粘贴纤维增强复合材料加固混凝土梁的蠕变特性研究进展

doi:10.11896/cldb.18100193

Abstract
Figure/Table
References
Related Citation (1)

Download:

Full Text ( PDF ) (21962KB)
Export: BibTeX | EndNote (RIS)

Abstract Due to the excellent performance of fiber-reinforced polymers (FRP) and ease of application, the techniques of strengthening concrete structures by externally bonding FRP had been widely applied in actual projects (e.g., structural modification, repairing, reinforcement and seismic retrofit), since the end of the last century. FRP presents low density, well corrosion-resistant and high strength. Recently, FRP has been more generally used since the material compensate is further declined. It should be noted that the service time of building structures is long. After strengthening, the strengthened structures still suffer sustained loads for long-period of time. However, so far, the long-term performance of strengthened structures under sustained load has not been fully explored. The practical strengthening designs do not consider the creep effects. To the actual fact that the strengthening techniques of bonding FRP externally have been already widely used, it is needed to further investigate the creep response of FRP-strengthened concrete structures.
Under sustained load, the long-term deformation of FRP-strengthened structure increases with time, along with complicated stress redistribution occurs in structure. These phenomena are basically caused by the creep behaviors of materials. Researches on the time-dependent properties of concrete had been carried out long before. Up to now, there is relatively adequate understan-ding for the shrinkage and uniaxial compressive creep of concrete, and some generally accepted models worldwide are recommended to theoretically describe such behavior. Researches show epoxy resin, which is used as adhesive to bond FRP on concrete exhibits evident creep performance. Higher environmental temperature and relative humidity increase the creep deformation of adhesive, which may even induce creep fracture. Experimental researches and numerical studies have demonstrated that the viscous flow of epoxy leads to obvious relaxation of interfacial stress. The CFRP and GFRP used for structural strengthening present ignorable creep performance, which has been validated by tests.
For the increasing of deformation of FRP-strengthened concrete structure under sustained load, the increasing rate is high in the earlier stage, but gradually reduces in the later stage, which is basically in consistent with the creep law of concrete and epoxy resin. Strengthening has evident effect on reducing the instantaneous deformation, whereas, its effect on reducing the long-term deformation is comparatively not pronounced. The believed reason is that the shear creep of adhesive relieves the stress in FRP, which degrades the strengthening effects and causes additional deformation. Based on cross section analysis, the long-term performance of FRP-strengthened concrete beams can be theoretically investigated, however, the shear creep of adhesive cannot be properly taken into account.
Reasonable discussion on the time-dependent behavior of FRP-strengthened structures fundamentally dependents on the adequate understan-ding of the creep response of materials. Thus, this paper first review the research progress on the creep behaviors of concrete, epoxy adhesive and FRP. It is noteworthy that in actual engineering projects, the sustained load for structure is service load. Under such level of load, the stress in steel is lower than the yield strength, which can be considered as linear elastic materials, hence the creep of steel can be reasonably neglected. Therefore, this paper no longer addresses the creep behavior of steel. Afterwards, the recent study progress on the time-dependent response of FRP-strengthened concrete beam is reviewed in the aspects of experimental study and theoretical analysis. The reviewed experimental studies cover the methods, phenomena and conclusions of long-term test. The reviewed theoretical analyses mainly include the methods for calculating the long-term deformation. Finally, the problems of existed studies are concluded, and the suggestions for further researches are presented.

Key words： fiber-reinforced polymers (FRP) paste reinforcement creep behavior long-term response

Published: 23 July 2019

CLC number:

TU375.1

Fund:This work was financially supported by the Key Projects for the Transformation of Outstanding Achievements in Colleges and Universities in Chongqing, China (KJZH14220); Scientific and Technological Key Projects of Chongqing Science and Technology Commission, China (CSTC2011AB0043).

About author:: Weilai Yao received his B.S. degree in civil enginee-ring from Chongqing University in 2013. Currently, he is a Ph.D. candidate at Department of Military Facility, Army Logistics University of PLA under the supervision of Prof. Shiyong Jiang. His research interest is long-term performance of FRP-strengthened concrete structures.
Shiyong Jiang received his Ph.D. degree from Tongji University in 1994. He is the judge of the National Science and Technology Progress Award and National Natural Science Foundation of China. He is the member of the American Society of Civil Engineers (ASCE) and the leader of academic and technical in Chongqing. He is the director of the Chongqing Science and Technology Youth Federation, and the executive director of the National Building Identification and Reinforcement Technical Committee. He is currently a full professor in Army Logistics University of PLA and School of Civil Engineering, Chongqing Jiaotong University. His research interests are structural detection, identification, reinforcement and cement-based composite materials, especially in the application of FRP in civil engineering. In recent years, by using prestressed reinforcement technology, the problem that the effect of reinforced concrete structures are not obvious using carbon fiber sheets has been solved. He has solved the problem that electromagnetic interference and corrosion of rebar exist in special military engineering structures by using FRP bars instead of steel rebar.

	Service
	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	YAO Weilai
	JIANG Shiyong
	CAI Tao
	GONG Hongwei
	TAO Shuai

Cite this article:

YAO Weilai,JIANG Shiyong,CAI Tao, et al. Research Progress on Creep Response of FRP-strengthened Reinforced Concrete Beams[J]. Materials Reports, 2019, 33(17): 2890-2901.

URL:

http://www.mater-rep.com/EN/10.11896/cldb.18100193 OR http://www.mater-rep.com/EN/Y2019/V33/I17/2890

1	Hu D. <i>Creep response of concrete structures</i>, Science Press, China, 2015 (in Chinese).<br />
	胡狄. 混凝土结构徐变效应理论, 科学出版社, 2015.<br />
2	Teng J G, Chen J F, Smith S T. <i>FRP strengthened RC structures, 2nd Edition</i>, John Wiley & Sons, UK, 2016.<br />
3	Aboubakr S H, Kandil U F, Taha M R. <i>International Journal of Adhesion & Adhesives</i>, 2014, 54(5), 1.<br />
4	Jeong Y, Lee J, Kim W S. <i>Materials</i>, 2015, 8(2), 435.<br />
5	Jeong Y, Lopez M M, Bakis C E. <i>Construction & Building Materials</i>, 2016, 124(4), 42.<br />
6	Costa I, Barros J. <i>International Journal of Adhesion & Adhesives</i>, 2015, 59(1), 15.<br />
7	Ferrier E, Michel L, Jurkiewiez B, et al. <i>Construction and Building Materials</i>, 2011, 25(2), 461.<br />
8	Neville A M, Dilger W H, Brooks J J. <i>Creep of plain and structural concrete</i>, Construction Press, United States, 1983.<br />
9	Huang G X, Hui R Y, Wang X J. <i>Creep and shrinkage of concrete</i>, China Electric Power Press, China, 2012 (in Chinese).<br />
	黄国兴, 惠荣炎, 王秀军. 混凝土徐变与收缩, 中国电力出版社, 2012.<br />
10	Gardner N J, Lockman M J. <i>ACI Materials Journal</i>, 2002, 98(2), 159.<br />
11	Ba ant Z P, Baweja S. <i>Materials & Structures</i>, 1995, 28(6), 357.<br />
12	CEB-FIP. <i>CEB-FIP model code 2010</i>, Ernst & Sohn Publishing House, Germany, 2013.<br />
13	ACI Committee 209. <i>Prediction of creep, shrinkage, and temperature effects in concrete structures</i>, American Concrete Institute, United States, 2002.<br />
14	Zhu B F. <i>Journal of Hydraulic Engineering</i>, 1985(9), 56 (in Chinese).<br />
	朱伯芳. 水利学报, 1985(9), 56.<br />
15	Goel R, Kumar R, Paul D K. <i>Journal of Materials in Civil Engineering</i>, 2007, 19(3), 249.<br />
16	Beeby A W, Scott R H. <i>Magzine of Concrete Research</i>, 2006, 58(5), 255.<br />
17	Ahmed, Abualwafa K T. Long term deflection of high-performance reinforced concrete beam. Ph.D. Thesis, University of Leeds, United Kingdom, 2013.<br />
18	Higgins L, Forth J P, Neville A, et al. <i>Engineering Structure</i>, 2013, 56(6), 457.<br />
19	Rossi P, Tailhan J L, Maou F L, et al. <i>Cement & Concrete Research</i>, 2012, 42(1), 61.<br />
20	Ranaivomanana N, Multon S, Turatsinze A. <i>Cement & Concrete Research</i>, 2013, 52(10), 1.<br />
21	Forth J P. <i>Cement & Concrete Composites</i>, 2015, 55, 70.<br />
22	Rossi P, Tailhan J L, Lemaou F. <i>Cement & Concrete Research</i>, 2013, 51, 78.<br />
23	Ranaivomanana N, Multon S, Turatsinze A. <i>Construction & Building Materials</i>, 2013, 38, 173.<br />
24	Chen B S, Chen S, Wang Y, et al.<i>Materials Review B: Research Papers</i>, 2017, 31(6), 149 (in Chinese).<br />
	陈邦尚, 陈松, 王岩, 等. 材料导报:研究篇, 2017, 31(6), 149.<br />
25	Reviron N, Nahas G, Tailhan J L, et al. In: Proceedings of the 8th International Conference on Creep, Shrinkage and Durability Mechanics of Concrete and Concrete Structures. Shima, Japan, 2009.<br />
26	Aili A, Vandamme M, Torrenti J M, et al. <i>Cement & Concrete Research</i>, 2016, 90, 144.<br />
27	Gopalakrishnan K S, Neville A M, Chali A. <i>ACI Journal & Proceedings</i>, 1969.<br />
28	Meyer I H. <i>Matériaux Et Construction</i>, 1969, 2(2), 125.<br />
29	Aili A, Vandamme M, Torrenti J M, et al. <i>Mechanics of Time-Dependent Materials</i>, 2015, 19(4), 537.<br />
30	Aili A, Vandamme M, Torrenti J M, et al. In: Proceedings of the 10th International Conference on Mechanics and Physics of Creep, Shrinkage, and Durability of Concrete and Concrete Structures. Massachusetts, 2015, pp. 1219.<br />
31	Charpin L, Sanahuja J. <i>International Journal of Solids & Structures</i>, 2017, 110, 2.<br />
32	Sellier A, Multon S, Buffo R L, et al. <i>Cement & Concrete Research</i>, 2016, 79(1), 301.<br />
33	Charpin L, Pape Y L, Coustabeau, et al. <i>Cement & Concrete Research</i>, 2017, 103, 140.<br />
34	Kim J K, Kwon S H, Kim Y Y. <i>Magzine of Concrete Research</i>, 2006, 58(1), 9.<br />
35	Ladaoui W, Vidal T, Sellier A, et al. <i>Materials & Structures</i>, 2011, 44(9), 1629.<br />
36	Luo J L. Experimental study on the time-dependent effects of shrinkage, creep and temperature on PC box girder bridge in high-speed railway. Ph.D. Thesis, Central South University, China,2014 (in Chinese).<br />
	罗俊礼. 高速铁路预应力箱梁收缩徐变和温度时变效应试验研究. 博士学位论文, 中南大学, 2014.<br />
37	Rao R, Zhang Z, Gan Q, et al. <i>Materials Research Innovations</i>, 2015, 19(S2), 174.<br />
38	Ba ant Z P, Yu Q, Li G H, et al. <i>Journal of Structure Engineering</i>, 2012, 138(6), 676.<br />
39	Vidal T, Sellier A, Ladaoui W, et al. <i>Journal of Materials in Civil Engineering</i>, 2015, 27(7), B4014002.<br />
40	Tabatabai H, Oesterle R G. <i>Magzine of Concrete Research</i>, 2017, 69(24), 1243.<br />
41	Yang Y Q, Lu W W, Li X B, et al.<i>Journal of Southwest Jiaotong University</i>, 2015, 50(6), 977.<br />
	杨永清, 鲁薇薇, 李晓斌, 等. 西南交通大学学报, 2015, 50(6), 977.<br />
42	Wang Y B, Jia Y, Liao P, et al.<i>Journal of the China Railway Society</i>, 2018, 40(7), 100.<br />
	王永宝, 贾毅, 廖平, 等. 铁道学报, 2018, 40(7), 100.<br />
43	Brinson H F. <i>Polymer engineering science and viscoelasticity</i>, Springer, United States, 2008.<br />
44	Zehsaz M, Vakili-tahami F, Saeimi-sadigh M A. <i>Journal of Strain Analysis for Engineering Design</i>, 2014, 50(1), 4.<br />
45	Dean G. <i>International Journal of Adhesion & Adhesives</i>, 2007, 27(8), 636.<br />
46	Feng C W, Keong C W, Hsueh Y P, et al. <i>International Journal of Adhesion & Adhesives</i>, 2005, 25(5), 427.<br />
47	Diab H, Wu Z. <i>Composites Part B</i>, 2008, 39(4), 722.<br />
48	Mazzotti C, Savoia M. <i>Advances in Structure Engineering</i>, 2009, 12(5), 651.<br />
49	Emara M, Torres L, Baena M, et al. <i>Composites Part B</i>, 2017, 129, 88.<br />
50	Houhou N, Benzarti K, Quiertant M, et al. <i>Journal of Adhesion Science & Technology</i>, 2014, 28(14), 1345.<br />
51	Choi K K, Meshgin P, Taha M R. <i>Composites Part B</i>, 2007, 38(5), 772.<br />
52	Zhang C, Wang J. <i>Composite Structures</i>, 2011, 93(12), 3200.<br />
53	Choi K K, Taha M M R. <i>Journal of Adhesion Science & Technology</i>, 2013, 27(5), 523.<br />
54	Jeong Y, Lee J, Kim W. <i>Materials</i>, 2015, 8(2), 435.<br />
55	Rathore D K, Prusty R K, Mohanty S C, et al. <i>Mechanics of Materials</i>, 2017, 105, 99.<br />
56	Ascione L, Berardi V P, Daponte A. <i>Mechanics Research Communications</i>, 2012, 43, 15.<br />
57	Ascione F, Berardi V P, Feo L, et al. <i>Composites Part B</i>, 2008, 39(7), 1147.<br />
58	Maksimov R D, Plume E. <i>Mechanics of Composite Materials</i>, 2001, 37(4), 271.<br />
59	Najafabadi E P, Bazli M, Ashrafi H, et al. <i>Construction and Building Materials</i>, 2018, 171, 960.<br />
60	Boscato G, Casalegno C, Russo S. <i>Mechanics of Composite Materials</i>, 2016, 52(1), 27.<br />
61	Bottoni M, Mazzotti C, Savoia M. <i>Composite Structures</i>, 2014, 108(108), 514.<br />
62	Findley W N. <i>Society of Plastic Engineering Journal</i>, 1960, 16(1), 57.<br />
63	Jeon J, Kim J, Muliana A. <i>Computational Materials Science</i>, 2013, 70, 37.<br />
64	Tan K H, Saha M K. <i>Journal of Composites for Construction</i>, 2006, 10(6), 474.<br />
65	Tanks J, Rader K, Sharp S, et al. <i>Composite Structures</i>, 2017, 159, 455.<br />
66	Hong S, Park S K. <i>Composite Structures</i>, 2016, 152, 140.<br />
67	Kim S H, Han K B, Kim K S, et al. <i>Composites Part B</i>, 2009, 40(4), 292.<br />
68	Hamed E, Chang Z T. <i>Composites Science & Technology</i>, 2013, 74, 186.<br />
69	Sobuz H R, Ahmed E, Sutan N M, et al. <i>Construction & Building Mate-rials</i>, 2012, 29(29), 597.<br />
70	El-sayed A K, Al-zaid R A, Al-negheimish A I, et al. <i>Construction and Building Materials</i>, 2014, 51, 473.<br />
71	Muller M, Toussaint E. <i>Composites Part B</i>, 2007, 38(4), 417.<br />
72	Chami G A, Thriault M, Neale K W. <i>Construction & Building Materials</i>, 2009, 23(4), 1640.<br />
73	Choi K K, Taha M M R, Masia M J, et al. <i>Journal of Composites for Construction</i>, 2010, 14(6), 812.<br />
74	Yahyaei-moayyed M, Taheri F. <i>Composite Structures</i>, 2011, 93(2), 616.<br />
75	Al-sunna R, Pilakoutas K, Hajirasouliha I, et al. <i>Composites Part B</i>, 2012, 43(5), 2125.<br />
76	Kim V J, Khan F. <i>ACI Structure Journal</i>, 2015, 112(4), 493.<br />
77	Chan B, Xiao Y. <i>Natrual Science Journal of Xiantan University</i>, 2008, 30(4), 75 (in Chinese).<br />
	单波, 肖岩. 湘潭大学自然科学学报, 2008, 30(4), 75.<br />
78	Shan B. Long-term behavior of FRP-strengthened concrete colums subjected to earthquake damage. Ph.D. Thesis, Hunan University, China,2006 (in Chinese).<br />
	单波. FRP加固钢筋混凝土柱考虑地震及使用损伤的长期性能和修复. 博士学位论文, 湖南大学, 2006.<br />
79	Zhang D J. A plasticity model for FRP confined concrete including creep effects. Ph.D. Thesis, Beijing Jiaotong University, China,2013 (in Chinese).<br />
	张电杰. 考虑徐变效应的FRP约束混凝土塑性模型研究. 博士学位论文, 北京交通大学, 2013.<br />
80	Han C X. Theoritical and experimental research on creep and shrinkage effect of steel and concrete composite beams. Ph.D. Thesis, Kunming University of Science and Technology, China, 2016 (in Chinese).<br />
	韩春秀. 钢—混凝土组合梁徐变和收缩效应的理论与试验研究. 博士学位论文, 昆明理工大学, 2016.<br />
81	Taha M M R, Masia M J, Choi K K, et al. <i>ACI Structure Journal</i>, 2010, 107(6), 627.<br />
82	Jiang S Y, Yao W L, Chen J, et al. <i>Composite Structures</i>, 2018, 200, 599.<br />
83	Jiang S Y, Cai T, Yao W L, et al.<i>Fiber Reinforced Plastics/Composites</i>, 2018(6), 28.<br />
	江世永, 蔡涛, 姚未来, 等. 玻璃钢/复合材料, 2018(6), 28.<br />
84	Mari A R, Oller E, Bair N J M, et al. <i>Composites Part B</i>, 2013, 45(1), 1368.<br />
85	Mari A R, Bair N J M, Duarte N. <i>Engineering Structure</i>, 2010, 32(3), 829.<br />
86	Torres L, Mi S C, Turon A, et al. <i>Engineering Structure</i>, 2012, 40(7), 230.<br />
87	ACI Committee 318. <i>Building code requirements for structural concrete and commentary</i>, American Concrete Institute, United States, 2014.<br />
88	Hamed E, Bradford M A. <i>European Journal of Mechanics-A/Solids</i>, 2010, 29(6), 951.<br />
89	Hamed E, Bradford M A. <i>International Journal of Solids & Structures</i>, 2012, 49(13), 1595.<br />
90	Hadjazi K, Sereir Z, Amziane S. <i>International Journal of Solids & Structures</i>, 2016, 94, 196.<br />
91	Teng J G, Zhang J W, Smith S T. <i>Construction & Building Materials</i>, 2002, 16(1), 1.<br />
92	Meshgin P, Choi K K, Taha M M R. <i>International Journal of Adhesion & Adhesives</i>, 2009, 29(1), 56.<br />
93	Chen G M. Behaviour and strength of RC beams shear-strengthened with externally bonded FRP reinforcement. Ph.D. Thesis, Hong Kong Polytechnic University,China, 2010.<br />
94	Chen G M, Teng J G, Chen J F. <i>Journal of Composites for Construction</i>, 2010, 15(3), 339.<br />