木质与草本生物质燃烧特性及工况优化研究

doi:10.11896/j.issn.1005-023X.2017.06.011

Abstract
Figure/Table
References
Related Citation (5)

Download:

Full Text ( PDF ) (1453KB)
Export: BibTeX | EndNote (RIS)

Abstract In order to improve the combustion efficiency of the biomass fuel and alleviate corrosion problems in biomass power plant boiler. Under different oxygen stoichiometric ratio (14% and 42%, respectively) and different heating rates (10 ℃/min, 30 ℃/min, 60 ℃/min), using thermogravimetric analysis (TG-DTG) techniques on eucalyptus trees for fuel comparison, woody and herbaceous biomass of mixed fuel thermal cracking process and combustion characteristics were analyzed. Results show that every combustion processes are similar, under the same heating rate, eucalyptus trunk in combustion process performances a certain lag. Such as 10 ℃/min volatile at the analysis stage, M1-M5 perform maximum weight loss rate between 325-330 ℃, and eucalyptus trunk is in 336 ℃ with maximum weight loss rate. At the same time, with the increase of oxygen chemical equivalence ratio and the reduction of heating rate, the combustion characteristics of various fuels have been improved. In addition, in 14% O₂ condition blen-ding a higher proportion of bagasse (M2), in 42% O₂ under the condition of low mixing proportion of sugarcane bagasse (M4) can improve the early flammability and combustion characteristic, but the burnout characteristics perform poor. Therefore, bagasse and other herbaceous plants as the combustion supporting additive to ignite wood material, for the efficient and stable operation of biomass power plant to provide some suggestions.

Key words： mixed combustion biomass thermogravimetric analysis ignition temperature burnout temperature combustible characteristics

Published: 02 May 2018

CLC number:

TK6

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	HE Shanshan
	LI Wei
	WANG Lingzhi
	LU Han
	ZHANG Hongliang

Cite this article:

HE Shanshan,LI Wei,WANG Lingzhi, et al. Combustion Characteristics and Working Condition Optimization for
Wood and Herb Biomass[J]. Materials Reports, 2017, 31(6): 50-55.

URL:

http://www.mater-rep.com/EN/10.11896/j.issn.1005-023X.2017.06.011 OR http://www.mater-rep.com/EN/Y2017/V31/I6/50

1 Manzano-Agugliaro F, Alcayde A, Montoya F G. Scientific production of renewable energies worldwide: An overview[J]. Renewable Sustainable Energy Rev,2013,18:134.
2 Panwar N L, Kaushik S C, Kothari S. Role of renewable energy sources in environmental protection: A review[J]. Renewable Sustainable Energy Rev,2011,15(3):1513.
3 Zhang J L, Li J, Hu Z W, et al. Thermal gravimetric analysis of mixed combustion of biomass and anthracite[J]. Acta Energiae Solaris Sin,2013,34(10):1847(in Chinese).
张建良,李净,胡正文,等.生物质与无烟煤混合燃烧行为的热重分析[J].太阳能学报,2013,34(10):1847.
4 Xiong S W, Zhang S Y, Wu Q M, et al. Combustion characteristics and kinetic analysis of biomass char[J]. J Fuel Chem Technol,2013,41(8):958(in Chinese).
熊绍武,张守玉,吴巧美,等.生物质炭燃烧特性与动力学分析[J].燃料化学学报,2013,41(8):958.
5 Liang A Y, Hui S E, Xu T M, et al. TG-DTG analysis of several kinds of biomass and Study on its combustion kinetics[J]. Rene-wable Energy Resour,2008,26(4):56(in Chinese).
梁爱云,惠世恩,徐通模,等.几种生物质的TG-DTG分析及其燃烧动力学特性研究[J].可再生能源,2008,26(4):56.
6 Wang X G, Lu G W, Lu J S, et al. Experimental study on combustion characteristics of biomass and coal blending[J]. Renewable Ene-rgy Resour,2014,32(1):87(in Chinese).
王晓钢,鲁光武,路进升,等.生物质与煤掺烧燃烧特性的实验研究[J].可再生能源,2014,32(1):87.
7 Shou E G, Li S Y, Ren Q Q, et al. Study on combustion characte-ristics of biomass and coal oxygen enriched mixture[J]. Renewable Energy Resour,2014,32(10):1551(in Chinese).
寿恩广,李诗媛,任强强,等.生物质与煤富氧混合燃烧特性研究[J].可再生能源,2014,32(10):1551.
8 Varol M, Atimtay A T, Bay B, et al. Investigation of co-combustion characteristics of low quality lignite coals and biomass with thermogravimetric analysis[J]. Thermochim Acta,2010,510(1):195.
9 Tian H, Liao Z Z. Agricultural biomass combustion characteristics and combustion dynamics[J]. Trans Chinese Soc Agric Eng,2013,29(10):203(in Chinese).
田红,廖正祝.农业生物质燃烧特性及燃烧动力学[J].农业工程学报,2013,29(10):203.
10 Tian Z F, Wang S Y, Cao Y W. Mechanism of biomass fuel combustion and the analysis of the factors affecting its combustion[J]. J Anhui Agric Sci,2014,42(2):541(in Chinese).
田仲富,王述洋,曹有为.生物质燃料燃烧机理及影响其燃烧的因素分析[J].安徽农业科学,2014,42(2):541.
11 Chen H B, Ning X A, Liao X K, et al. Analysis of heat and weight of waste and dust bag in cement plant and its morphological characteristics[J]. Acta Scientiae Circumstantiae,2013,33(7):1940(in Chinese).
陈海斌,宁寻安,廖希凯,等.水泥厂废旧除尘布袋热重分析及其形态特征[J].环境科学学报,2013,33(7):1940.
12 Liu X, Chen M, Wei Y. Kinetics based on two-stage scheme for co-combustion of herbaceous biomass and bituminous coal[J]. Fuel,2015,143:580.
13 Gai C, Zhang Y, Chen W T, et al. Thermogravimetric and kinetic analysis of thermal decomposition characteristics of low-lipid microalgae[J]. Bioresour Technol,2013,150:139.
14 Ren Minna. Experimental study on ignition and combustion characteristics of typical biomass pellet fuel[D]. Jinan: Shandong Jianzhu University,2012(in Chinese).
任敏娜.典型生物质颗粒燃料点火和燃烧特性的实验研究[D].济南:山东建筑大学,2012.
15 Varol M, Atimtay A T, Bay B, et al. Investigation of co-combustion characteristics of low quality lignite coals and biomass with thermogravimetric analysis[J]. Thermochim Acta,2010,510(1):195.
16 Zhang L H, Duan F, Huang Y J. Thermogravimetric investigation on characteristic of biomass combustion under the effect of organic calcium compounds[J]. Bioresour Technol,2015,175:177.
17 Ning X A, Zhang N, Liu J Y. Study on combustion characteristics and kinetics of paper mill sludge mixture[J]. Acta Scientiae Circumstantiae,2011,31(7):1486(in Chinese).
宁寻安,张凝,刘敬勇.造纸污泥混煤燃烧特性及动力学研究[J].环境科学学报,2011,31(7):1486.
18 Yang Zhe. Experimental study on the effect of mixed mode on the characteristics and combustion characteristics of mixed coal particles[D]. Changsha: Changsha University of Science & Technology,2013(in Chinese).
杨哲.掺混方式对混煤颗粒特性及燃烧特性影响的实验研究[D].长沙:长沙理工大学,2013.
19 Wei W, Liao Y F, Chen T, et al. Analysis of alkali metal transfer in the process of direct burning of Eucalyptus[J]. Guangdong Electric Power,2014,27(6):13(in Chinese).
韦威,廖艳芬,陈拓,等.桉树枝直燃利用过程中碱金属迁移规律分析[J].广东电力,2014,27(6):13.
20 Zhang Linhai. Study on the processing of crop straw solid forming[D]. Beijing: China Agricultural University,2014(in Chinese).
张林海.农作物秸秆固体成型预处理研究[D].北京:中国农业大学,2014.
21 Wu K, Liu J, Wu Y, et al. Pyrolysis characteristics and kinetics of aquatic biomass using thermogravimetric analyzer[J]. Bioresour Technol,2014,163:18.
22 Ahn S, Choi G, Kim D. The effect of wood biomass blending with pulverized coal on combustion characteristics under oxy-fuel condition[J]. Biomass Bioenergy,2014,71:145.
23 Chen Y, Duan J, Lin P, et al. Effect of oxygen content on combustion characteristics of typical biomass[J]. Proceed CSEE,2008,28(2):43(in Chinese).
陈祎,段佳,林鹏,等.氧量对典型生物质燃烧特性的影响[J].中国电机工程学报,2008,28(2):43.
24 Chen Y L, Han X, Zhang Y F. Study on combustion kinetics of biomass straw[J]. Eng J Wuhan University,2013,46(6):805(in Chinese).
陈义龙,韩旭,张岩丰.生物质秸秆燃烧动力学特性研究[J].武汉大学学报:工学版,2013,46(6):805.
25 Pu G, Lei Q, Xu P. Heat weight of biomass burning and dynamic characteristics of plate[J]. Chinese J Environ Eng,2012,6(7):2432(in Chinese).
蒲舸,雷强,徐鹏.板材类生物质燃烧及动力学特性热重研究[J].环境工程学报,2012,6(7):2432.