磷尾矿材料化综合利用途径研究进展

Abstract
Figure/Table
References
Related Citation (8)

Download:

Full Text ( PDF ) (2027KB)
Export: BibTeX | EndNote (RIS)

Abstract The phosphorus chemical industry has a huge industrial scale, which is the pillar industry of national economic development in China. As the basic raw material of phosphorus chemical industry, phosphate concentrate mainly originates from phosphate rock by mineral processing. The stock of associated phosphate tailings is increasing year by year, which not only occupies a lot of land, but also leads to serious environmental pollution problems, such as vegetation damage, water pollution and the safety risk of dam break. Based on the introduction of the main sources, hazards and traditional utilization methods of phosphate tailings, the utilization ways of phosphate tailings materials are summarized according to the research status and development trend in recent years in this paper. The utilization direction of phosphate tailings is highlighted, which is from the simple utilization mode of phosphate tailings as filling materials and roadbed materials to the utilization mode of a large number of high content elements Ca, Mg and Si and Al in phosphate tailings to prepare multi-functional and high value-added materials, such as light heat insulation and fire resistance. At the same time, the direct preparation of green high value-added materials from phosphate tailings is prospected, the corresponding fabrication problems needed to be solved are pointed out.

Key words： phosphate tailings materialization comprehensive utilization high added value

Published: 09 December 2021

CLC number:

X754

Fund:This work was financially supported by the Key Research and Development Program of Hubei Province (2020BCA082) and the Natural Science Foundation of Hubei Province (2020CFB123).

About author:: Yang Huang graduated from Wuhan University of Science and Technology in June 2020 with a bachelor of engineering degree. Now he is a master candidate of the School of Resources and Environmental Engineering, Wuhan University of Science and Technology. At pre-sent, the main research field is the material utilization of phosphorus tailings.
Nanyan Hu served in Wuhan University of Science and Technology. She is currently a lecturer with Ph.D. degree. She has publishedmore than 20 research papers, and authorized more than 10 national inventionpatents. Her main research direction is the materialized utilization of tailings.

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	HUANG Yang
	YE Yicheng
	HU Nanyan
	WANG Weiqi
	ZHANG Jie

Cite this article:

HUANG Yang,YE Yicheng,HU Nanyan, et al. Research Progress in Materialized Utilization of Phosphate Tailings[J]. Materials Reports, 2021, 35(z2): 279-284.

URL:

http://www.mater-rep.com/EN/ OR http://www.mater-rep.com/EN/Y2021/V35/Iz2/279

1 李朋德. 江西建材, 2021(4), 46.
2 唐仁敏. 中国经贸导刊, 2021(8), 14.
3 魏浩杰, 于皓, 彭犇, 等.中国资源综合利用, 2019, 37(11), 56.
4 张汉泉, 许鑫, 胡超杰, 等.中国矿业, 2021, 30(4), 50.
5 刘虹利, 张均, 王永卿, 等. 矿产综合利用, 2017(1), 6.
6 李阳.有色金属设计, 2020, 47(2), 104.
7 张晋, 贺爱平, 李国栋, 等.矿产综合利用, 2021(2), 199.
8 孙娜, 尤彩霞. 河南科技, 2019(10), 126.
9 刘润哲, 刘丽芬, 欧志兵, 等. 化工矿物与加工, 2020, 49(2), 52.
10 李鹏毅, 张冬冬, 宁平, 等. 化工矿物与加工, 2019, 48(2), 66.
11 吴琼慧, 刘志学, 陈业阳, 等. 环境科学研究, 2020, 33(5), 1233.
12 周雪娜, 关洪亮, 何东升, 等. 广州化工, 2021, 49(5), 24.
13 冯安生, 吕振福, 武秋杰, 等. 矿产保护与利用, 2018(2), 40.
14 吴汉军. 磷尾矿综合利用研究. 硕士学位论文, 武汉工程大学, 2015.
15 彭倩坤. 磷尾矿库区土壤重金属的污染及修复技术研究. 硕士学位论文,重庆大学, 2014.
16 刘美美, 施泽明, 倪师军. 矿物学报, 2013, 33(S2), 703.
17 禹鹤. 高镁磷尾矿制备复混肥料技术开发. 硕士学位论文,郑州大学, 2016.
18 孙娜, 尤彩霞. 河南科技, 2019(10), 126.
19 郑建国, 于南树, 刘永秀, 等. 化工矿物与加工, 2019, 48(7), 64.
20 卢玉莲, 张钦, 张富强, 等. 化工矿物与加工, 2019, 48(8), 68.
21 雷汉民, 文武强, 肖艳华, 等. 矿产保护与利用, 2018(2), 123.
22 张文, 陈跃, 田言, 等. 化工矿物与加工, 2016, 45(5), 20.
23 郑建国, 于南树, 刘永秀, 等. 无机盐工业, 2020, 52(2), 43.
24 张萍花, 燕云洁, 陈建钧, 等. 无机盐工业, 2019, 51(3), 63.
25 张萍花, 刘代俊, 陈建钧. 现代化工, 2016, 36(3), 104.
26 张萍花, 张春丽, 王红艳, 等. 现代化工, 2017, 37(5), 102.
27 张萍花, 李梦婷, 李晓玲, 等. 宿州学院学报, 2018, 33(5), 113.
28 杨丽. 磷尾矿充填体中有害元素的溶出行为研究. 硕士学位论文,贵州大学, 2015.
29 王昊. 磷尾矿充填中有害元素地下迁移规律试验研究. 硕士学位论文,贵州大学, 2019.
30 邓晓轩, 纪宪坤, 田均兵, 等. 材料导报:综述篇, 2016,30(3), 95.
31 陈琴. 磷尾矿管道输送添加剂减阻试验研究. 硕士学位论文,贵州大学, 2016.
32 杨馨, 邱跃琴, 杨俊. 非金属矿, 2020, 43(5), 59.
33 邱跃琴, 高贺然, 黄远来, 等. 矿产保护与利用, 2017(6), 32.
34 Huynh L, Beattie D A, Fornasiero D, et al. Minerals Engineering, 2006, 19(1), 28.
35 Kim J H, Kwon S H, Kawashima S, et al. Cement & Concrete Compo-sites, 2017, 77, 60.
36 陈琴, 邱跃琴, 杨丽, 等. 化工矿物与加工, 2016, 45(9), 20.
37 黄远来. 磷尾矿胶结充填添加剂减阻输送及有害离子固化试验研究. 硕士学位论文,贵州大学, 2017.
38 黄远来, 邱跃琴, 高贺然. 矿业研究与开发, 2016, 36(12), 93.
39 龙文江. 添加剂对磷尾矿充填体有害离子无害化及机理研究. 硕士学位论文, 贵州大学, 2020.
40 龙文江, 邱跃琴, 杨馨, 等. 非金属矿, 2020, 43(1), 1.
41 陈博文, 梅甫定, 杨柳, 等. 安全与环境工程, 2015, 22(5), 145.
42 陈博文, 梅甫定, 卢开华. 金属矿山, 2015(10), 184.
43 陈博文, 梅甫定, 杨柳, 等. 科学技术与工程, 2015, 15(13), 25.
44 李延杰, 梅甫定, 叶峰, 等. 矿业研究与开发, 2017, 37(1), 30.
45 黄绪泉, 赵小蓉, 唐次来, 等. 环境工程学报, 2016, 10(10), 5957.
46 Chen Q, Zhang Q, Fourie A, et al. Journal of Environmental Management, 2017, 201, 19.
47 刘冬梅, 刘玉娇, 彭艳周, 等. 非金属矿, 2020, 43(4), 11.
48 刘冬梅, 卢希, 高德军. 中国矿业, 2020, 29(5), 126.
49 刘冬梅. 三峡大学学报(自然科学版), 2012, 34(4), 51.
50 庄心善, 王康, 李凯, 等. 公路工程, 2019, 44(1), 38.
51 庄心善, 李凯, 王康, 等. 湖北工业大学学报, 2019, 34(4), 104.
52 庄心善, 杨文博, 胡其志. 科学技术与工程, 2018, 18(5), 281.
53 庄心善, 王康, 王俊翔, 等. 南水北调与水利科技, 2018, 16(6), 164.
54 庄心善, 杨文博, 王康, 等. 人民黄河, 2020, 42(6), 140.
55 庄心善, 杨文博, 胡其志, 等. 人民长江, 2017, 48(S2), 244.
56 庄心善, 庄涛, 陶高梁, 等. 岩石力学与工程学报, 2020, 39(S1), 3032.
57 庄涛. 磷尾矿改良膨胀土动力特性研究. 硕士学位论文,湖北工业大学, 2020.
58 蔡宝成. 合成材料老化与应用, 2020, 49(2), 70.
59 张魁, 李红, 朱立位, 等. 江苏建筑, 2020(6), 88.
60 任园, 邵静. 公路, 2018, 63(11), 46.
61 吴非. 北方交通, 2019(3), 45.
62 毛伟, 龙泉名, 张庆刚, 等. 新世纪水泥导报, 2021, 27(1), 69.
63 顾炳伟, 赵龙伟, 胡杰, 等. 材料导报, 2015, 29(S2), 446.
64 茹晓红. 矿渣磷尾矿免烧砖的开发研究. 硕士学位论文,武汉理工大学, 2010.
65 王其林. 磷尾矿在建筑材料中的应用研究. 硕士学位论文,武汉工程大学, 2013.
66 Ettoumi M, Jouini M, Neculita C M, et al. Journal of Cleaner Production, 2021, 284, 124750.
67 丁云飞, 王剑平, 刘龙斌, 等. 矿产综合利用, 2019(1), 96.
68 向兴. 利用磷尾矿制备泡沫混凝土的研究. 硕士学位论文,武汉工程大学, 2015.
69 李家劲, 向兴, 尹亚, 等. 混凝土, 2016(12), 151.
70 向兴, 薛俊, 曾维, 等. 中国非金属矿工业导刊, 2013(3), 9.
71 李杰. 磷尾矿加气混凝土的制备及其性能分析. 硕士学位论文,武汉理工大学, 2011.
72 尚保亮. 建材工业信息, 2005(1), 34.
73 Boutaleb F, Boutaleb N, Bahlaouan B, et al. International Journal of Engineering and Technical Research, 2020, 9(2), 140.
74 Boutaleb F Z, Boutaleb N, Bahlaouan B, et al. Mediterranean Journal of Chemistry, 2020, 10(6), 568.
75 Perumal P, Piekkari K, Sreenivasan H, et al. Minerals Engineering, 2019, 144, 106026.
76 Provis J L, Deventer J. Alkali activated materials, state-of-the-art report, RILEM TC 224-AAM, Springer Netherlands, 2014, pp. 139.
77 Provis J L, Deventer J. Geopolymers, structure, processing, properties and industrial applications, Woodhead Publishing Limited, Ingram Publisher Services Distributor, 2009. pp. 89.
78 Feng D, Provis J L, van Deventer J S J. Journal of the American Ceramic Society, 2012, 95(2), 565.
79 Wu J, Li J, Rao F, et al. Chemosphere, 2020, 251, 126367.
80 Dabbebi R, Barroso D, Camoes A, et al. Construction and Building Materials, 2018, 185, 489.
81 Mabroum S, Aboulayt A, Taha Y, et al. Journal of Cleaner Production, 2020, 261, 121317.
82 Moukannaa S, Nazari A, Bagheri A, et al. Journal of Non-Crystalline Solids, 2019, 511, 76.
83 Haddaji Y, Majdoubi H, Mansouri S, et al. Materials Chemistry and Physics, 2021, 260, 124147.
84 He N A, Ma B, Hs A, et al. Minerals Engineering, DOI:10.1016/j.mineng. 2020,1065, 35.
85 吴洁, 饶峰, 印万忠. 金属矿山, 2020(8), 216.
86 邓国亮, 齐砚勇, 朱战甫. 非金属矿, 2016, 39(1), 44.
87 王丹, 齐砚勇, 朱战甫, 等. 水泥, 2017(12), 6.
88 Staněk T, Sulovsk Y P. Materials Characterization, 2009, 60(7), 749.
89 Zheng K, Zhou J, Gbozee M. Construction and Building Materials, 2015, 98, 593.
90 Idrissi H, Taha Y, Elghali A, et al. Materials Chemistry and Physics, 2021, 260, 124119.
91 梁兴荣, 薛俊, 曹宏. 混凝土与水泥制品, 2016(3), 87.
92 曹曦娇, 邱俊, 吕宪俊. 现代矿业, 2013(12), 152.
93 闫传霖. 金尾矿焙烧陶粒的制备与性能研究. 硕士学位论文,济南大学, 2014.
94 Chen H J, Wang S Y, Tang C W. Construction & Building Materials, 2010, 24(1), 46.
95 González-corrochano B, Alonso-azcárate J, Rodas M, et al. Construction and Building Materials, 2011, 25(8), 3591.
96 Cheeseman C R, Virdi G S. Resources Conservation & Recycling, 2005, 45(1), 18.
97 González-Corrochano B, Alonso-Azcárate J, Rodas M, et al. Construction and Building Materials, 2011, 25(8), 3591.
98 徐伟, 郑勇. 墙材革新与建筑节能, 2007(11), 30.
99 朱万旭, 酆磊, 周红梅, 等. 新型建筑材料, 2016, 43(10), 90.
100 刘莲香, 曾令可, 侯来广, 等. 砖瓦, 2005(6), 55.
101 李猛. 新型免烧陶粒的制备及其对生活污水处理的研究. 硕士学位论文,青岛理工大学, 2010.
102 蒋丽. 粉煤灰烧结陶粒制备及其强化废水中磷酸盐去除的试验研究. 硕士学位论文,湖南大学, 2012.
103 Riley C M. Journal of the American Ceramic Society, 1951, 34(4), 121.
104 Loutou M, Hajjaji M, Mansori M, et al. Journal of Environmental Ma-nagement, 2013, 130, 354.
105 吕品. 国土与自然资源研究, 2004(3), 96.
106 周婷婷, 封孝信, 谢元涛, 等. 水泥技术, 2020(5), 99.
107 沈凡, 韦国苏, 庞若楠, 等. 安全与环境学报, 2020, 20(6), 2303.
108 李晓燕. 磷尾矿烧制陶粒工艺及资源化利用的试验研究. 硕士学位论文,重庆大学, 2016.
109 Loutou M, Hajjaji M, Babram M A, et al. Journal of Building Enginee-ring, 2017, 11, 48.
110 Loutou M, Hajjaji M, Mansori M, et al. Journal of Environmental Ma-nagement, 2016, 177, 169.
111 Loutou M, Hajjaji M, Mansori M, et al. Journal of Environmental Ma-nagement, 2013, 130, 354.
112 Yang Y, Wei Z, Chen Y, et al. Construction and Building Materials, 2017, 155, 1081.
113 林小化. 白云石质磷尾矿制备抗水化环保型镁钙质耐火材料. 硕士学位论文,贵州大学, 2019.
114 林小化, 张煜, 廖裕辉, 等. 化工矿物与加工, 2019, 48(2), 57.
115 林小化, 张煜, 廖裕辉, 等. 化工矿物与加工, 2019, 48(1), 31.