碳基复合吸波材料研究进展分析<sup>*</sup>

doi:10.11896/j.issn.1005-023X.2017.021.007

Abstract
Figure/Table
References
Related Citation (15)

Download:

Full Text ( PDF ) (2751KB)
Export: BibTeX | EndNote (RIS)

Abstract Accounting the competitive dielectric properties, excellent composited performance, particular microstructure, low mass ratio, high chemistry stability and convenience of utilizing as well as maintaining etc., the carbon-based materials have shown great application potential for electromagnetic (EM) wave absorption and drawn extensive attention in academic and industrial field. Comparative analysis upon domestic and foreign researches have been engaged in the present review. Based on the analysis of the research results both at home and abroad, we classify carbon-based composite materials into zero-dimensional, one-dimensional, two-dimensional and three-dimensional composite structures, according to their dimensionality. Further more, the research progress of carbon-based composite materials used for radar EM wave absorption has been clearly elaborated on the basis of the present classification. It has been of common knowledge that “thinner thickness, lower mass, wider effective bandwidth, higher mechanical perfor-mance” are the basic requirements for future EM wave absorption materials. The developing directions of physical phases compositing, particle structure diversifying, mechanism coorperating and electromagnetism parameters adjusting are figured out by comparing and summarizing the international academic progress of absorption materials.

Key words： electromagnetic wave absorption carbon-based composites reflection loss microstructure

Published: 08 May 2018

CLC number:

TB34

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	AN Rui
	WEI Hongyu
	HE Min
	ZHOU Laishui
	LIANG Jinhua
	XIE Di
	ZHANG Zhiping
	WU Huanqi

Cite this article:

AN Rui,WEI Hongyu,HE Min, et al. The Progress Analysis of Carbon-based Composites Used for Electromagnetic Wave Absorption[J]. Materials Reports, 2017, 31(21): 46-53.

URL:

http://www.mater-rep.com/EN/10.11896/j.issn.1005-023X.2017.021.007 OR http://www.mater-rep.com/EN/Y2017/V31/I21/46

1 Liu L, Duan Y, Ma L, et al. Microwave absorption properties of a wave-absorbing coating employing carbonyl-iron powder and carbon black[J]. Appl Surf Sci, 2010,257(3):842.
2 Weng X, Lv X, Li B, et al. One-pot preparation of reduced graphene oxide/carbonyl iron/polyvinyl pyrrolidone ternary nanocomposite and its synergistic microwave absorbing properties[J]. Mater Lett, 2016,188:280.
3 Xu Y, Yuan L, Zhang D, et al. Microwave absorption and shielding property of composites with FeSiAl and carbonous materials as filler[J]. J Mater Sci Technol, 2012,28(10):913.
4 Zou T, Haipeng L I, Zhao N, et al. Electromagnetic and microwave absorbing properties of hollow carbon nanospheres[J]. Bull Mater Sci, 2013,36(2):213.
5 Lv H, Ji G, Liu W, et al. Achieving hierarchical hollow carbon@Fe@Fe₃O₄ nanospheres with superior microwave absorption properties and lightweight feature[J]. J Mater Chem C, 2015,3(39):10232.
6 Zhu H L, Xu Z F, Cui H Z, et al. Surface modification as an effective approach to enhance the microwave absorbing properties of hollow carbon spheres[J]. Mater Res Exp,2016,3(10):105020.
7 Zhou C, Geng S, Xu X, et al. Lightweight hollow carbon nanos-pheres with tunable sizes towards enhancement in microwave absorption[J]. Carbon, 2016,108:234.
8 Ding D, Wang Y, Li X, et al. Rational design of core-shell Co@C microspheres for high-performance microwave absorption[J]. Carbon, 2016,111:722.
9 Huang Y, Zhang H, Zeng G, et al. The microwave absorption properties of carbon-encapsulated nickel nanoparticles/silicone resin flexible absorbing material[J]. J Alloys Compd, 2016,682:138.
10Han D, Or S W, Dong X, et al. FeSn₂/defective onion-like carbon core-shell structured nanocapsules for high-frequency microwave absorption[J]. J Alloy Compd, 2016,695:2605.
11Chen J, Wang M, Meng P, et al. Electromagnetic and microwave absorption properties of the core-shell structured C@BaMg_0.2Co_0.8-TiFe₁₀O_19, nanoparticles[J]. J Mater Sci Mater Electron, 2016,28(2):2100.
12Zhou W, Long L, Xiao P, et al. Silicon carbide nano-fibers in-situ grown on carbon fibers for enhanced microwave absorption properties[J]. Ceram Int, 2017,43(7):5628.
13 刘顺华. 电磁波屏蔽及吸波材料[M]. 北京:化学工业出版社, 2014.
14Liu Y, Zhang Z, Xiao S, et al. Preparation and properties of cobalt oxides coated carbon fibers as microwave-absorbing materials[J]. Appl Surf Sci, 2011,257(17):7678.
15Chen X, Wang X, Li L, et al. Preparation and microwave absorbing properties of nickel-coated carbon fiber with polyaniline via in situ polymerization[J]. J Mater Sci: Mater Electron, 2016,27(6):5607.
16Qiu J, Wu X, Qiu T. High electromagnetic wave absorbing performance of activated hollow carbon fibers decorated with CNTs and Ni nanoparticles[J]. Ceram Int, 2015,42(4):5278.
17Wang W, Cao M. Ni₃Sn₂ alloy nanocrystals encapsulated within electrospun carbon nanofibers for enhanced microwave absorption performance[J]. Mater Chem Phys, 2016,177:198.
18Salimkhani H, Palmeh P, Khiabani A B, et al. Electrophoretic de-position of spherical carbonyl iron particles on carbon fibers as a microwave absorbent composite[J]. Surf Interfaces, 2016,5:1.
19Gupta A, Choudhary V. Electromagnetic interference shielding behavior of poly(trimethylene terephthalate)/multi-walled carbon nanotube composites[J]. Compos Sci Technol, 2011,71(13):1563.
20Alam R S, Moradi M, Nikmanesh H. Influence of multi-walled carbon nanotubes (MWCNTs) volume percentage on the magnetic and microwave absorbing properties of BaMg_0.5Co_0.5TiFe₁₀O₁₉/MWCNTs nanocomposites[J]. Mater Res Bull, 2016,73:261.
21Xu Y, Yuan L, Cai J, et al. Smart absorbing property of composites with MWCNTs and carbonyl iron as the filler[J]. J Magn Magn Mater, 2013,343(5):239.
22Afghahi S S S, Peymanfar R, Javanshir S, et al. Synthesis, characterization and microwave characteristics of ternary nanocomposite of MWCNTs/doped Sr-hexaferrite/PANI[J]. J Magn Magn Mater, 2016,423:152.
23Wang W, Li Q, Chang C. Effect of MWCNTs content on the magnetic and wave absorbing properties of ferrite-MWCNTs composites[J]. Synth Met, 2011,161(1-2):44.
24Munnazza Bibi, Syed Mustansar Abbas, Nisar Ahmad, et al. Microwaves absorbing characteristics of metal ferrite/multiwall carbon nanotubes nanocomposites in X-band[J]. Composites Part B, 2017,114:139.
25Huang L, Liu X, Dan C, et al. Flaky FeSiAl alloy-carbon nanotube composite with tunable electromagnetic properties for microwave absorption[J]. Sci Rep, 2016,6:35377.
26Xia R, Yin Y, Zeng M, et al. High-frequency absorption of the hybrid composites with spindle-like Fe₃O₄ nanoparticles and multiwalled carbon nanotubes[J]. Nano Brief Rep Rev, 2016,11(9):16397.
27Zhang Y, Zhang A, Ding L, et al. The effect of polymer spatial configuration on the microwave absorbing properties of non-covalent modified MWNTs[J]. Composites Part A, 2016,81(4):264.
28Kachusova A O, Ulianova O A, Dotsenko O A, et al. Effect of ultrasonic treatment on electromagnetic properties of composites based on multiwall carbon nanotubes at microwave frequency range[C]∥ International Conference of Young Specialists on Micro/nanotechno-logies and Electron Devices. Erlagol:IEEE, 2016:48.
29Kong L, Yin X, Han M, et al. Carbon nanotubes modified with ZnO nanoparticles: High-efficiency electromagnetic wave absorption at high-temperatures[J]. Ceram Int, 2015,41(3):4906.
30Yang C, Jiang J, Liu X, et al. Rare earth ions doped polyaniline/cobalt ferrite nanocomposites via a novel coordination-oxidative polymerization-hydrothermal route: Preparation and microwave-absor-bing properties[J]. J Magn Magn Mater, 2016,404(36):45.
31Qiu H, Wang J, Qi S, et al. Microwave absorbing properties of multi-walled carbon nanotubes/polyaniline nanocomposites[J]. J Mater Sci: Mater Electron, 2015,26(1):564.
32Chen D, Wang G S, He S, et al. Controllable fabrication of mono-dispersed RGO-hematite nanocomposites and their enhanced wave absorption properties[J]. J Mater Chem A, 2013,1(19):5996.
33Weng X, Li B, Zhang Y, et al. Synthesis of flake shaped carbonyl iron/reduced graphene oxide/polyvinyl pyrrolidone ternary nanocomposites and their microwave absorbing properties[J]. J Alloy Compd, 2017,695:508.
34Liu P, Huang Y, Zhang X. Preparation and excellent microwave absorption properties of ferromagnetic graphene/poly(3, 4-ethylene-dioxythiophene)/CoFe₂O₄, nanocomposites[J]. Powder Technol, 2015,276:112.
35Huang X, Yan X, Xia L, et al. A three-dimensional graphene/Fe₃O₄ /carbon microtube of sandwich-type architecture with improved wave absorbing performance[J]. Scr Mater, 2016,120:107.
36Chih-Chia Chen, Wen-Fan Liang, Yu-Hsun Nien, et al. Microwave absorbing properties of flake-shaped carbonyl iron/reduced graphene oxide/epoxy composites[J]. Mater Res Bull, 2017,DOI:10.1016/j. materres bull.2017.01.045.
37Han M, Yin X, Duan W, et al. Hierarchical graphene/SiC nanowire networks in polymer-derived ceramics with enhanced electromagnetic wave absorbing capability[J]. J Eur Ceram Soc, 2016,36(11):2695.
38Chen Y, Zhang A, Ding L, et al. A three-dimensional absorber hybrid with polar oxygen functional groups of MWNTs/graphene with enhanced microwave absorbing properties[J]. Composites Part B, 2017,108:386.
39Chen D, Wang G S, He S, et al. Controllable fabrication of mono-dispersed RGO-hematite nanocomposites and their enhanced wave absorption properties[J]. J Mater Chem A, 2013,1(19):5996.
40Sun D, Zou Q, Qian G, et al. Controlled synthesis of porous Fe₃O₄-decorated graphene with extraordinary electromagnetic wave absorption properties[J]. Acta Mater, 2013,61(15):5829.
41Yu H, Wang T, Wen B, et al. Graphene/polyaniline nanorod arrays: Synthesis and excellent electromagnetic absorption properties[J]. J Mater Chem, 2012,22(40):21679.
42Gao Feng,Li Pengfei,Wang Qun.Flattening effect on FeSiAl alloy structure and magnetic properties[J].Electron Compon Mater,2009,28(1):31(in Chinese).
高峰, 李鹏飞, 王群. 扁平化对FeSiAl合金结构及电磁特性的影响[J]. 电子元件与材料, 2009,28(1):31.
43Zong M, Huang Y, Zhang N, et al. Influence of (RGO)/(ferrite) ratios and graphene reduction degree on microwave absorption pro-perties of graphene composites[J]. J Alloy Compd, 2015,644:491.
44Dan C, Liu X, Yu R, et al. Enhanced microwave absorption properties of flake-shaped FePCB metallic glass/graphene composites[J]. Composites Part A, 2016,89:33.
45Fan Y, Yang H, Li M, et al. Evaluation of the microwave absorption property of flake graphite[J]. Mater Chem Phys, 2009,115(2-3):696.
46Fan Y, Yang H, Liu X, et al. Preparation and study on radar absorbing materials of nickel-coated carbon fiber and flake graphite[J]. J Alloy Compd, 2008,461(1-2):490.
47Yang W, Fu Y, Xia A, et al. Microwave absorption property of Ni-Co-Fe-P-coated flake graphite prepared by electroless plating[J]. J Alloy Compd, 2012,518(2):6.
48Liu Z, He F, Gao F, et al. Fabrication and electromagnetic properties of novel FeNi alloy-coated flake graphite prepared by electroless plating[J]. J Alloy Compd, 2016,656:51.
49Wang Chen,Kang Feiyu,Gu Jialin.Iron cobalt nickel alloy particle/graphite flake preparation and absorbing properties of composite materials research[J].J Inorg Mater, 2010,25(4):406(in Chinese).
王晨, 康飞宇, 顾家琳. 铁钴镍合金粒子/石墨薄片复合材料的制备与吸波性能研究[J]. 无机材料学报, 2010,25(4):406.
50Wang C, Lv R, Huang Z, et al. Synthesis and microwave absorbing properties of FeCo alloy particles/graphite nanoflake composites[J]. J Alloy Compd, 2011,509(2):494.
51Shen G, Xu Y, Liu B, et al. Enhanced microwave absorption pro-perties of N-doped ordered mesoporous carbon plated with metal Co[J]. J Alloy Compd, 2016,680:553.
52Wu H, Wang L, Wang Y, et al. Enhanced microwave absorbing properties of carbonyl iron-doped Ag/ordered mesoporous carbon nanocomposites[J]. Mater Sci Eng B, 2012,177(6):476.
53Du Y, Liu T, Yu B, et al. The electromagnetic properties and microwave absorption of mesoporous carbon[J]. Mater Chem Phys, 2012,135(2-3):884.
54Ma Y Z, Yin X W, Quan L I. Effects of heat treatment temperature on microstructure and electromagnetic properties of ordered mesoporous carbon[J]. Trans Nonferr Met Soc China, 2013,23(6):1652.
55Jyoti Prasad Gogoi, Nidhi Saxena Bhattacharyya, Satyajib Bhattacharyya. Single layer microwave absorber based on expanded gra-phite-novolac phenolic resin composite for X-band applications[J]. Composites Part B, 2014,58:518.
56Xu Y, Yan Z, Zhang D. Microwave absorbing property of a hybrid absorbent with carbonyl irons coating on the graphite[J]. Appl Surf Sci, 2015,356:1032.
57Li Xueai,Wang Chunsheng,Han Xijiang.In situ chemical precipita-tion of preparing Fe₃O₄-graphite composites absorbing performance[J].Mater Eng, 2015,43(5):44(in Chinese).
李雪爱, 王春生, 韩喜江. 原位化学沉淀法制备Fe₃O₄-石墨复合材料的吸波性能[J]. 材料工程, 2015,43(5):44.
58Zhang Y, He P, Yuan J, et al. Effects of graphite on the mechanical and microwave absorption properties of geopolymer based compo-sites[J]. Ceram Int, 2016,43(2):2325.
59Li Jia,Liu Hongbo,Yang Li.Nano iron cobalt alloy/graphite composite materials microwave absorbing performance of the research[J].J Inorg Mater, 2014,29(5):470(in Chinese).
李佳, 刘洪波, 杨丽. 纳米铁钴合金/石墨复合材料的微波吸收性能研究[J]. 无机材料学报, 2014,29(5):470.
60Xu Feng,Xiang Chen,Li Liangchao,et al.CoFe₂O₄ and the preparation of expanded graphite composites with electromagnetic properties[J].J High School Chem, 2013,34(10):2254(in Chinese).
许峰, 向晨, 李良超,等. CoFe₂O₄及其膨胀石墨复合物的制备与电磁性能[J]. 高等学校化学学报, 2013,34(10):2254.