Materials Reports 2021, Vol. 35 Issue (z2): 183-187 |
INORGANIC MATERIALS AND CERAMIC MATRIX COMPOSITES |
|
|
|
|
|
Influence of Ultra-low Temperature and Low Temperature Cycles on Performance of Concrete Materials |
LI Kaiwen1, LIU Juanhong1,2, ZHANG Chao3, DUAN Pinjia3, ZHANG Bochao3
|
1 College of Civil and Resource Engineering, University of Science and Technology Beijing, Beijing 100083, China 2 Beijing Key Laboratory of Urban Underground Space Engineering, University of Science and Technology Beijing, Beijing 100083, China 3 China National Offshore Petroleum Gas and Electricity Group Co., Ltd., Beijing 100028, China |
|
|
Abstract The mechanical performance of prestressed concrete (LHC) as a material for liquefied natural gas (LNG) storage tanks is significantly degraded in the ultra-low temperature (-165 ℃) environment. The perdormance of low-temperature concrete was studied and evaluated in this paper, and the pore structure characteristics and mechanical properties of LHC after low-emperature cycles are analyzed. The results showed that the number of pores at 105 nm—104 nm in LHC matrix is relatively small, and the volume of pores, pores and total porosity in LHC are lower than those in C60 concrete. After cryogenic cycling, the LHC matrix and the internal structure of C60 concrete were damaged to a certain extent, and all the mechanical parameters showed a downward trend. Compared with C60 concrete, LHC has excellent mechanical performance at ultra-low temperature environment.
|
Published: 09 December 2021
|
|
Fund:This work was financially supported by the Fundamental Research Expenses for Central Universities Engineering Materials for Deep Earth Rock Mass and Safety in Service (FRF-BD-20-01B). |
About author:: Kaiwen Li is a postgraduate student in the School of Civil and Resource Engineering, University of Science and Technology Beijing. Her current main research is ecological environmental protection high performance structural materials for civil engineering field. Juanhong Liu is currently a professor in University of Science and Technology Beijing. Her research interests are as follows: high-performance civil engineering structural materials; new concrete materials and their life analysis; the research and application of mine filling materials. |
|
|
1 Kim S, Kim M, Yoon H, et al.Cryogenics, 2018, 93, 75. 2 Kognara R B, Iyengar S R,Grasley Z C, et al. Construction and Building Materials, 2013, 47, 760. 3 Lee G C, Shih T S, Chang K C. Journal of Cold Regions Engineering, 1988, 2(4), 169. 4 Dahmani L.Strength of Materials, 2011, 43(5), 526. 5 We H D, Zhou M Z, Zhang Y C, et al.Engineers, 2010, 18, 22. 6 Krstulovic O N.Materials Journal, 2007, 104(3), 297. 7 杨海涛,段品佳,吴瑞东,等. 材料导报:研究篇, 2020, 34(16), 16043. 8 Masad N, Zollinger D, Kim S M, et al.Materials and Structures, 2016, 49(6), 2141. 9 魏强,谢剑,吴洪海. 工程力学, 2013, 30(S1), 125. 10 程宝军,王军,杨文,等. 混凝土, 2014(1), 101. 11 中华人民共和国建设部. 普通混凝土拌合物性能试验方法标准, 中国建筑工业出版社, 2003. 12 王术飞. 公路工程, 2019, 44(4), 279. 13 Corr D J, Lebourgeois J, Monteiro J M, et al.Cement and Concrete Research, 2002, 32(7), 1025. 14 Deboodt T, Wildenschhild D, Ideker J H, et al.Cement and Concrete Research, 2019, 116, 102. 15 Monteirop J, Rashed A, Bastacky J, et al. Cement and Concrete Research, 1989, 19 (2), 306. 16 Kim M J, Yoo D Y, Kim S, et al.Cement and Concrete Research, 2018, 107, 30. 17 谢剑,崔宁,姜晓峰. 硅酸盐通报, 2018, 37(8), 2367. 18 Cui Y H, Chen Y, Peng G.Construction and Building Materials, 2019, 211, 284. 19 Sanchez X R, Nonoa G, Vera G D, et al.Cement and Concrete Research, 2008, 38 (7), 1015. 20 Zhang M H, Islam J.Construction and Building Materials, 2012, 29, 573. 21 Liu J, Qu G F, Qiu Q, et al.Construction and Building Materials, 2017, 146, 493. 22 Selvaraj R, Muralidharan S, Srinivasan S.Struct Concrete, 2003, 4(1), 19. 23 Khalil K A.Materials Letters, 1996, 26(4), 259. 24 Xu Y, Chung D L.Cement and Concrete Research, 2000, 30(8), 1305. 25 Van B K.Cryogenics, 1982, 22(7), 331. |
|
|
|