氯盐环境下沥青与沥青混合料性能及劣化机理研究进展

doi:10.11896/cldb.21110001

Abstract
Figure/Table
References
Related Citation (4)

Download:

Full Text ( PDF ) (9292KB)
Export: BibTeX | EndNote (RIS)

Abstract Aiming at the impact of chloride salt environment on asphalt pavement performance and deterioration mechanism under actual working conditions, previous studies conducted on the performance and deterioration mechanism of asphalt and asphalt mixture in chloride salt environment are reviewed in this paper, including the laboratory simulation design of the chloride salt environment, impacts of the chloride salt environment on the material performance and deterioration mechanism aspects, also, the future development direction is suggested. The recent study primarily analyzes the performance deterioration process of asphalt and asphalt mixture in the chlorine salt environment via the laboratory simulation accelerated test. However, commonly used laboratory simulation methods of chloride salt environments only consider the impacts of salt, which is inconsistent with the state where the asphalt pavement is subjected to the combined action of several factors, including vehicle load and temperature during the practical service. Moreover, poor correlations are observed in the test results obtained using different test schemes owing to the divergence in the type and concentration of chloride salt, asphalt type, temperature, and circulation mode. The analysis of the impact of the chloride environment on the material performance and its deterioration mechanism primarily based on the laboratory simulation accelerated test, and lacks of in-depth discussion by means of numerical simulation. These test methods and single research mean of the chloride environment are difficult to objectively analyze the corrosion risk and deterioration mechanism of the chloride environment on the performance of asphalt pavement in-service. Therefore, it is recommended further optimizing the chloride salt environment laboratory simulation test plan and establishing a numerical simulation system, from the view of the diffusion mechanism of chloride salt ions in the asphalt mixture, the physical or chemical reactions and corrosion products between chloride-asphalt/aggregate. The laboratory test is organically combined with multiphysics numerical simulation to rea-lize the equivalent conversion of the simulation parameters and actual indicators, and to further explore the performance deterioration and mechanism of different types of asphalt and asphalt mixtures in the chloride environment under real service conditions.

Key words： chloride salt environment asphalt and asphalt mixture service performance degradation mechanism multi-field coupling

Published: 10 August 2023 Online: 2023-08-07

CLC number:

U414

Fund:National Natural Science Foundation of China(51308084), the Fundamental Research Funds for the Central Universities (3132017029), Special Project for ‘Double First Class' Construction of Dalian Maritime University (BSCXXM021), Liaoning Highway Science and Technology Innovation Key Scientific Research Project (201701), and Dalian Science and Technology Innovation Fund Project (2020JJ26SN062).

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	CHU Zhaoyang
	GUO Naisheng
	FANG Chenze
	TAN Yiqiu
	YOU Zhanping

Cite this article:

CHU Zhaoyang,GUO Naisheng,FANG Chenze, et al. Research Progress on Performance and Deterioration Mechanism of Asphalt and Asphalt Mixture in Chloride Environment[J]. Materials Reports, 2023, 37(15): 21110001-9.

URL:

http://www.mater-rep.com/EN/10.11896/cldb.21110001 OR http://www.mater-rep.com/EN/Y2023/V37/I15/21110001

1 Yu H J. The macro-and meso-damage mechanism of concrete under different kinds of salt attack. Master's Thesis, Jilin University, China, 2017(in Chinese).
禹虹机. 不同类盐蚀对混凝土的宏细观损伤机理. 硕士学位论文, 吉林大学, 2017.
2 Li W J. Simulation of chloride ions erosion in concrete under loadings and environmental factors. Ph.D. Thesis, Southeast University, China, 2019(in Chinese).
李万金. 荷载与环境因素作用下氯离子侵蚀混凝土过程模拟. 博士学位论文, 东南大学, 2019.
3 Xiong R, Chu C, Qiao N, et al. Construction and Building Materials, 2019, 201, 121.
4 Setiadji B H, Utomo S N. International Journal of Pavement Research and Technology, 2017, 10(2), 122.
5 Liu Z Z, Sha A M, Xing M L, et al. Cold Regions Science and Technology, 2015, 114, 9.
6 Behnam A, Saleh S T. International Journal of Pavement Engineering, 2014, 15(5), 383.
7 Yang D Y, Luo J J. Construction and Building Materials, 2012, 36, 129.
8 Dang Y D, Xie N, Kessel A, et al. Construction and Building Materials, 2014, 55(1), 128.
9 Peng J X, Wang H, Zhang J R, et al. China Journal of Highway and Transport, 2014, 27(6), 77(in Chinese).
彭建新, 王华, 张建仁, 等. 中国公路学报, 2014, 27(6), 77.
10 Cao J. Experimental study on corrosion resistance of basalt fiber concrete in saline soil environment of southern Xinjiang. Master's Thesis, Tarim University, China, 2021(in Chinese).
操镜. 南疆盐渍土环境下玄武岩纤维混凝土耐腐蚀性能试验研究. 硕士学位论文, 塔里木大学, 2021.
11 Xiao Z A, Lai Y M. Chinese Journal of Rock Mechanics and Engineering, 2018, 37(S1), 3738(in Chinese).
肖泽岸, 赖远明. 岩石力学与工程学报, 2018, 37(S1), 3738.
12 Liao M K, Liu E L, Fu L, et al. Concrete, 2019(1), 81(in Chinese).
廖孟柯, 刘恩龙, 付林, 等. 混凝土, 2019(1), 81.
13 Li J, Gao P W, Liu H W, et al. Journal of Nanjing University of Science and Technology, 2017, 41(5), 666(in Chinese).
李隽, 高培伟, 刘宏伟, 等. 南京理工大学学报, 2017, 41(5), 666.
14 Lu K, Xue W, Xu J C, et al. Concrete, 2021(2), 4(in Chinese).
卢凯, 薛文, 徐锦超, 等. 混凝土, 2021(2), 4.
15 Zheng M, Wang C, Han L, et al. International Journal of Pavement Research and Technology, 2016, 9(2), 140.
16 Zhao L H, Zeng Y Y, Gao L. Highway Engineering, 2020, 45(4), 183(in Chinese).
赵丽华, 曾勇银, 高亮. 公路工程, 2020, 45(4), 183.
17 He H H. Study on the selection of snowmelt agent and its influence on the performance of asphalt concrete. Master's Thesis, Northeast Forestry University, China, 2020(in Chinese).
贺皓皓. 融雪剂选择及其对沥青混凝土性能影响的研究. 硕士学位论文, 东北林业大学, 2020.
18 Zhou Z G, Li H J, Liu X, et al. Journal of Building Materials, 2020, 23(6), 1430(in Chinese).
周志刚, 李浩嘉, 刘鑫, 等. 建筑材料学报, 2020, 23(6), 1430.
19 Guo Q L, Li G Y, Gao Y, et al. Construction and Building Materials, 2019, 206, 590.
20 Zhang K, Zhang Z Q. Journal of Wuhan University of Technology, 2014, 36(9), 48(in Chinese).
张苛, 张争奇. 武汉理工大学学报. 2014, 36(9), 48.
21 Zhang K, Zhang Z Q. Journal of South China University of Technology (Natural Science Edition), 2015, 43(8), 106(in Chinese).
张苛, 张争奇. 华南理工大学学报(自然科学版), 2015, 43(8), 106.
22 Zhang K, Li W L, Han F F. Construction and Building Materials, 2019, 208(5), 749.
23 Liao D Y. Effect of calcium chloride solution on pavement performance of asphalt mixture under freeze-thaw cycle. Master's Thesis, Chongqing Jiaotong University, China, 2019(in Chinese).
廖德扬. 冻融循环作用下氯化钙溶液对沥青混合料路用性能影响的研究. 硕士学位论文, 重庆交通大学, 2019.
24 Cui Y N, Chen D S, Li Z. Highway Engineering, 2018, 43(5), 48(in Chinese).
崔亚楠, 陈东升, 李震. 公路工程, 2018, 43(5), 48.
25 Cui Y N, Chen R P, Han J W, et al. Bulletin of the Chinese Ceramic Society, 2018, 37(4), 1467(in Chinese).
崔亚楠, 陈瑞璞, 韩吉伟, 等. 硅酸盐通报, 2018, 37(4), 1467.
26 Liu B K. Study on the properties of asphalt mixture and its failure mechanism under freeze-thaw cycles with deicers. Master's Thesis, Chang'an University, China, 2017(in Chinese).
刘宝奎. 盐冻融作用下沥青混合料性能及破坏机理研究. 硕士学位论文, 长安大学, 2017.
27 Wang L, Gong N N, Xing Y M. Journal of Functional Materials, 2016, 47(4), 88(in Chinese).
王岚, 弓宁宁, 邢永明. 功能材料, 2016, 47(4), 88.
28 Feng L, Cheng Z, Wan L, et al. Bulletin of the Chinese Ceramic Society, 2021, 40(5), 1743(in Chinese).
冯蕾, 陈征, 王岚, 等. 硅酸盐通报, 2021, 40(5), 1743.
29 Wang L, Wang Y. Journal of Building Materials, 2016, 19(4), 773(in Chinese).
王岚, 王宇. 建筑材料学报, 2016, 19(4), 773.
30 Xiong R, Jiang W Y, Li K H, et al. Applied Chemical Industry, 2020, 49(3), 545(in Chinese).
熊锐, 蒋汶玉, 李科宏, 等. 应用化工, 2020, 49(3), 545.
31 Xiong R, Wang L, Yang F, et al. Technology of Highway and Transport, 2016, 32(5), 32(in Chinese).
熊锐, 王璐, 杨发, 等. 公路交通技术, 2016, 32(5), 32.
32 Xiong R, Wang L, Guan B W, et al. International Journal of Pavement Research and Technology, 2015, 8(1), 53.
33 Xiong R, Cu C, Guan B W, et al. International Journal of Pavement Engineering, DOI:10. 1080/10298436. 2020. 1802025.
34 Chu C, Liu K P, Li K H. Bulletin of the Chinese Ceramic Society, 2018, 37(12), 3906(in Chinese).
褚辞, 刘开平, 李科宏. 硅酸盐通报, 2018, 37(12), 3906.
35 Chu C. Study on salt corrosion deterioration characteristics of asphalt mixture under multi-factor action. Master's Thesis, Chang'an University, China, 2019(in Chinese).
褚辞. 多因素作用下沥青混合料盐蚀劣化特性研究. 硕士学位论文, 长安大学, 2019.
36 Li C, Xiong R, Li S, et al. Journal of Materials Science and Enginee-ring, 2022, 40(2), 1(in Chinese).
李闯, 熊锐, 李松, 等. 材料科学与工程学报, 2022, 40(2), 1.
37 Pan B F. Study on the evaluation method of pavement materials damage under hydrodynamic pressure. Ph.D. Thesis, Dalian University of Technology, China, 2010(in Chinese).
潘宝峰. 动水压力作用下路面材料损伤的评价方法研究. 博士学位论文, 大连理工大学, 2010.
38 Wei P K. Study on the damage of asphalt concrete under the action of hydrodynamic water pressure. Master's Thesis, Chongqing Jiaotong University, China, 2013(in Chinese).
魏鹏克. 动水压力作用下沥青混凝土路面破坏研究. 硕士学位论文, 重庆交通大学, 2013.
39 Wang Z Y. Study on the water-damage of asphalt pavement under hydrodynamic pressure. Master's Thesis, Jilin University, China, 2016(in Chinese).
王振勇. 动水压力作用下沥青路面水损坏研究. 硕士学位论文, 吉林大学, 2016.
40 Xu R G. Study on the effect of sodium erosion on asphalt self-healing and fatigue performance. Master's Thesis, Guangxi University, China, 2019(in Chinese).
徐锐光. 钠盐侵蚀对沥青自愈合与疲劳特性的影响研究. 硕士学位论文, 广西大学, 2020.
41 Meng Y J, Xu R G, Guo H Y, et al. Construction and Building Materials, 2021, 286(122), 884.
42 Xiong R, Jiang W Y, Yang F, et al. Materials, 2019, 12, 3374.
43 Zhang K, Luo Y F, Xie W, et al. Materials Today Communications, 2020, 25, 1.
44 Zhang K, Luo Y F. Science Technology and Engineering, 2020, 20(36), 15081(in Chinese).
张苛, 罗要飞. 科学技术与工程, 2020, 20( 36), 15081.
45 Wang L, Jia Y J, Zhang D W, et al. Acta Materiae Compositae Sinica, 2016, 33(10), 2380(in Chinese).
王岚, 贾永杰, 张大伟, 等. 复合材料学报, 2016, 33(10), 2380.
46 Cui Y N, Han J W, Feng L, et al. Journal of Functional Materials, 2015, 46(18), 18037(in Chinese).
崔亚楠, 韩吉伟, 冯蕾, 等. 功能材料, 2015, 46(18), 18037.
47 Cui Y N, Sun G N, Han J W, et al. Acta Materiae Compositae Sinica, 2017, 34(4), 678(in Chinese).
崔亚楠, 孙广宁, 韩吉伟, 等. 复合材料学报, 2017, 34(4), 678.
48 Cui Y N, Han J W, Feng L, et al. Journal of Jilin University (Enginee-ring and Technology Edition), 2017, 47(2), 452(in Chinese).
崔亚楠, 韩吉伟, 冯蕾, 等. 吉林大学学报(工学版), 2017, 47(2), 452.
49 Zhang Q L. Study on water damage mechanism of asphalt mixture in multi-factor environment of the south coast. Ph.D. Thesis, Zhejiang University, China, 2020. (in Chinese)
张勤玲. 南方滨海多因素环境沥青混合料水损伤机理研究. 博士学位论文, 浙江大学, 2020.
50 Zhang Q L, Huang Z Y. Materials, 2019, 12(16), 2627.
51 Zhang Q L, Huang Z Y. Journal of Zhejiang University (Engineering Science), 2021, 55(1), 38(in Chinese).
张勤玲, 黄志义. 浙江大学学报(工学版), 2021, 55(1), 38.
52 Zhang Q L, Huang Z Y. Journal of Building Materials, 2020, 23(4), 920(in Chinese).
张勤玲, 黄志义. 建筑材料学报. 2020, 23(4), 920.
53 Meng Y J, Wei G P, Li Z H, et al. Journal of Guangxi University (Na-tural Science Edition), 2020, 45(1), 61(in Chinese).
孟勇军, 韦耿平, 李正华, 等. 广西大学学报(自然科学版), 2020, 45(1), 61.
54 Wei G P. Research on water stability and high temperature of TLA modified asphalt mixture under chloride attack. Master's Thesis, Guangxi University, China, 2018(in Chinese).
韦耿平. 氯盐侵蚀下TLA改性沥青混合料水稳定性及髙温性研究. 硕士学位论文, 广西大学, 2018.
55 Chen H L, Sha A M, Jiang W, et al. Journal of Highway and Transportation Research and Development, 2016, 33(12), 42(in Chinese).
陈华梁, 沙爱民, 蒋玮, 等. 公路交通科技, 2016, 33(12), 42.
56 Gong X B. Mechanical behavior and united models of asphalt pavement materials within multi-scales. Ph. D. Thesis, Harbin Institute of Technology, China, 2017(in Chinese).
龚湘兵. 沥青路面材料多尺度域力学行为及统一模型. 博士学位论文, 哈尔滨工业大学, 2017.
57 Huang H. Research on chlorine salt snowmelt agent's effect of asphalt mixture performance and mechanism. Master's Thesis, Changsha University of Science & Technology, China, 2014(in Chinese).
黄河. 氯盐类融雪剂对沥青混合料性能影响及作用机理的研究. 硕士学位论文, 长沙理工大学, 2014.
58 Fu G W. Research on Influence of snow melt agent to performances of asphalt and asphalt mixture. Master's Thesis, Changsha University of Science & Technology, China, 2010(in Chinese).
傅广文. 融雪剂对沥青及沥青混合料性能影响研究. 硕士学位论文, 长沙理工大学, 2010.
59 Huang X Y, Sha A M, Jiang W, et al. Journal of Chang'an University (Natural Science Edition), 2017, 37(3), 33(in Chinese).
黄新颜, 沙爱民, 蒋玮, 等. 长安大学学报(自然科学版), 2017, 37(3), 33.
60 Mansour F, Sajad J, Reza S, et al. Construction and Building Materials, 2019, 227(116), 581.
61 Zhang J, Airey G D, Grenfell J R A. Materials & Structures, 2016, 49, 2653.
62 Li W J. Study on adhesive properties of asphalt-aggregate interface under chloride salt erosion. Master's Thesis, Guangxi University, China, 2019(in Chinese).
李炜钧. 氯盐侵蚀下沥青与集料界面粘附性能研究. 硕士学位论文, 广西大学, 2019.
63 Chen Y, Dong S Z, Wang H N, et al. Construction and Building Materials, 2020, 240(118), 4.
64 Raquel M, Raul V, Hussain B. Construction and Building Materials, 2017, 130(15), 156.
65 Li Y, Wang Q Z. Highway, 2018(1), 191(in Chinese).
李杨, 王琦智. 公路, 2018(1), 191.
66 Chen J B. Study on damage of asphalt stabilized macadam under the coupling of load and sulfate. Master's Thesis, Changsha University of Science & Technology, China, 2018(in Chinese).
陈敬博. 荷载与硫酸盐耦合作用下ATB力学性能衰变特征研究. 硕士学位论文, 长沙理工大学, 2018.
67 Zhou X D, Chang C Q, Wang L. Journal of Building Materials, 2020, 23(3), 650(in Chinese).
周晓东, 常春清, 王岚. 建筑材料学报, 2020, 23(3), 650.
68 Hassan Y, Abdelhalim A O, Razaqpur A G, et al. Journal of Transportation Engineering, 2002, 128(4), 385.
69 Yu D. Research on performance decay characteristics and mechanism of basalt fiber-modified asphalt mixture under freeze-thaw cycles. Ph.D. Thesis, Jilin University, China, 2019(in Chinese).
余地. 冻融循环作用下玄武岩纤维沥青混合料性能衰变特性及机理研究. 博士学位论文, 吉林大学, 2019.
70 Qiu Q S, Wang Y W, Lin H Z, et al. Highway, 2021(7), 261(in Chinese).
邱庆生, 王永卫, 林汉忠, 等. 公路, 2021(7), 261.
71 Ma J K. Experimental research on performance of crumb rubber and SBS compound modified asphalt mixture under freeze-thaw cycles and dry-wet cycles with salt action. Master's Thesis, Changchun Institute of Techno-logy, China, 2017(in Chinese).
马建坤. 盐冻融与干湿循环作用下橡胶SBS复合改性沥青混合料性能试验研究. 硕士学位论文, 长春工程学院, 2017.
72 Feng D C, Yi J Y, Wang D S, et al. Cold Regions Science and Technology, 2010, 62, 34.
73 Yang Q B. Journal of Building Materials, 2005, 8(5), 495(in Chinese).
杨全兵. 建筑材料学报, 2005, 8(5), 495.
74 Wang X P. The research on the erosion damage mechanism of the acid rain on the asphalt and asphalt mixture. Master's Thesis, Changsha University of Science & Technology, China, 2014(in Chinese).
王晓鹏. 酸雨对沥青及沥青混合料的侵蚀破坏机理研究. 硕士学位论文, 长沙理工大学, 2014.
75 Hu F Z. Material surface and interface, East China University of Science and Technology Press, China, 2008(in Chinese).
胡福增. 材料表面与界面, 华东理工大学出版社, 2008.
76 Juli-Gándar L, Vega-Zamanillo Á, Calzada-Pérez M Á. Cold Regions Science and Technology, 2019, 164, 1.
77 Xiao Q Y, Hu H X, Wang L J, et al. Journal of Hebei University of Technology, 2012, 41(4), 64. (in Chinese)
肖庆一, 胡海学, 王丽娟, 等. 河北工业大学学报, 2012, 41(4), 64.