INORGANIC MATERIALS AND CERAMIC MATRIX COMPOSITES |
|
|
|
|
|
Modeling of the Compressive Strength of Basalt Fiber Concrete Based on Pore Structure Under Single-side Freeze-Thaw Condition |
ZHAO Yanru1, LIU Fangfang1, WANG Lei1, GUO Zilin2
|
1 School of Civil Engineering,Inner Mongolia University of Technology,Hohhot 010051, China 2 Shandong Tongyuan Design Group Co. Ltd,Jinan 250000, China |
|
|
Abstract In this paper, the effects of different basalt fiber content and freeze-thaw times on the frost resistance and pore structure of concrete were stu-died through the single-side freeze-thaw cycle test. Grey entropy method was used to analyze the influence of pore structure parameters on the compressive strength of concrete after freeze-thaw cycles.The contribution rate formula of basalt fiber under different freeze-thaw cycles was obtained by fitting. The compressive strength model was established based on multiple factors such as pore specific surface area, pore volume and basalt fiber contribution rate. The results showed that the compressive strength of the different fiber contents specimens decreased with the increase of freeze-thaw cycles, the air content, average pore chord length and pore spacing coefficient of specimens increased with the increase of freeze-thaw cycles, and the specific surface area of pores decreased with the increase of freeze-thaw cycles. In this test, the frost resistance of concrete is optimal when the fiber content is 0.2vol%. According to the grey entropy analysis, the correlation degree of compressive strength with the pore specific surface area and pore diameter of less than 100 μm is the highest.The regression effect of the compressive strength and the specific surface area of pores, pore volume and the contribution rate of basalt fiber is significant, which can predict the quantitative relationship between the compressive strength of basalt fiber concrete and the pore structure after the single-side freeze-thaw cycle test, and evaluate the durability of basalt fiber concrete in cold areas.
|
Published: 29 May 2020
|
|
Fund:This work was financially supported by the National Natural Science Foundation of China (11762015,11362013). |
About author:: Yanru Zhao is professor and supervisor of mechanics doctoral student, supervisor of civil engineering master. She currently works in department of architectural engineering, School of Civil Engineering, Inner Mongolia University of Technology. The mechanical properties and durability of concrete, electron beam moire technology and its application and the interface mechanical properties of fiber reinforced composites were main studied. |
|
|
1 Yang Quanbing. Salt damage to concrete, China Architecture & Building Press,China,2012(in Chinese). 杨全兵.混凝土盐冻破坏,中国建筑工业出版社,2012. 2 Zhu Fazhu. Experimental study on salt-frost resistance of rubber aggregate concrete. Master's Thesis, Tianjin University,China,2007(in Chinese). 祝发珠.橡胶集料混凝土抗盐冻性能试验研究.硕士学位论文,天津大学,2007. 3 Zhu Yunzhe. Study on salt-frost resistance and modification mechanism of nano-modified concrete. Master's Thesis,Harbin Institute of Technology,China,2015(in Chinese). 朱昀喆.纳米改性混凝土的抗盐冻性能及其改性机理研究.硕士学位论文,哈尔滨工业大学,2015. 4 Shen Litao. Research on the mechanism and prevention of salt-frost damage of pavement concrete. Master's Thesis,Hebei University of Technology,China,2011(in Chinese). 申力涛.路面混凝土盐冻破坏机理与防治研究.硕士学位论文,河北工程大学,2011. 5 Peng Miao,Huang Haoxiong,Liao Qinhe,et al. Journal of Xiamen University of Technology,2012,20(1),83(in Chinese). 彭苗,黄浩雄,廖清河,等.厦门理工学院学报,2012,20(1),83. 6 Li Zhonghua. Study on the resistance of road concrete to salt-frost erosion in cold area. Ph.D. Thesis,Harbin Institute of Technology,China,2009(in Chinese). 李中华.寒冷地区道路混凝土抗盐冻剥蚀性能研究.博士学位论文,哈尔滨工业大学,2009. 7 Zhang Guoqiang. Study on salt-frost resistance of concrete. Master's Thesis, Tsinghua University,China,2005(in Chinese). 张国强.混凝土抗盐冻研究.硕士学位论文,清华大学,2005. 8 Jie Y,Yue W. Construction and Building Materials,2018,168,975. 9 Mautusinovic T,Sipusic J,Vrbos N. Cement and Concrete Research,2003,33,1801. 10 Pann K S, Yen T. ACI Materials Journal,2003,100(4), 311. 11 JGJ55-2011, Specification for mix proportion design of ordinary concrete, China Architecture & Building Press,China,2011(in Chinese). 中华人民共和国住房和城乡建设部.JGJ55-2011,普通混凝土配合比设计规程,中国建筑工业出版社,2011. 12 GB/T50081-2002, Standard for text methods of mechanical performance of ordinary concrete, China Architecture & Building Press,China,2002(in Chinese). 中华人民共和国建设部国家质量监督检验检疫总局.GB/T50081-2002,普通混凝土力学性能试验方法标准,中国建筑工业出版社,2002. 13 GB/T50082-2009, Standard for text methods of long-term performance and durability of ordinary concrete,China Architecture & Building Press,China,2009(in Chinese). 中华人民共和国住房和城乡建设部中华人民共和国国家质量监督检验检疫总局.GB/T50082-2009,普通混凝土长期性能和耐久性能试验方法标准,中国建筑工业出版社,2009. 14 Chen Xia,Yang Huaquan,Zhou Shihua,et al. Journal of Building Mate-rials,2011,14(2),257(in Chinese). 陈霞,杨华全,周世华,等.建筑材料学报,2011,14(2),257. 15 Li B, Mao Z. Construction and Building Materials,2017,147,79. 16 Valenza J J,Scherer W. Materials and Structures,2007,40,259. 17 Tang Wei,Zhang Guangtai,Dong Haijiao,et al. Materials Reports A:Review Papers,2014,28(11),123(in Chinese). 唐巍,张广泰,董海蛟,等.材料导报:综述篇,2014,28(11),123. 18 Li Weiming,Xu Jinyu,Shen Liujun,et al. Acta Materiae Compositae Sinica,2008(2),135(in Chinese). 李为民,许金余,沈刘军,等.复合材料学报,2008(2),135. 19 Du Dong,Pang Qinghua. Modern comprehensive evaluation methods and case selection, Tsinghua University Press,China,2005(in Chinese). 杜栋,庞庆华.现代综合评价方法与案例精选,清华大学出版社,2005. 20 Liu Sifeng,et al. Grey system theory and its application,Science Press,China,2017(in Chinese). 刘思峰,等.灰色系统理论及其应用,科学出版社,2017. |
|
|
|