| RESEARCH PAPER |
|
|
|
|
|
| Study on Graphene Oxide/HA Composites Prepared by Gelcasting Technology |
| LI Qiang1, WEI Leishan1, SUN Xudong2
|
1 College of Materials Science & Engineering, Liaoning University of Technology, Jinzhou 121001;
2 School of Materials Science & Engineering, Northeastern University, Shenyang 110004 |
|
|
|
|
Abstract Graphene oxide (GO) and hydroxyapatite(HA) particles were used as initial materials to prepare GO/HA compo-sites by gelcasting method. The effects of the contents of organic monomer and graphene oxide,the solid content of the slurries on viscosity of GO/HA slurries were studied. The gelcasting processes of the GO/HA slurries were observed and the green density and compressive strength of green compacts were measured. The effects of GO contents on bending strength and fracture toughness of GO/HA composites were analyzed. The microstructure of the fracture surface of the HA composites were observed. The results show that at organic monomer of 15wt%, GO particles of 1.5wt% and the solid content of slurries of 45wt%, the GO/HA slurries have better viscosity of 362.9 mPa·s and good dispersion. The solidified compacts have better density and compressive strength. With the increase of the contents of the GO particles, the bending strength and fracture toughness of the HA composites first increase and then decrease. When the content of GO particles is 1.5wt%, the GO/HA composites sintered at 1 150 ℃ have bending strength of 81.5 MPa and flexural toughness of 1.52 MPa·m1/2, which are 151.8% and 74.7% higher than those of HA matrix. Therefore, the GO/HA composites have better mechanical properties with the addition of GO particles.
|
|
Published: 08 May 2018
|
|
|
|
|
1 Liu D M, Troczynski T, Tseng W J.Water-based sol-gel synthesis of hydroxyapatite: Process development[J]. Biomaterials, 2001,22(13):1721.
2 Zhou H, Lee J. Nanoscale hydroxyapatite particles for bone tissue engineering[J]. Acta Biomater, 2011,7(7):2769.
3 Hutmacher D W. Scaffolds in tissue engineering bone and cartilage[J]. Biomaterials, 2000,21(24):2529.
4 Guo X D. Bone tissue engineering: Research progress of techniques to bone defect repair[J]. Int J Biomedical Eng, 2004,27(5):270(in Chinese).
郭晓东. 用组织工程学技术修复骨缺损研究进展[J]. 国际生物医学工程杂志,2004,27(5):270.5 Chen F. The investigation and development of biomedical materials containing hydroxyapatite[J]. China Ceram, 2006,42(4):8(in Chinese).
陈菲. 羟基磷灰石生物医用陶瓷材料的研究与发展[J]. 中国陶瓷, 2006,42(4):8.
6 Bolotin K, Sikes K, Hone J, et al. Temperature-dependent transport in suspended graphene[J]. Phys Rev Lett, 2008,101(9):67.
7 Katsnelson M I. Graphene: Carbon in two dimensions[J]. Mater Today, 2007,10(1):20.
8 Liu Z, Robinson J T, Sun X, et al. Pegylated nanographene oxide for delivery of water-insoluble cancer drugs[J]. J Am Chem Soc, 2008,130(33):10876.
9 Sun X, Liu Z, Welsher K, et al. Nano-graphene oxide for cellular imaging and drug delivery[J]. Nano Res, 2008,1(3):203.
10Huang X, Qi X, Boey F, et al. Graphene-based composites[J]. Chem Soc Rev, 2012,41(2):666.
11Verdejo R, Bernal M M, Romasanta L J, et al. Graphene filled po-lymer nanocomposites[J]. J Mater Chem, 2011,21(10):3301. |
|
|
|
渝公网安备50019002502923号 © Editorial Office of Materials Reports.
2017, Vol. 31 
