路面基层混合料煤矸石掺配方式及耐久性试验研究

doi:10.11896/cldb.24010125

Abstract
Figure/Table
References
Related Citation (15)

Download:

Full Text ( PDF ) (40219KB)
Export: BibTeX | EndNote (RIS)

Abstract The application of coal gangue as road construction material in highway base is an effective way of green and high-value utilization of solid waste. In view of the tunneling coal gangue materials produced in northern Henan, the difference between coarse and fine aggregates of coal gangue and gravel was studied. Through repeated freeze-thaw test, dry shrinkage test and four-point bending fatigue test, the influence of coal gangue ratio replacement and particle size replacement of natural gravel on the durability of coal gangue mixture was analyzed. Based on XRD phase analysis test and SEM microscopic test, the internal mechanism of strength formation and failure of cement stabilized coal crushing mixture was discussed. The results show that the compressive strength of the four groups of mixtures after proportional replacement is 7.7%, 37.8%, 45.6% and 61.8% higher than that of 100%TCG, respectively. The order of strength loss rate and dry shrinkage coefficient is 100%LF＜40%TCG＜60%TCG ＜100%TCG, while the order of BDR value and fatigue life is opposite. The higher the content of coal gangue in the mixture, the greater the decrease in strength, the weaker the frost resistance, the greater the decrease in fatigue life, the greater the drying shrinkage. Under the particle size replacement method, replacing coarse and fine aggregates can increase the compressive strength and BDR value of the mixture and reduce the strength loss rate. The fatigue life of the mixture is ranked as 100%TCG ＜T4＜T1~2＜T1~3＜100%LF, while the dry shrin-kage strain of T1~2 and T1~3 is the smallest, and the dry shrinkage strain of T4 is the largest. Coal gangue fine aggregate has a gain effect on the dry shrinkage of the mixture, and more significantly affects the frost resistance of the mixture. The aggregate of 9.5—31.5 mm has more significant effect on the strength of the mixture, while the aggregate of 4.7—9.5 mm has less effect on the strength, frost resistance and fatigue life of the mixture. The mixture prepared by particle size replacement has better fatigue performance at low stress ratio, while the mixture prepared by proportional replacement is more suitable for high stress ratio scenarios. The increase of coal gangue aggregate will inhibit the production of gel and delay hydration reaction. 40%TCG and T4 produced more C-S-H gel and AFt crystal phase cementation, forming a dense gel network with stronger compactness and integrity. It is recommended that 40%TCG is used as the blending method of high-grade highway base.

Key words： pavement base tunneling coal gangue blending mode four-point bending fatigue micro-analysis

Published: Online: 2025-05-29

CLC number:

U414

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	WANG Decai
	WEI Jiawei
	HU Lei
	ZHANG Qing
	DONG Shi
	YANG Lan
	CHENG Kai

Cite this article:

WANG Decai,WEI Jiawei,HU Lei, et al. Experimental Study on Coal Gangue Mixing Method and Durability of Pavement Base Mixture[J]. Materials Reports, 2025, 39(11): 24010125-10.

URL:

https://www.mater-rep.com/EN/10.11896/cldb.24010125 OR https://www.mater-rep.com/EN/Y2025/V39/I11/24010125

1 Liu Z, Duan K R, Zhou M, et al. Materials Reports, 2024, 38(10), 88 (in Chinese).
刘泽, 段开瑞, 周梅, 等. 材料导报, 2024, 38(10), 88.
2 Li J Y, Wang J M. Journal of Cleaner Production, 2019, 239, 117946.
3 Huang X M, Rao Y L, Du K. Mining Safety & Environmental Protection, 2023, 50(6), 92(in Chinese).
黄学满, 饶吉来, 杜凯. 矿业安全与环保, 2023, 50(6), 92.
4 Tian Y R, Zhang X R, Liu J F, et al. Science & Technology Review, 2020, 38(22), 104 (in Chinese).
田怡然, 张晓然, 刘俊峰, 等. 科技导报, 2020, 38(22), 104.
5 Niu X L. Research & Application of Building Materials, 2013 (1), 17 (in Chinese).
牛小玲. 建材技术与应用, 2013 (1), 17.
6 Zhu X L, Zhang M, Wang D M, et al. Metal Mine, 2022(1), 21 (in Chinese).
祝小靓, 张明, 王栋民, 等. 金属矿山, 2022(1), 21.
7 Gao J. Study on coal gangue road performance in Bayan Gaolle mining area. Master’s Thesis, Inner Mongolia University of Technology, China, 2019 (in Chinese).
高健. 巴彦高勒矿区煤矸石路用性能研究. 硕士学位论文, 内蒙古工业大学, 2019.
8 Wang L, Sun L. Journal of Environmental Protection and Ecology, 2022, 23(3), 991.
9 Guo Y X, Li C, Li M. International Journal of Coal Preparation and Utilization, 2022, 42(3), 580.
10 Li Z, Guo T, Chen Y, et al. Materials Research Express, 2021, 8(12), 125502.
11 Guan J, Lu M, Yao X, et al. Crystals, 2021, 11(8), 993.
12 Liu N C. Study on road performance of coal gangue in cement stabilized macadam base. Master’s Thesis, Ningxia University, China, 2022 (in Chinese).
刘乃成. 煤矸石在水泥稳定碎石基层中的路用性能研究. 硕士学位论文, 宁夏大学, 2022.
13 Li M, Li C, Guo Y X, et al. Bulletin of the Chinese Ceramic Society, 2019, 38(9), 2895 (in Chinese).
李明, 李昶, 郭雨鑫, 等. 硅酸盐通报, 2019, 38(9), 2895.
14 Wu H X. Research of coal gangue in pavement base onthe applied technology. Master’s Thesis, Beijing University of Technology, China, 2016 (in Chinese).
武昊翔. 煤矸石在路面基层的应用技术研究. 硕士学位论文, 北京工业大学, 2016.
15 Ji X P, Cao H L, Liu L Q. Journal of Building Materials, 2016, 19(2), 342 (in Chinese).
纪小平, 曹海利, 刘陵庆. 建筑材料学报, 2016, 19(2), 342.
16 Su Z, Li X, Zhang Q. Journal of Cleaner Production, 2022, 363, 132408.
17 Zhu Y Y, Wang A G, Sun D S, et al. Journal of China Coal Society, 2021, 46(11), 3657 (in Chinese).
朱愿愿, 王爱国, 孙道胜, 等. 煤炭学报, 2021, 46(11), 3657.
18 Liu D, Li L H, Cui H J, et al. Journal of Tongji University (Natural Science), 2015, 43(3), 405 (in Chinese).
刘栋, 李立寒, 崔华杰. 同济大学学报(自然科学版), 2015, 43(3), 405.
19 Chen J X, Jia J Q, Zhang L H, et al. Ksce Journal of Civil Engineering, 2022, 26(8), 3520.
20 Ma L L, Zhang X, Liu F, et al. Journal of Building Materials, 2023, 26(7), 762 (in Chinese).
马璐璐, 张翛, 刘芳, 等. 建筑材料学报, 2023, 26(7), 762.
21 Duan X M. Study on the micro-structure and physical-mechanical performance of concrete with coal gangue as aggregate. Master’s Thesis, China University of Mining and Technology, China, 2014 (in Chinese).
段晓牧. 煤矸石集料混凝土的微观结构与物理力学性能研究. 硕士学位论文, 中国矿业大学, 2014.
22 Yu L, Xia J, Xia Z, et al. Construction and Building Materials, 2022, 338, 127626.