RESEARCH PAPER |
|
|
|
|
|
Experimental Study on the Friction of Isotropic Magnetorheological Elastomer Materials |
LI Rui, REN Dejun, CHEN Xiang, WANG Xiaojie
|
Department of Automation, Chongqing University of Posts and Telecommunications, Chongqing 400065; |
|
|
Abstract The influence of magnetic field on tribological behavior of isotropic magnetorheological elastomer (MRE) was investigated from both macroscopic and microscopic view. Friction test-bed of MRE was built, and sliding friction experiment was carried out under an external magnetic field. The experimental results showed that the friction coefficient of MRE decreased with the increase of normal pressure under conditions of light load and low speed. The friction coefficient of MRE surface decreased under magnetic field, and the decreasing trend presented a nonlinear change with the increase of volume fraction of carbonyl iron. The maximum reduction of friction coefficient was about 25% when the volume fraction of carbonyl iron was 10%, the normal pressure was 0.25 N and the magnetic field was 250 mT. Then the surface of MRE under magnetic field and nonmagnetic field were further observed by metallographic microscope. The test showed that the magnetic field caused the aggregation of carbonyl iron on the surface of MRE, which changed the material properties and microstructure of the surface, and it was an important reason for the change of tribological behavior of MRE.
|
Published: 02 May 2018
|
|
|
|
1 Li Bing, Yang Shengdong, Qu Bo, et al. Research and development of automobile friction material [J]. Mater Rev,2012,26(S1):348(in Chinese). 李兵,杨圣岽,曲波,等.汽车摩擦材料现状与发展趋势[J].材料导报,2012,26(专辑19):348. 2 He Ren, Tang Bao, Zhao Qiang. Switching control strategy of integrated electromagnetic and friction brake system [J]. J Jiangsu University: Nat Sci Ed,2015,36(2):125(in Chinese). 何仁,汤宝,赵强.电磁与摩擦制动集成系统切换控制策略[J].江苏大学学报:自然科学版,2015,36(2):125. 3 Xu Xiang, Yang Ming. Research situation of the organic brake friction materials [J]. Mater Rev:Rev,2015,29(11):81(in Chinese). 徐祥,杨明.有机复合摩擦材料及其研究现状[J].材料导报:综述篇,2015,29(11):81. 4 Zhang Yuanshen, Mi Xiaoming, Yu Youling, et al. Structural improvements for reducing friction in pneumatic cylinder [J]. J Lanzhou University of Technology,2014,40(2):55(in Chinese). 张远深,米晓明,於又玲,等.降低气缸摩擦力的结构改进[J].兰州理工大学学报,2014,40(2):55. 5 Bi Lianying. Integrated approach to change the rubber friction pro-perties [J]. World Rubber Ind,2001,28(1):36(in Chinese). 毕莲英.改变橡胶摩擦性能的综合方法[J].世界橡胶工业,2001,28(1):36. 6 Xiao Qian, Lin Fengtao, Wang Chengguo, et al. Analysis on wheel-rail rolling contact characteristics with variable friction coefficient [J]. J China Railway Soc,2012,34(6):24(in Chinese). 肖乾,林凤涛,王成国,等.变摩擦系数条件下的轮轨滚动接触特性分析[J].铁道学报,2012,34(6):24. 7 Wang Jianxiao, Meng Guang. Research advances in magnetorheological elastomers[J]. J Funct Mater,2006,37(5):706(in Chinese). 汪建晓,孟光.磁流变磁流变橡胶研究进展[J].功能材料,2006,37(5):706. 8 Li Rui, Chen Weimin, Liao Changrong, et al. Engine isolation control via magnetorheological technology[J]. Chinese J Mechan Eng,2009,45(3):183(in Chinese). 李锐,陈伟民,廖昌荣,等.基于磁流变技术的发动机隔振控制[J].机械工程学报,2009,45(3):183. 9 Xu Yangguang, Gong Xinglong, Wan Qiang, et al. Magneto-sensitive smart soft material and magnetorheological mechanism [J]. Adv Mech,2015,45(1):461(in Chinese). 许阳光,龚兴龙,万强,等.磁敏智能软材料及磁流变机理[J].力学进展,2015,45(1):461. 10 Sohn J W, Choi S B, Lee C H, et al. Wear characteristics of magnetorheological fluid under boundary lubrication [J]. Adv Mater Res,2009,79-82:83 . 11 Lee C H, Lee D W, Choi J Y, et al. Tribological characteristics modification of magnetorheological fluid [J]. J Tribology,2011,133(3):031801. 12 Wong P L, Bullough W A, Feng C Q,et al. Tribological effect of a MRF on steel/steel conjunction under boundary lubrication conditions[C]//7th Int. Conf. Tribology, South African Inst. Tribology,2001:21. 13 Bullough W A, Wong P L, Feng C, et al. Fundamental boundary tribology: ESF[J]. J Intelligent Mater Systems Struct,2003,14(2):71. 14 Leung W C, Bollough W A, Wong P L, et al. The effect of particle concentration in a magneto-rheological suspension on the perfor-mance of a boundary lubricated contact[J].J Eng Tribol,2004,218:251. 15 Lee D W, Lee K, Lee C H, et al. A study on the tribological cha-racteristics of a magneto-rheological elastomer [J]. J Tribology,2013,135(1):014501. 16 Lee K H, Chenglong L, Lee C H, et al. Rolling friction behavior of magneto-rheological elastomer under a magnetic field [J]. J Ind Eng Chem,2014,15(6):773. 17 Lian C, Lee K H, Lee C H. Friction and wear characteristics of magneto-rheological elastomers based on silicone/polyurethane hybrid [J]. J Tribology,2015,137(3):031607. 18 卢秀首,乔秀颖,龚兴龙,等.各向同性和各向异性热塑性磁流变弹性体的制备与表征[C]//第十届全国流变学学术会议.杭州,2010. 19 Li Jianfeng, Gong Xinglong, Zhang Xianzhou, et al. Research on magnetorheological elastomer based on silicone rubber[J]. J Funct Mater,2006,37(6):1003(in Chinese). 李剑锋,龚兴龙,张先舟,等.硅橡胶基磁流变磁流变弹性体的研制[J].功能材料,2006,37(6):1003. 20 Pei Xudong, Guo Konghui, Ding Yuhua, et al. Friction of rubber and tire [J]. China Rubber Ind,2003,50(9):562(in Chinese). 彭旭东,郭孔辉,丁玉华,等.橡胶和轮胎的摩擦[J].橡胶工业,2003,50(9):562. 21 温诗铸,黄平.摩擦学原理[M].北京:清华大学出版社,2002.
|
|
|
|