Please wait a minute...
《材料导报》期刊社  2018, Vol. 32 Issue (9): 1571-1576    https://doi.org/10.11896/j.issn.1005-023X.2018.09.024
  材料的腐蚀与防护 |
不同液膜厚度下电偶腐蚀当量折算研究
陈跃良,黄海亮,张 勇,卞贵学,王晨光,王安东
海军航空工程学院青岛校区,青岛 266041
Study on Equivalent Conversion of Galvanic Corrosion Under Different Liquid Film Thickness
CHEN Yueliang, HUANG Hailiang, ZHANG Yong, BIAN Guixue, WANG Chenguang, WANG Andong
Naval Aeronautical Engineering Institute Qingdao Campus, Qingdao 266041
下载:  全 文 ( PDF ) ( 1874KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 搭建薄液膜厚度测量与控制装置,采用微距参比电极后置法组建三电极体系,测量了在3.5%(质量分数,下同)NaCl不同液膜厚度下2024铝合金和TA15钛合金极化曲线和电偶电流,得到了不同厚度液膜下两种材料的电化学动力学参数;建立了基于薄壳电流分布的Comsol腐蚀仿真模型,得出了不同液膜厚度下的电偶电流以及电偶腐蚀与无电偶腐蚀时的当量折算系数。结果表明,利用仿真模型得到的电偶电流值与试验值吻合较好, 50 μm液膜厚度下的电偶电流约是溶液状态的25倍,随着液膜厚度的增大,电偶电流的下降速度逐渐增大,当液膜厚度达到1 000 μm时,电偶电流趋近于溶液状态;50 μm和100 μm液膜厚度下电偶腐蚀折算系数约为无电偶状态下的5倍,当液膜厚度超过100 μm时,折算系数急剧下降,到1 000 μm时无论有无电偶腐蚀其折算系数均基本趋于1。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
陈跃良
黄海亮
张 勇
卞贵学
王晨光
王安东
关键词:  液膜  当量折算  电偶腐蚀  腐蚀仿真    
Abstract: The polarization curves and galvanic currents of 2024 aluminum alloy and TA15 titanium alloy under different thickness of 3.5wt% NaCl liquid film were measured and the electrochemical kinetic parameters of two kinds of materials under different thickness liquid membranes were determined by applying a liquid membrane thickness measurement apparatus and a three-electrode system with backward inserted micro-distance reference eletrode. To obtain the galvanic current under different liquid film thickness and equivalent conversion factor of galvanic-non galvanic corrosion. The Comsol corrosion simulation model based on the shell current distribution was established.The result manifested that the galvanic current value obtained by the simulation model agreed well with the experimental data, under the thickness of 50 μm liquid film, the galvanic current was about 25 times of that of the solution, with the increase of liquid film thickness, the decrease speed of galvanic current increased gradually. When the liquid film thickness reaches 1 000 μm, the galvanic current approached the solution state,the conversion coefficient of galvanic corrosion at 50 μm and 100 μm liquid film thickness was about 5 times of that without galvanic couple. When the liquid film thickness was more than 100 μm, the conversion coefficient dropped sharply. When the liquid film thickness was 1 000 μm, whether there was galvanic corrosion or not, the conversion coefficient basically tended to 1.
Key words:  liquid film    equivalent conversion    galvanic corrosion    corrosion simulation
出版日期:  2018-05-10      发布日期:  2018-07-06
ZTFLH:  TG172.2  
  V252  
作者简介:  陈跃良:男,1962年生,博士,教授,主要从事结构强度、腐蚀防护与控制方面的研究 E-mail:cyl0532@sina.com
引用本文:    
陈跃良,黄海亮,张 勇,卞贵学,王晨光,王安东. 不同液膜厚度下电偶腐蚀当量折算研究[J]. 《材料导报》期刊社, 2018, 32(9): 1571-1576.
CHEN Yueliang, HUANG Hailiang, ZHANG Yong, BIAN Guixue, WANG Chenguang, WANG Andong. Study on Equivalent Conversion of Galvanic Corrosion Under Different Liquid Film Thickness. Materials Reports, 2018, 32(9): 1571-1576.
链接本文:  
https://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2018.09.024  或          https://www.mater-rep.com/CN/Y2018/V32/I9/1571
1 Lin Cui,Xiao Zhiyang.Eletrochemical corrosion behavior of carbon steel under thin electrolyte layer containing NaCl[J].Corrosion & Protection,2014,35(4):316(in Chinese).
林翠,肖志阳.碳钢在NaCl薄液膜下的电化学腐蚀行为[J].腐蚀与防护,2014,35(4):316.
2 Huang H, Guo X, Zhang G, et al. The effects of temperature and electric field on atmospheric corrosion behaviour of PCB-Cu under absorbed thin electrolyte layer[J].Corrosion Science,2011,53(5):1700.
3 Jiang J, Wang J, Lu Y, et al. Effect of length of gas/liquid/solid three-phase boundary zone on cathodic and corrosion behavior of metals[J].Electrochimica Acta,2009,54(5):1426.
4 Cheng Y L, Zhang Z, Cao F H, et al. A study of the corrosion of aluminum alloy 2024-T3 under thin electrolyte layers[J].Corrosion Science,2004,46(7):1649.
5 Pan C, Lv W, Wang Z, et al. Atmospheric corrosion of copper exposed in a simulated coastal-industrial atmosphere[J].Journal of Materials Science & Technology,2017,33(6): 587.
6 Huang H, Pan Z, Guo X, et al. Effect of an alternating electric field on the atmospheric corrosion behaviour of copper under a thin electrolyte layer[J].Corrosion Science,2013,75:100.
7 Huang H, Dong Z, Chen Z, et al. The effects of Cl- ion concentration and relative humidity on atmospheric corrosion behaviour of PCB-Cu under adsorbed thin electrolyte layer[J].Corrosion Science,2011,53(4):1230.
8 Huang H, Guo X, Zhang G, et al. The effects of temperature and electric field on atmospheric corrosion behaviour of PCB-Cu under absorbed thin electrolyte layer[J].Corrosion Science,2011,53(5):1700.
9 Liao X, Cao F, Zheng L, et al. Corrosion behaviour of copper under chloride-containing thin electrolyte layer[J].Corrosion Science,2011,53(10):3289.
10 Liao X, Cao F, Chen A, et al. In-situ investigation of atmospheric corrosion behavior of bronze under thin electrolyte layers using electrochemical technique[J].Transactions of Nonferrous Metals Society of China,2012,22(5):1239.
11 Zhong X, Zhang G, Qiu Y, et al. The corrosion of tin under thin electrolyte layers containing chloride[J].Corrosion Science,2013,66(1):14.
12 Wang Chenguang,Chen Yueliang,Zhang Yong,et al.Corrosion behavior of 7B04 Al-alloy in simulated marine atmospheric environment[J].Journal of Aeronautical Materials,2017,37(1):59(in Chinese).
王晨光,陈跃良,张勇,等.7B04铝合金在模拟海洋大气环境下的腐蚀行为[J].航空材料学报,2017,37(1):59.
13 Li Yakun.Electrochemical behavior research of metal corrosion under thin eletrolyte lay[D].Qingdao: Ocean University of China,2007(in Chinese).
李亚坤.薄液层下金属电化学腐蚀行为研究[D].青岛:中国海洋大学,2007.
14 Deng Zuyu.Eletrochemical behavior of corrosion of X70 steel under thin layer of electrolytes containing hydrogen sulfide[J].Corrosion&Protection,2014(6):557(in Chinese).
邓祖宇.H2S薄层液膜下X70钢的腐蚀电化学行为[J].腐蚀与防护,2014(6):557.
15 Lin Cui,Xiao Zhiyang,Liang Jianneng.Electrochemical corrosion behavior of AZ91D magnesium alloy under thin electrolyte layer containing SO2[J].Materials for Mechanical Engineering,2013,37(6):55(in Chinese).
林翠,肖志阳,梁健能.AZ91D镁合金在SO2薄液膜下的电化学腐蚀行为[J].机械工程材料,2013,37(6):55.
16 Chen Yueliang,Wang Zhefu,Bian Guixue,et al.Equivalent conversion of typical aluminum-titanium alloy in NaCl solution with different concentrations[J].Acta Aeronautica et Astronautica Sinica,2017,38(3):260(in Chinese).
陈跃良,王哲夫,卞贵学,等.不同浓度NaCl溶液下典型铝/钛合金电偶腐蚀当量折算关系[J].航空学报,2017,38(3):260.
17 曹楚南.腐蚀电化学原理(第三版)[M].北京:化学工业出版社,2008.
18 Xu L Y, Cheng Y F. Development of a finite element model for si-mulation and prediction of mechanoelectrochemical effect of pipeline corrosion[J].Corrosion Science,2013,73:150.
19 Zhang Yong,Chen Yueliang,Wang Chenguang.Study on galvanic corrosion of aluminum alloy related joint in simulated coastal wet atmosphere[J].Materials Review B: Research Papers,2016,30(5):152(in Chinese).
张勇,陈跃良,王晨光.模拟沿海大气环境下铝合金搭接件电偶腐蚀行为研究[J].材料导报:研究篇,2016,30(5):152.
20 Chen Yueliang,Wang Chenguang,Zhang Yong,et al.Coating corrosion failure analysis and influence of titanium-steel bolted lap joints[J].Acta Aeronautica et Astronautica Sinica,2016(11):3528(in Chinese).
陈跃良,王晨光,张勇,等.钛-钢螺栓搭接件涂层腐蚀失效分析及影响[J].航空学报,2016(11):3528.
21 刘文珽,李玉海.飞机结构日历寿命体系评定技术[M].北京:航空工业出版社,2004:84.
[1] 郭贺, 焦进超, 张津, 王旭东, 连勇, 冯波, 冯晓伟, 郑开宏, 丁啸云, 韩东. 不同铝合金对Al/Mg/Al层状复合材料腐蚀行为的影响[J]. 材料导报, 2024, 38(12): 22090163-8.
[2] 寇杰, 马东旭, 郑勇. 基于丝束电极技术的电偶腐蚀研究进展[J]. 材料导报, 2023, 37(23): 22040352-9.
[3] 胡连军, 刘建军, 潘国峰, 曹静伟, 夏荣阳. 钴化学机械抛光的研究进展[J]. 材料导报, 2022, 36(4): 20090178-10.
[4] 黄海亮, 陈跃良, 张勇, 卞贵学, 王晨光, 吴省均. 飞机多金属耦合在溶液状态与大气状态下的腐蚀行为对比及当量折算研究[J]. 材料导报, 2020, 34(4): 4118-4125.
[5] 卜红梅, 李肖蔚, 齐建涛, 李焰. 利用微电极阵列技术研究合金的腐蚀[J]. 材料导报, 2019, 33(23): 3963-3970.
[6] 卞贵学, 陈跃良, 张勇, 王安东, 王哲夫. 基于电偶腐蚀仿真的铝/钛合金在不同浓度酸性NaCl溶液中与水介质中的当量折算系数[J]. 材料导报, 2019, 33(16): 2746-2752.
[7] 宋刚, 迟佳玉, 于景威, 刘黎明. 镁/钢激光-电弧复合焊接接头的腐蚀行为[J]. 材料导报, 2018, 32(16): 2773-2777.
[8] 陈跃良, 王安东, 卞贵学, 张勇. CF8611/AC531复合材料的电化学特性及其与7B04-T74铝合金的电偶腐蚀仿真[J]. 材料导报, 2018, 32(16): 2889-2896.
[9] 姚小飞, 田伟, 谢发勤, 陈建. 超级13Cr和P110油管钢在NaCl溶液中电偶腐蚀行为的研究[J]. 《材料导报》期刊社, 2017, 31(11): 166-169.
[1] Yanzhen WANG, Mingming CHEN, Chengyang WANG. Preparation and Electrochemical Properties Characterization of High-rate SiO2/C Composite Materials[J]. Materials Reports, 2018, 32(3): 357 -361 .
[2] Yimeng XIA, Shuai WU, Feng TAN, Wei LI, Qingmao WEI, Chungang MIN, Xikun YANG. Effect of Anionic Groups of Cobalt Salt on the Electrocatalytic Activity of Co-N-C Catalysts[J]. Materials Reports, 2018, 32(3): 362 -367 .
[3] Qingshun GUAN,Jian LI,Ruyuan SONG,Zhaoyang XU,Weibing WU,Yi JING,Hongqi DAI,Guigan FANG. A Survey on Preparation and Application of Aerogels Based on Nanomaterials[J]. Materials Reports, 2018, 32(3): 384 -390 .
[4] Lijing YANG,Zhengxian LI,Chunliang HUANG,Pei WANG,Jianhua YAO. Producing Hard Material Coatings by Laser-assisted Cold Spray:a Technological Review[J]. Materials Reports, 2018, 32(3): 412 -417 .
[5] Zhiqiang QIAN,Zhijian WU,Shidong WANG,Huifang ZHANG,Haining LIU,Xiushen YE,Quan LI. Research Progress in Preparation of Superhydrophobic Coatings on Magnesium Alloys and Its Application[J]. Materials Reports, 2018, 32(1): 102 -109 .
[6] Wen XI,Zheng CHEN,Shi HU. Research Progress of Deformation Induced Localized Solid-state Amorphization in Nanocrystalline Materials[J]. Materials Reports, 2018, 32(1): 116 -121 .
[7] Xing LIANG, Guohua GAO, Guangming WU. Research Development of Vanadium Oxide Serving as Cathode Materials for Lithium Ion Batteries[J]. Materials Reports, 2018, 32(1): 12 -33 .
[8] Hao ZHANG,Yongde HUANG,Yue GUO,Qingsong LU. Technological and Process Advances in Robotic Friction Stir Welding[J]. Materials Reports, 2018, 32(1): 128 -134 .
[9] Laima LUO, Mengyao XU, Xiang ZAN, Xiaoyong ZHU, Ping LI, Jigui CHENG, Yucheng WU. Progress in Irradiation Damage of Tungsten and Tungsten AlloysUnder Different Irradiation Particles[J]. Materials Reports, 2018, 32(1): 41 -46 .
[10] Fengsen MA,Yan YU,Jie ZHANG,Haibo CHEN. A State-of-the-art Review of Cytotoxicity Evaluation of Biomaterials[J]. Materials Reports, 2018, 32(1): 76 -85 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed