Please wait a minute...
《材料导报》期刊社  2017, Vol. 31 Issue (12): 84-88    https://doi.org/10.11896/j.issn.1005-023X.2017.012.018
  材料研究 |
铝锂合金T型自冲铆接头疲劳特性及失效机理*
程强, 何晓聪, 邢保英, 张越
昆明理工大学机电工程学院, 昆明 650500
Fatigue Properties and Failure Mechanisms of Self-piercing Riveted T Joints in Aluminum-Lithium Alloys
CHENG Qiang, HE Xiaocong, XING Baoying, ZHANG Yue
Faculty of Mechanical and Electrical Engineering, Kunming University of Science and Technology, Kunming 650500
下载:  全 文 ( PDF ) ( 1742KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 为研究T型自冲铆接头的疲劳特性,以铝锂合金(AL1420)同种及其与铜合金(H62)和不锈钢(410)异种组合制备的AA、HA和SA三组T型自冲铆接头为研究对象,基于其静力学试验采用正弦波进行拉-拉加载疲劳试验,用二参数威布尔分布对所得疲劳数据的有效性进行验证,采用最小二乘拟合直线得到拟合的F-N曲线,并采用SEM扫描电镜对各组典型疲劳失效断口进行微观分析。结果表明:SA组疲劳寿命对载荷变化最敏感,并且疲劳寿命随相对滑移量的增加而减小;由三组T型接头失效形式可看出接头薄弱环节有由铆钉向板材转移的趋势;从微观分析疲劳断口可知裂纹萌生区多为形貌特征较为平坦的准解理,裂纹瞬断区形貌更加突出,多为沿晶断裂或韧窝形貌。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
程强
何晓聪
邢保英
张越
关键词:  铝锂合金  T型自冲铆接头  疲劳试验  SEM扫描电镜  断裂特征    
Abstract: In order to study the fatigue properties of self-piercing riveted(SPR) T joints, three sets of T joints (1420 aluminum-lithium alloys joined with itself (AA joints), with H62 copper alloys (HA joints) and with 410 stainless steel(SA joints)) were prepared. Fatigue test were conducted on the basis of peeling test. The effectiveness of test data was analyzed by two-parameter Weibull distribution, and the equations of fatigue load-fatigue life curves were calculated by least square method. Scanning electron microscope was adopted to observe the appearance of the joints fracture. The results show that the fatigue life of SA joints was the most sensitive to the load fluctuation which were loaded on joints, and fatigue life decreased with the increasing relative slippage. The weak point of the joints transferred from rivets to sheets. From micro-view, the fracture features of crack initiation region is flatter than the fracture features of crack transient zone which are mainly the intergranular fracture or the dimple.
Key words:  aluminum-lithium alloys    self-piercing riveted(SPR) T joints    fatigue test    scanning electron microscope    fracture features
出版日期:  2017-06-25      发布日期:  2018-05-08
ZTFLH:  TG447  
基金资助: *国家自然科学基金(51565023;51565022);国家科技重大专项项目(2012ZX04012-031);云南省教育厅科学研究基金重大专项项目(ZD201504)
通讯作者:  何晓聪:通讯作者,男,1955年生,博士,教授,博士研究生导师,从事薄板材料连接新技术研究 E-mail:xiaocong_he@126.com   
作者简介:  程强:男,1989年生,硕士研究生,主要研究方向为薄板材料连接新技术 E-mail:qiangcheng1214@163.com
引用本文:    
程强, 何晓聪, 邢保英, 张越. 铝锂合金T型自冲铆接头疲劳特性及失效机理*[J]. 《材料导报》期刊社, 2017, 31(12): 84-88.
CHENG Qiang, HE Xiaocong, XING Baoying, ZHANG Yue. Fatigue Properties and Failure Mechanisms of Self-piercing Riveted T Joints in Aluminum-Lithium Alloys. Materials Reports, 2017, 31(12): 84-88.
链接本文:  
https://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2017.012.018  或          https://www.mater-rep.com/CN/Y2017/V31/I12/84
1 Mucha J. A study of quality parameters and behavior of self-piercing riveted aluminum sheets with different joining conditions[J]. J Mech Eng,2011,57(4):323.
2 Pickin C G, et al. Joining of lightweight sandwich sheets to aluminum using self-pierce riveting[J]. Mater Des,2007,28(8):2361.
3 Lu Yi, He Xiaocong, Wang Yifeng, et al. Effect of local heat treatment on the mechanical properties of steel-titanium self-piercing riveted joints[J]. Mater Rev:Res,2015,29(5):120(in Chinese).
卢毅, 何晓聪, 王医锋, 等. 局部热处理对钢-钛自冲铆接头力学性能的影响[J]. 材料导报:研究篇,2015,29(5):120.
4 Zhou Changrong, Pan Qinglin, Zhu Chaoming,et al. Development and study of new types aluminum-lithium alloys[J]. Mater Rev,2004,18(5):30(in Chinese).
周昌荣, 潘青林, 朱朝明, 等. 新型铝锂合金的研究和发展[J]. 材料导报,2004,18(5):30.
5 He Xiaocong, Zhao Lun, Deng Chengjiang, et al. Self-piercing riveting of similar and dissimilar metal sheets of aluminum alloy and copper alloy[J]. Mater Des,2015,65:923
6 Zhao Lun, He Xiaocong, Xing Baoying, et al. Influence of sheet thickness on fatigue behavior and fretting of self-piercing riveted joints in aluminum alloy 5052[J]. Mater Des,2015,87:1010.
7 He Xiaocong. An approximate method via coefficient of variation for strength prediction of self-piercing riveted joints[C]//Applied Mechanics and Materials. Luoyang, China,2010:334.
8 Se-Hyung kang, Ho-Kyung Kim. Fatigue strength evaluation of self-piercing riveted Al-5052 joints under different specimen configurations[J]. Int J Fatigue,2015,80:58.
9 Xing Baoying, He Xiaocong, Wang Yuqi, et al. Static mechanical properties and failure mechanism of self-piercing riveted aluminum alloy joint[J]. Trans China Welding Institution,2016,37(6):47(in Chinese).
邢保英, 何晓聪, 王玉奇, 等. 铝合金自冲铆接头疲劳性能及失效机理[J]. 焊接学报,2016,37(6):47.
10 Karbhari V M, Wang Q. Influence of triaxial braid denier on ribbon-based fiber reinforced dental composites [J]. Dental Mater,2007,23(8):969.
11 何明鉴. 机械构件的微动疲劳[M]. 北京:国防工业出版社,1994:33.
12 Zhao Lun, He Xiaocong, Lu Yi, et al. Mechanism of fretting fatigue damage on single-lap self-piercing riveted joints of 5052 aluminum alloy[J]. Hot Working Technol,2016,45(5):16(in Chinese).
赵伦, 何晓聪, 卢毅, 等. 5052铝合金单搭自冲铆接头微动疲劳损伤机理研究[J]. 热加工工艺,2016,45(5):16.
13 熊峻江. 疲劳断裂可靠性工程学[M]. 北京:国防工业出版社,2008:4.
14 钟群鹏, 赵子华. 断口学[M]. 北京:高等教育出版社,2006:200.
[1] 何涛, 马国政, 李海庆, 石佳东, 李振, 郭伟玲, 邢志国. 固体润滑齿轮接触疲劳寿命及影响因素研究现状[J]. 材料导报, 2025, 39(1): 23120091-15.
[2] 王万祯. Q460C钢缺口板的疲劳裂纹萌生寿命计算模型和总疲劳寿命计算[J]. 材料导报, 2024, 38(4): 23010056-8.
[3] 于以标, 陈乐平, 徐勇, 袁源平, 方森鹏. 2060-T8E30铝锂合金的高温拉伸变形行为及显微组织研究[J]. 材料导报, 2023, 37(6): 21090209-6.
[4] 陈小丽, 谭敏, 罗文东. 温度对铝锂合金阳极氧化膜结构及耐蚀性的影响[J]. 材料导报, 2022, 36(Z1): 21120067-5.
[5] 陈小丽. 有机酸对新型铝锂合金阳极氧化膜结构及耐蚀性的影响[J]. 材料导报, 2022, 36(Z1): 22010030-5.
[6] 李朝阳, 黄光杰, 曹玲飞, 曹宇, 林林. 升温速率对AA2060铝锂合金中间形变热处理微观组织的影响[J]. 材料导报, 2022, 36(7): 21020008-7.
[7] 吴涛, 姚卫星, 黄杰. 纤维增强树脂基复合材料超高周疲劳研究进展[J]. 材料导报, 2022, 36(6): 20050117-9.
[8] 黄珂, 易幼平, 黄始全, 董非, 王晨光. 2195铝锂合金超低温流变行为及成形特性研究[J]. 材料导报, 2022, 36(3): 20090263-6.
[9] 陈亚军, 韦第升, 彭剑书, 宋先捷. 基于蚀坑形貌特征的2198-T8铝锂合金预腐蚀疲劳寿命预测[J]. 材料导报, 2022, 36(21): 21080028-7.
[10] 于娟, 李国爱, 冯朝辉, 陈军洲, 赵唯一. 中间形变热处理对铝锂合金短横向拉伸性能的影响[J]. 材料导报, 2022, 36(18): 20060118-5.
[11] 仇伟夷, 祝祥辉, 黄伟九, 杨绪盛, 汪鑫. 晶界特征对AA2099铝锂合金疲劳加载分层断裂影响探究[J]. 材料导报, 2022, 36(10): 21030256-5.
[12] 范凌云, 高婧, 李锦峰, 周海俊. 层压型CFRP环带疲劳试验中接触面温度场分析[J]. 材料导报, 2022, 36(1): 20110148-7.
[13] 张庆, 侯德华, 刘廷国. 水固化型聚合物改性乳化沥青混合料性能研究[J]. 材料导报, 2020, 34(Z2): 612-617.
[14] 郝时嘉, 陆政, 李国爱, 于娟. 高性能铝锂合金关键力学性能各向异性的影响因素及控制措施[J]. 材料导报, 2019, 33(Z2): 389-393.
[15] 雷林, 杨庆波, 张志清, 樊祥泽, 李旭, 杨谋, 邓赞辉. AA2195铝锂合金多道次压缩行为及微观组织演变[J]. 材料导报, 2019, 33(z1): 348-352.
[1] Lanyan LIU,Jun SONG,Bowen CHENG,Wenchi XUE,Yunbo ZHENG. Research Progress in Preparation of Lignin-based Carbon Fiber[J]. Materials Reports, 2018, 32(3): 405 -411 .
[2] Haoqi HU,Cheng XU,Lijing YANG,Henghua ZHANG,Zhenlun SONG. Recent Advances in the Research of High-strength and High-conductivity CuCrZr Alloy[J]. Materials Reports, 2018, 32(3): 453 -460 .
[3] Yanchun ZHAO,Congyu XU,Xiaopeng YUAN,Jing HE,Shengzhong KOU,Chunyan LI,Zizhou YUAN. Research Status of Plasticity and Toughness of Bulk Metallic Glass[J]. Materials Reports, 2018, 32(3): 467 -472 .
[4] Xinxing ZHOU,Shaopeng WU,Xiao ZHANG,Quantao LIU,Song XU,Shuai WANG. Molecular-scale Design of Asphalt Materials[J]. Materials Reports, 2018, 32(3): 483 -495 .
[5] Yongtao TAN, Lingbin KONG, Long KANG, Fen RAN. Construction of Nano-Au@PANI Yolk-shell Hollow Structure Electrode Material and Its Electrochemical Performance[J]. Materials Reports, 2018, 32(1): 47 -50 .
[6] Ping ZHU,Guanghui DENG,Xudong SHAO. Review on Dispersion Methods of Carbon Nanotubes in Cement-based Composites[J]. Materials Reports, 2018, 32(1): 149 -158 .
[7] Fangyuan DONG,Shansuo ZHENG,Mingchen SONG,Yixin ZHANG,Jie ZHENG,Qing QIN. Research Progress of High Performance ConcreteⅠ:Raw Materials and Mix Proportion Design Method[J]. Materials Reports, 2018, 32(1): 159 -166 .
[8] Guiqin HOU,Yunkai LI,Xiaoyan WANG. Research Progress of Zinc Ferrite as Photocatalyst[J]. Materials Reports, 2018, 32(1): 51 -57 .
[9] Jianxiang DING,Zhengming SUN,Peigen ZHANG,Wubian TIAN,Yamei ZHANG. Current Research Status and Outlook of Ag-based Contact Materials[J]. Materials Reports, 2018, 32(1): 58 -66 .
[10] Jing WANG,Hongke LIU,Pingsheng LIU,Li LI. Advances in Hydrogel Nanocomposites with High Mechanical Strength[J]. Materials Reports, 2018, 32(1): 67 -75 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed