| NEW MATERIAL AND TECHNOLOGY |
|
|
|
|
|
| Progress in Gas Adsorption and Separation Application of Metal-Organic Framework Materials |
| ZHOU Lingling, TANG Lihong, NING Ping, LI Kai, BAO Shuangyou, ZHU Tingting, JIN Xu, ZHANG Xiuying
|
| Faculty of Environmental Science and Engineering, Kunming University of Science and Technology, Kunming 650500 |
|
|
|
|
Abstract The metal-organic framework materials have become one of the hot spots in the fields of chemistry and materials because of its good performances, such as high specific surface areas,large porosity, diversified and adjustable pore structure and relatively mild preparation conditions. This paper summarizes the preparation methods of MOFs and its application in the adsorption and separation of gases (carbon, nitrogen and sulfur). Finally, the development trend and application prospects of metal-organic frameworks are discussed.
|
|
Published: 10 October 2017
Online: 2018-05-07
|
|
|
|
|
1 Samimi A, Zarinabadi S. Reduction of greenhouse gases emission and effect on environment[J]. Australian J Basic Appl Sci,2012, 8(12):1011.
2 Zambrano M. Energy efficiency and greenhouse effect gas reduction[C]//SPE Latin American and Caribbean Petroleum Engineering Conference. Lima,2015.
3 Wang W, Wang T. On acid rain formation in China[J]. Atmosphe-ric Environment,1996,30(23):4091.
4 Wenxing W. Study on the origin of acid rain formation in China[J]. China Environ Sci,1994,14(5):323.
5 Khan F I, Ghoshal A K. Removal of volatile organic compounds from polluted air[J]. J Loss Prevention in the Process Industries,2000, 13(6):527.
6 Dunn R F, El-Halwagi M M. Optimal design of multicomponent VOC condensation systems[J]. J Hazard Mater,1994,38(1):187.
7 Rand B. Vapor degreasing with solvent distillation and condensation recovery: US,3375177[P]. 1968-03-26.
8 Dunn R F, El-Halwagi M M. Selection of optimal VOC-condensation systems[J]. Waste Management,1994,14(2):103.
9 Zhao T, Sha F, Xiao J, et al. Absorption, desorption and spectroscopic investigation of sulfur dioxide in the binary system ethylene glycol + dimethyl sulfoxide[J]. Fluid Phase Equilibria,2015,405:7.
10 Cui G, Zhang F, Zhou X, et al. Acylamido-based anion-functiona-lized ionic liquids for efficient SO2 capture through multiple-site inte-ractions[J]. ACS Sustainable Chem Eng,2015,3(9):2264.
11 Mondal A, Balasubramanian S. Understanding SO2 capture by ionic liquids[J]. J Phys Chem B,2016,120(19):4457.
12 Li X, Liu X, Jiang Y, et al. Solubilities and thermodynamic properties of carbon dioxide in some biobased solvents[J].J Chen Eng Data,2016,61(9): 3355.
13 Heymes F, Manno-Demoustier P, Charbit F, et al. A new efficient absorption liquid to treat exhaust air loaded with toluene[J].Chem Eng J,2006,115(3):225.
14 Carlowitz O, Ruskamp B, Neese O, et al. Method for the treatment of exhaust gases containing organosilicon components or accompanying substances, and apparatus therefor: US, US8105562[P].2012.
15 Popp D. International innovation and diffusion of air pollution control technologies: The effects of NOx and SO2 regulation in the US,Japan, and Germany[J]. J Environ Econom Manage,2006,51(1):46.
16 Bereketidou O A, Charisiou N D, Goula M A. Simultaneous removal of NOx and SO2 from combustion flue gases using supported copper oxide catalysts[J]. Globalnest Int J,2012,14(2):166.
17 De Nevers N. Air pollution control engineering[M]. United States: Waveland Press,2010.
18 Kotoh K. Hydrogen isotope separation by gas adsorption processes[J]. Purazuma, Kaku Yugo Gakkai-Shi,2016,92(1):15.
19 Ilavsky＇ J, Barloková D, Munka K. Antimony removal from water by adsorption to iron-based sorption materials[J]. Water Air Soil Pollut,2015,226(1):2238.
20 Clarkson C R, Solano N, Bustin R M, et al. Pore structure characterization of North American shale gas reservoirs using USANS/SANS, gas adsorption, and mercury intrusion[J]. Fuel,2013,103:606.
21 Baur G B, Yuranov I, Renken A, et al. Activated carbon fibers for efficient VOC removal from diluted streams: The role of surface morphology[J]. Adsorption,2015,21(6):479.
22 Wei X U, Liu J, Sun K. Application progresses in the treatment of volatile organic compounds by adsorption on activated carbon[J]. Chem Ind Eng Progress,2016,35(4):1223.
23 Tong X, Liu Z, Chen X Q, et al. Analysis and pollution sources speculations of toxic gases in a secondary fiber paper mill[J]. J Environ Sci Health A Tox Hazard Subst Environ Eng,2016,15(13):1.
24 Meng X, Huang H, Shi L. Reactive mechanism and regeneration performance of NiZnO/Al2O3-diatomite adsorbent by reactiveadsorption desulfurization[J]. Ind Eng Chem Res,2013,52(18):6092.
25 Knoblauch K, Richter E, Jüntgen H. Application of active coke in processes of SO2-and NOx-removal from flue gases[J]. Fuel, 1981,60(9):832.
26 Sethupathi S, Bashir M J K, Akbar Z A, et al. Biomass-based palm shell activated carbon and palm shell carbon molecular sieve as gas separation adsorbents[J]. Waste Manage Res J Int Solid Wastes Public Cleansing Association Iswa,2015,33(4):303.
27 Gordon B R, Kelsey S F, Dau P C, et al. Long-term effects of low-density lipoprotein apheresis using an automated dextran sulfatecellulose adsorption system[J]. Am J Cardiol,1998,81(4):407.
28 Kitis M, Karanfil T, Wigton A, et al. Probing reactivity of dissolved organic matter for disinfection by-product formation using-XAD-8 resin adsorption and ultrafiltration fractionation[J]. Water Res,2002,36(15):3834.
29 Otten W, Gail E, Frey T. Uses of hydrophobic zeolites in adsorption technology. properties, process optimization, and application[J]. Chem Inform,2015,24(7):133.
30 Zhao Z, Cui X, Ma J, et al. Adsorption of carbon dioxide on alkali-modified zeolite 13X adsorbents[J]. Int J Greenhouse Gas Control, 2007,1(3):355.
31 Li J R, Sculley J, Zhou H C. Metal-organic frameworks for separations[J]. Chem Rev,2012,112(2):869.
32 Rowsell J L C, Spencer E C, Eckert J, et al. Gas adsorption sites in a large-pore metal-organic framework[J]. Science,2005,309(5739): 1350.
33 Nandasiri M I, Jambovane S R, Mcgrail B P, et al. Adsorption, separation, and catalytic properties of densified metal-organic frameworks[J]. Coordination Chem Rev,2016,311:38.
34 Li J R, Ma Y, McCarthy M C, et al. Carbon dioxide capture-related gas adsorption and separation in metal-organic frameworks[J]. Coordination Chem Rev,2011,255(15):1791.
35 Couck S, Denayer J F M, Baron G V, et al. An amine-functionalized MIL-53 metal-organic framework with large separation power for CO2 and CH4[J]. J Am Chem Soc,2009,131(18):6326.
36 Watanabe T, Sholl D S. Accelerating applications of metal-organic frameworks for gas adsorption and separation by computational screening of materials[J]. Langmuir,2012,28(40):14114.
37 Sun W, Lin L C, Peng X, et al. Computational screening of porous metal-organic frameworks and zeolites for the removal of SO2 and NOx from flue gases[J]. AIChE J,2014,60(6):2314.
38 Kitagawa S. Metal-organic frameworks (MOFs)[J]. Chem Soc Rev,2014,43(16):5415.
39 Yu J, Xie L H, Li J R, et al. CO2 capture and separations using MOFs: computational and experimental studies[J]. Chem Rev, DOI:10.1021/acs.chemrev.6b00626.
40 Bastin L, Bárcia P S, Hurtado E J, et al. A microporous metal-organic framework for separation of CO2/N2 and CO2/CH4 by fixed-bed adsorption[J]. J Phys Chem C,2008,112(5):1575.
41 Ramsahye N A, Gao J, Jobic H, et al. Adsorption and diffusion of light hydrocatbons in UiO-66(Zr): A combination of experimental and modeling tools[J].J Phys Chem C,2014,118(47):27470.
42 Sumida K, Rogow D L, Mason J A, et al. Carbon dioxide capture in metal-organic frameworks[J]. Chem Rev,2011,112(2):724.
43 Choi S, Watanabe T, Bae T H, et al. Modification of the Mg/DOBDC MOF with amines to enhance CO2 adsorption from ultradilute gases[J]. J Phys Chem Lett,2012,3(9):1136.
44 Salles F, Ghoufi A, Maurin G, et al. Molecular dynamics simulations of breathing MOFs: Structural transformations of MIL-53(Cr) upon thermal activation and CO2 adsorption[J]. Angewandte Chem,2008,120(44):8615.
45 Valenzano L, Civalleri B, Chavan S, et al. Computational and experimental studies on the adsorption of CO, N2, and CO2 on Mg-MOF-74[J]. J Phys Chem C,2010,114(25):11185.
46 Torrisi A, Bell R G, Mellot-Draznieks C. Functionalized MOFs for enhanced CO2 capture[J]. Cryst Growth Des,2010,10(7): 2839.
47 Hamon L, Llewellyn P L, Devic T, et al. Co-adsorption and separation of CO2-CH4 mixtures in the highly flexible MIL-53(Cr) MOF[J]. J Am Chem Soc,2009,131(47):17490.
48 Keskin S, Sholl D S. Assessment of a metal-organic framework membrane for gas separations using atomically detailed calculations: CO2, CH4, N2, H2 mixtures in MOF-5[J]. Ind Eng Chem Res,2008,48(2):914.
49 Alezi D, Belmabkhout Y, Suyetin M, et al. MOF crystal chemistry paving the way to gas storage needs: Aluminum-based soc-MOF for CH4, O2, and CO2 storage[J]. J Am Chem Soc,2015,137(41):13308.
50 Spanopoulos I, Tsangarakis C, Klontzas E, et al. Reticular synthesis of HKUST-like tbo-MOFs with enhanced CH4 storage[J]. J Am Chem Soc,2016,138(5):1568.
51 D′Alessandro D M, Smit B, Long J R. Carbon dioxide capture: Prospects for new materials[J]. Angewandte Chem Int Ed,2010,49(35):6058.
52 Zhang S Y, Liu H, Liu P F, et al.Progress of adsorption-based CO2/CH4 separation by metal organic frameworks[J]. CIESC J,2014, 65(5):1563(in Chinese).
张所瀛, 刘红, 刘朋飞, 等. 金属有机骨架材料在CO2/CH4吸附分离中的研究进展[J].化工学报,2014,65(5):1563.
53 Asadi T, Ehsani M R, Ribeiro A M, et al. CO2/CH4 separation by adsorption using nanoporous metal organic framework Copper-Benzene-1, 3, 5-tricarboxylate tablet[J]. Chem Eng Technol,2013,36(7):1231.
54 Alduhaish O, Wang H, Li B, et al. A threefold interpenetrated pillared-layer metal-organic framework for selective separation of C2H2/CH4 and CO2/CH4[J]. Chem Plus Chem,2016,81(8):764.
55 Liu Y Y, Huang Y, He J J, et al. Adsorption isotherms and selectivity of CO/N2/CO2 on MOF-74(Ni) [J]. CIESC J, 2015, 66(11):4469(in Chinese).
刘有毅, 黄艳, 何嘉杰, 等. CO/N2/CO2在MOF-74 (Ni) 上吸附相平衡和选择性[J].化工学报, 2015, 66(11):4469.
56 Lindinger W, Hansel A, Jordan A. On-line monitoring of volatile organic compounds at pptv levels by means of proton-transfer-reaction mass spectrometry (PTR-MS) medical applications, food control and environmental research[J]. Int J Mass Spectrometry Ion Processes,1998,173(3):191.
57 Bellat J P, Bezverkhyy I, Weber G, et al. Capture of formaldehyde by adsorption on nanoporous materials[J]. J Hazard Mater,2015,300:711.
58 Li W, Wu X, Han N, et al. Core-shell Au@ ZnO nanoparticles derived from Au@ MOF and their sub-ppm level acetone gas-sensing performance[J]. Powder Technol,2016,304:241.
59 Homayoonnia S, Zeinali S. Design and fabrication of capacitive nanosensor based on MOF nanoparticles as sensing layer for VOCs detection[J]. Sensors Actuators B: Chem,2016,237:776.
60 Britt D, Tranchemontagne D, Yaghi O M. Metal-organic frameworks with high capacity and selectivity for harmful gases[J]. PNAS,2008,105(33):11623.
61 Yang K, Sun Q, Xue F, et al. Adsorption of volatile organic compounds by metal-organic frameworks MIL-101: Influence of molecular size and shape[J]. J Hazard Mater,2011,195:124.
62 Yang K, Xue F, Sun Q, et al. Adsorption of volatile organic compounds by metal-organic frameworks MOF-177[J]. J Environ Chem Eng,2013,1(4):713.
63 Saha D, Bao Z, Jia F, et al. Adsorption of CO2, CH4, N2O, and N2 on MOF-5, MOF-177, and zeolite 5A[J]. Environ Sci Technol,2010, 44(5):1820.
64 Tan K, Zuluaga S, Gong Q, et al. Competitive coadsorption of CO2 with H2O, NH3, SO2, NO, NO2, N2, O2, and CH4 in M-MOF-74(M= Mg, Co, Ni): The role of hydrogen bonding[J]. Chem Mater,2015,27(6):2203.
65 Chen Y, Yang C, Wang X, et al. Kinetically controlled ammonia vapor diffusion synthesis of a Zn(Ⅱ) MOF and its H2O/NH3 adsorption properties[J]. J Mater Chem A,2016,4(26):10345.
66 Borfecchia E, Maurelli S, Gianolio D, et al. Insights into adsorption of NH3 on HKUST-1 metal-organic framework: A multitechnique approach[J]. J Phys Chem C,2012,116(37):19839.
67 Maes M, Trekels M, Boulhout M, et al. Selective removal of N-he-terocyclic aromatic contaminants from fuels by lewis acidicmetal-organic frameworks[J]. Angewandte Chem,2011,123(18):4296.
68 Wang C Y, Li G, Sun Z G. Denitrogenation through adsorption to sulfonated metal-organic frameworks[J]. Acta Physico-Chimica Sinica,2013,29(11):2422(in Chinese).
王朝阳, 李钢, 孙志国. 磺酸功能化金属-有机骨架吸附脱氮性能[J].物理化学学报,2013,29(11):2422.
69 Li Z, Liao F, Jiang F, et al. Capture of H2S and SO2 from trace sulfur containing gas mixture by functionalized UiO-66(Zr) materials: A molecular simulation study[J]. Fluid Phase Equilibria,2016,427:259.
70 Ma L L. Molecular simulation study of gas mixtures separation in metal-organic frameworks[D]. Beijing: Beijing University of Chemical Technology,2011(in Chinese).
马琳琳. 金属-有机骨架材料中气体混合物吸附分离行为的分子模拟研究[D]. 北京:北京化工大学,2011.
71 Hamon L, Serre C, Devic T, et al. Comparative study of hydrogen sulfide adsorption in the MIL-53 (Al, Cr, Fe), MIL-47 (V),MIL-100 (Cr), and MIL-101(Cr) metal-organic frameworks at room temperature[J]. J Am Chem Soc,2009,131(25):8775.
72 Petit C, Mendoza B, Bandosz T J, et al. Hydrogen sulfide adsorption on MOFs and MOF/graphite oxide composites[J]. Chem Phys Chem,2010,11(17):3678.
73 Khan N A, Jhung S H. Scandium-triflate/metal-organic frameworks: Remarkable adsorbents for desulfurization and denitrogenation[J]. Inorg Chem,2015,54(23):11498.
74 Gong R, Zhou L M, Ma N, et al.Adsorptive performance of benzothiophene using metal organic framework material MOF-5[J].J Fuel Chem Technol,2013,41(5):607(in Chinese).
巩睿, 周丽梅, 马娜, 等. 金属有机骨架材料MOF-5吸附苯并噻吩性能[J]. 燃料化学学报,2013,41(5):607.
75 Zhao X Q, Xin C L, Yin Y C, et al. Research on desulfurization effect of metal-organic framework compound MOF-14[J]. Petrochem Technol Appl,2012(5):393(in Chinese).
赵学勤, 辛春玲, 尹延超, 等. 金属有机骨架化合物MOF-14的脱硫效果研究[J]. 石化技术与应用,2012(5):393.
76 Ren J, Cao G W, Zhang Y. Adsorptive desulfurization of gasoline with Cu(I) based metal-organic framework[J]. J Petrochem Universities,2015,28(3):41(in Chinese).
任靖, 曹光伟, 张勇. Cu(I)金属有机骨架材料在汽油吸附脱硫中的应用[J]. 石油化工高等学校学报,2015,28(3):41.
77 Greathouse J A, Allendorf M D. The interaction of water with MOF-5 simulated by molecular dynamics[J]. J Am Chem Soc,2006, 128(33):10678.
78 Iremonger S S, Liang J, Vaidhyanathan R, et al. Phosphonate monoesters as carboxylate-like linkers for metal organic frameworks[J]. J Am Chem Soc,2011,133(50):20048.
79 Yang J, Grzech A, Mulder F M, et al. Methyl modified MOF-5: A water stable hydrogen storage material[J]. Chem Commun,2011, 47(18):5244.
80 Gelfand B S, Lin J B, Shimizu G K. Design of a humidity-stable metal-organic framework using a phosphonate monoester ligand[J]. Inorg Chem,2015,54(4):1185.
81 Low J J, Benin A I, Jakubczak P, et al. Virtual high throughput screening confirmed experimentally: Porous coordination polymer hydration[J]. J Am Chem Soc,2009,131(131):15834.
82 Tranchemontagne D J, Hunt J R, Yaghi O M. Room temperature synthesis of metal-organic frameworks: MOF-5, MOF-74, MOF-177, MOF-199, and IRMOF-0[J]. Tetrahedron,2008,64(36):8553.
83 Yuan W, Garay A L, Pichon A, et al. Study of the mechanochemical formation and resulting properties of an archetypal MOF: Cu3-(BTC)2(BTC=1, 3, 5-benzenetricarboxylate)[J]. CrystEngComm,2010,12(12):4063.
84 Fricˇic′ T, Fábián L. Mechanochemical conversion of a metal oxide into coordination polymers and porous frameworks using liquid-assisted grinding (LAG)[J]. CrystEngComm,2009,11(5):743. |
|
|
|
渝公网安备50019002502923号 © Editorial Office of Materials Reports.
2017, Vol. 31 
