): 116 -121 .
[7] Xing LIANG, Guohua GAO, Guangming WU. Research Development of Vanadium Oxide Serving as Cathode Materials for Lithium Ion Batteries[J]. Materials Reports, 2018, 32(1): 12 -33 .
[8] Hao ZHANG,Yongde HUANG,Yue GUO,Qingsong LU. Technological and Process Advances in Robotic Friction Stir Welding[J]. Materials Reports, 2018, 32(1): 128 -134 .
[9] Laima LUO, Mengyao XU, Xiang ZAN, Xiaoyong ZHU, Ping LI, Jigui CHENG, Yucheng WU. Progress in Irradiation Damage of Tungsten and Tungsten AlloysUnder Different Irradiation Particles[J]. Materials Reports, 2018, 32(1): 41 -46 .
[10] Fengsen MA,Yan YU,Jie ZHANG,Haibo CHEN. A State-of-the-art Review of Cytotoxicity Evaluation of Biomaterials[J]. Materials Reports, 2018, 32(1): 76 -85 .
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed