| RESEARCH PAPER |
|
|
|
|
|
| Research on Filler-bitumen Ratio and Viscosity-temperature Property of Activated Coal Gangue Modified Asphalt Mortar |
| XIONG Rui1, YANG Xiaokai1, YANG Fa2, LIU Ziming1,WANG Xiaowen1, CHEN Huaxin1
|
1 School of Materials Science and Engineering, Chang’an University, Xi’an 710061;
2 Yunnan Department of Transportation, Kunming 650031; |
|
|
|
|
Abstract The coal gangue is one of the largest industrial solid waste emissions in our country. Up to now, there is few research results about coal gangue′s activation in order to improve the performance of asphalt. In this article, dynamic shear rheological test (DSR), bending beam rheometer (BBR) and brook-field viscometer test (BV) were used to study the high and low temperature performance of asphalt mortar which was made of limestone slag and three types of activated coal gangue. The relationship between Eμ (viscous part of repeated creep stiffness) or S (creep stiffness) and filler-bitumen ratio was analyzed. Through rheological method and double linear simplified model, reasonable range and optimum point of filler-bitumen ratio of activated coal gangue modified asphalt were set forth. With the application of scanning electron microscope(SEM) and infrared-ray spectroscopy(IR), the reinforcing mechanism of coal gangue compound mineral fiber was researched. The results show that the identified filler-bitumen ratio of activated coal gangue modified asphalt mortar can balance the high and low temperature performance well. The activated coal gangue has better effect on the improvement of thermosensitivity of asphalt mortar than mineral powder due to its smaller mean grain size, bigger specific surface area and porous surface. The results will contribute to the resource utilization of abandoned coal in the asphalt pavement engineering.
|
|
Published: 25 January 2017
Online: 2018-05-02
|
|
|
|
|
1 Huang Bin, Ma Liping, Xu Wenjuan. Rsearch development of modified asphalt [J]. Mater Rev:Rev,2010,24(1):137(in Chinese).
黄彬,马丽萍,许文娟. 改性沥青的研究进展[J].材料导报:综述篇,2010,24(1):137.
2 Chen Zhiguo. Research on performance of volcanic ash asphalt mastic[D]. Harbin: Harbin Institute of Technology,2010(in Chinese).
陈志国.火山灰沥青胶浆路用性能的研究[D].哈尔滨:哈尔滨工业大学,2010.
3 Yang Xiaokai, Xiong Rui, Fan Tianqi, et al. Laboratory investigation of the rheological property of activated coal gangue modified asphalt binder [J]. Mater Rev:Res,2015,29(6):135(in Chinese).
杨晓凯,熊锐,范天奇,等.活化煤矸石改性沥青胶浆流变性能实验研究[J].材料导报:研究篇,2015,29(6):135.
4 Fu Tianling, Wu Yonggui, Ou Lisha, et al. Effects of different re-dox environments on the release of coal gangue contaminants[J]. Acta Scientiae Circumstantiae,2012,32(10):2476(in Chinese).
付天岭,吴永贵,欧莉莎,等.不同氧化还原环境对煤矸石污染物质释放的影响[J].环境科学学报,2012,32(10):2476.
5 Tang Z H, Dong X X, Yang Y, et al. Research on the relationship between grain composition and repose angle of coal gangue in Dongkuang mine[J].J Earth Sci,2014,25:309.
6 He A X, Liu N, Wei G F, et al. Coal-gangue acoustic signal recognition based on sparse representation [J]. Ind Instrumentation Control SystemsⅡ,2013,336:722.
7 李智慧,谭忆秋. 应用流变学研究沥青胶浆最佳粉胶比的确定方法[J].中外公路,2014,34(4):294.
8 Dou Huaibin. Design and pavement performance of ultra-thin snow melt salt asphalt mixture pavement overlay[D]. Xi’an: Chang’an University,2015(in Chinese).
豆怀兵. 超薄罩面盐化物自融雪沥青混合料组成与性能研究[D]. 西安:长安大学,2015.
9 沈金安. 沥青及沥青混合料路用性能[M].北京:人民交通出版社,2003.
10 Liao Zewen, Geng Ansong. Characterization of FT-IR analysis of asphaltenes and its geochemical implications [J]. Geochimica,2001,30(5):433(in Chinese).
廖泽文,耿安松.沥青质傅里叶变换红外光谱(FT-IR)分析及其在有机地球化学研究中的应用[J].地球化学,2001,30(5):433.
|
|
|
|
渝公网安备50019002502923号 © Editorial Office of Materials Reports.
2017, Vol. 31 
