生物质供氢体协助低变质煤加氢热解提质的研究进展

doi:10.11896/cldb.20070237

Abstract
Figure/Table
References
Related Citation (1)

Download:

Full Text ( PDF ) (5204KB)
Export: BibTeX | EndNote (RIS)

Abstract Coal resource plays a crucial role in energy structure of China, but the utilization of low-rank coal meets some great challenges, such as energy waste, environmental pollution, etc. As a green renewable energy, biomass has some advantages of low-cost, high volatile and high H/C ratio. However, lots of hydrogen components in biomass are consumed via low-end utilization, resulting in the resource waste. The co-pyrolysis of low-rank coal and biomass not only changes the characteristics of coal pyrolysis, and improves the yield and quality of pyrolysis products, but makes full use of biomass resource, and alleviates the problem of environmental pollution, which results in the efficient, clean, and graded utilization of low-rank coal and biomass resource.
Currently, the researches of co-pyrolysis of low-rank coal and biomass mainly focus on the pyrolysis process optimization, the distribution rule of pyrolysis products, the synergy mechanism of co-pyrolysis and so on. Many works showed that the pyrolysis temperature, heating rate, biomass composition and other factors affected the distribution, yield and quality of products. In addition, compared to traditional pyrolysis, the new type pyrolysis, such as microwave pyrolysis and infrared pyrolysis, can markedly improve the pyrolysis efficiency, the yield and quality of pyrolysis products, which has gradually attracted the attention by scholars at home and abroad.
In this paper, the characteristics of pyrolysis product of four kinds of biomass (forest and agricultural products, algae, livestock products and municipal solid waste) assisted hydrogenated pyrolysis reactions of low-rank coalare roundly analyzed, and the hydrogenated co-pyrolysis mechanisms of biomass, such as catalysis of alkalis, radical reactions, and secondary reactions of volatiles, are summarized. In addition, the application of microwave pyrolysis and infrared pyrolysis in the field of co-pyrolysis are also introduced, and the development prospect of co-pyrolysis technology is forecasted.

Key words： low-rank coal biomass hydrogen-donor hydropyrolysis pyrolysis methods efficiency and quality improvement

Published: 10 May 2022 Online: 2022-05-09

CLC number:

TQ561.1

Fund:National Natural Science Foundation of China (51774227), Natural Science Basic Research Program of Shaanxi (2017ZDJC-33), Natural Science Basic Research Program Enterprise United Fund Project of Shaanxi (2019JLP-17), Innovation Capability Support Program of Shaanxi (2020TD-028), and Open Foundation of State Key Laboratory of Iron & Steel Industry Environmental Protection (YZC2019ky01).

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	ZHOU Jingjing
	ZHOU Jun
	WU Lei
	YANG Rongrong
	SONG Yonghui
	ZHANG Qiuli

Cite this article:

ZHOU Jingjing,ZHOU Jun,WU Lei, et al. Research Progress of Hydrogenated Pyrolysis of Low-rank Coal Assisted by Biomass Hydrogen-donor[J]. Materials Reports, 2022, 36(9): 20070237-8.

URL:

http://www.mater-rep.com/EN/10.11896/cldb.20070237 OR http://www.mater-rep.com/EN/Y2022/V36/I9/20070237

1 Ding X X, Li H J, Wang Y T. Clean Coal Technology, 2019, 25(5), 1(in Chinese).
丁肖肖, 李洪娟, 王亚涛.洁净煤技术, 2019, 25(5), 1.
2 Xia W C, Xie G Y, Peng Y L. Powder Technology, 2015, 277, 206.
3 Wu Z Q, Li Y W, Xu D H, et al. Fuel, 2019, 236, 43.
4 Zhu Y N, Wen W, Li Y M, et al. Journal of the Energy Institute, 2020, 93(1), 405.
5 Liu S Q, Tuo K Y, Wang L P, et al. Journal of the Energy Institute, 2020, 93(4), 1602.
6 Wang J F, Ma M, Bai Y H, et al. Fuel, 2020, 265, 116911.
7 Hassan H, Lim J K, Hameed B H. Bioresource Technology, 2016, 221, 645.
8 Liu W J, Li W W, Jiang H, et al. Chemical Reviews, 2017, 117, 6367.
9 Bhoi P R, Ouedraogo A S, Soloiu V, et al. Renewable and Sustainable Energy Reviews, 2020, 121, 109676.
10 Chen X Y, Liu L, Zhang L Y, et al. Energy & Fuels, 2019, 33, 1267.
11 Cao L C, Zhang C, Chen H H, et al. Bioresource Technology, 2017, 245, 1184.
12 Xie G H, Fang Y R, Li S B, et al. Journal of China Agricultural University, 2019, 24(8), 1(in Chinese).
谢光辉, 方艳茹, 李嵩博, 等.中国农业大学学报, 2019,24(8), 1.
13 Dai G X. Fundamental research on biomass fast pyrolysis and selective conversion. Ph.D. Thesis, Zhejiang University,China, 2020(in Chinese).
戴贡鑫. 生物质热解机理及选择性调控研究. 博士学位论文, 浙江大学, 2020.
14 Li G X. A Study on the pyrolysis mechanism of lignocellulosic biomass. Ph.D. Thesis, Zhejiang University, China, 2020(in Chinese).
李国翔. 木质纤维素类生物质热裂解机理研究. 博士学位论文, 浙江大学, 2020.
15 Li Y L, Huang S, Wang Q, et al. Fuel Processing Technology, 2019, 192, 13.
16 Niu Q. Experimental and mechanism study on pyrolysis of typical algae biomass. Master's Thesis, Tijin University, China, 2018(in Chinese).
牛琦. 典型藻类生物质热解实验与机理研究. 硕士学位论文, 天津大学, 2018.
17 Wu Z Q, Yang W C, Li Y W, et al. Bioresource Technology, 2018, 255, 238.
18 Wu Z Q, Yang W C, Li Y W, et al. Bioresource Technology, 2018, 268, 672.
19 Cheng X H. Low temperature co-pyrolysis of brown coal and ulva. Master's Thesis, Wuhan University of Science and Technology, China, 2015(in Chinese).
程晓晗. 石莼与褐煤低温共热解的转化研究. 硕士学位论文,武汉科技大学, 2015.
20 Wu J G, Meng A H, Zhang Z D, et al. Journal of Jilin Agricultural University, 2011, 33(3), 237(in Chinese).
吴景贵, 孟安华, 张振都, 等.吉林农业大学学报, 2011, 33(3), 237.
21 Liu W R, Zeng D, She L, et al. Science of the Total Environment, 2020, 734, 139023.
22 Zhou S M, Han L J, Huang G Q, et al. Journal of Analytical and Applied Pyrolysis, 2018, 134, 343.
23 Xu Y G, Qi F J, Bai T X, et al. Journal of Hazardous Materials, 2019, 380,120870.
24 Ma M, Bai Y H, Song X D, et al. Science of the Total Environment, 2020, 728, 138828.
25 Atienza-Martínez M, Ábrego J, Gea G, et al. Journal of Analytical and Applied Pyrolysis, 2020, 145, 104724.
26 Song Q, Zhao H Y, Jia J W, et al. Journal of Cleaner Production, 2020, 258, 120682.
27 Tokmurzin D, Kuspangaliyeva B, Aimbetov B, et al. Energy, 2020, 191, 116562.
28 Seo M W, Kim D S, Lee S H, et al. Journal of Analytical and Applied Pyrolysis, 2010, 88, 160.
29 Liu B, Li S Q, Liao H Q, et al. Fuel & Chemical Processes, 2011, 42(6),1(in Chinese).
刘波, 李世青, 廖洪强, 等.燃料与化工, 2011, 42(6), 1.
30 Meng H Y, Wang S Z, Chen L, et al. Bioresource Technology, 2016, 209, 273.
31 Ulloa C A, Gordon A L, García X A. Fuel Processing Technology, 2009, 90 (4), 583.
32 Park D K, Kim S D, Lee S H, et al. Bioresource Technology, 2010, 101(15), 6151.
33 Abdelsayed V, Ellison C R, Trubetskaya A, et al. Energy Fuels, 2019, 33, 7069.
34 An Y, Tahmasebi A, Yu J L. Journal of Analytical and Applied Pyrolysis, 2017, 128, 75.
35 Zhu J L,Jin L J, Luo Y W, et al. Energy Conversion and Management, 2020, 205, 112442.
36 Sonobe T, Worasuwannarak N, Pipatmanomai S. Fuel Processing Technology, 2008, 89 (12), 1371.
37 Wang Z H, Wan K D, Xia J, et al. Energy & Fuels, 2015, 29(8), 5036.
38 Lin B W, Zhou J S, Qin Q W, et al. Journal of Analytical and Applied Pyrolysis, 2019, 144, 104718.
39 Rajasekhar R B, Vinu R. Fuel Processing Technology, 2018, 178, 41.
40 Chen C X, Ma X Q, He Y. Bioresource Technology, 2012, 117, 264.
41 Wu Z Q, Yang W C, Yang B L. Bioresource Technology, 2018, 249, 501.
42 He X M, Pan Y, Chen K, et al. Coal Conversion, 2012, 35(4), 11(in Chinese).
何选明, 潘叶, 陈康, 等.煤炭转化, 2012, 35(4),11.
43 Jeong Y W, Choi S K, Choi Y S, et al. Renewable Energy, 2015, 79, 14.
44 Zhou Y C, Chen Z Z, Gong H J, et al. Waste Management, 2020, 107, 74.
45 Zhang M M, Song Q, Song L H, et al. Environmental Engineering, 2018, 36(4),137(in Chinese).
张蒙蒙, 宋强, 宋丽华, 等.环境工程, 2018, 36(4),137.
46 Liu C. TG-FTIR analysis of co-pyrolysis characteristics of refuse derived fuel and lignite. Master's Thesis, Changsha University of Science & Technology, China, 2017(in Chinese).
刘成. TG-FTIR研究垃圾衍生燃料与褐煤共热解特性. 硕士学位论文,长沙理工大学, 2017.
47 Ran H, Ma Y T. Low Carbon World, 2019(7), 91(in Chinese).
冉昊, 马禹婷.低碳技术, 2019(7), 91.
48 Zhang H Y, Ma Y N, Shao S S, et al. Applied Energy, 2017, 208, 867.
49 Qian Y P, Li W F, Chen X L, et al. Journal of East China University of Science and Technology (Natural Science Edition), 2013, 39(1),35(in Chinese).
钱亚平, 李伟锋, 陈雪莉, 等. 华东理工大学学报(自然科学版), 2013, 39(1),35.
50 Tang C Y. Mechanism research on the influence on yield and quality of tar derived from co-pyrolysis of biomass and coal. Ph.D. Thesis, East China University of Science and Technology, China, 2017(in Chinese).
唐初阳. 影响生物质和煤共热解油产率和品质的机理研究. 博士学位论文, 华东理工大学, 2017.
51 Li C Z. Fuel, 2013, 112, 609.
52 Kirtania K, Bhattacharya S. Biomass and Bioenergy, 2013, 55, 291.
53 Idris S S, Abd Rahman N, Ismail K, et al. Bioresource Technology, 2010, 101(12), 4584.
54 Pei X F. Clean Coal Technology, 2016, 22(3), 40(in Chinese).
裴贤丰.洁净煤技术, 2016, 22(3), 40.
55 Zhou J, Wu L, Liang K, et al. Materials Reports A: Review Papers, 2019, 33(1), 191(in Chinese).
周军, 吴雷, 梁坤, 等. 材料导报:综述篇, 2019, 33(1), 191.
56 Huang Y F, Chiueh P T, Lo S L. Sustainable Environment Research, 2016, 26,103.
57 Mamaeva A, Tahmasebi A, Tian L, et al. Bioresource Technology, 2016, 211, 382.
58 Zhang Y N, Fan L L, Liu S Y, et al. Bioresource Technology, 2018, 259, 461.
59 Sui C P, Wang L, Huang H F. Journal of University of Chinese Academy of Sciences, 2016, 33(3), 398(in Chinese).
隋春平, 王雷, 黄洪风.中国科学院大学学报, 2016, 33(3), 398.
60 Wang N, Hou X J. Food Research and Development, 2019, 40(4), 209(in Chinese).
王楠, 侯旭杰. 食品研究与开发, 2019, 40(4), 209.
61 Zhu J L, Jin L J, Li J G, et al. Bioresource Technology, 2019, 290, 121739.
62 Li J Q, Zhu J L, Hu H Q, et al. Fuel, 2020, 272, 117739.