Please wait a minute...
材料导报  2018, Vol. 32 Issue (18): 3116-3122    https://doi.org/10.11896/j.issn.1005-023X.2018.18.004
  无机非金属及其复合材料 |
磷酸二氢钾晶体薄表面层生长动力学实时显微研究
胡志涛, 李明伟, 尹华伟, 刘杭
重庆大学动力工程学院,低品位能源利用技术及系统教育部重点实验室,重庆 400030
In Situ Micro-study on the Growth Kinetics of the Thin Surface Layer of Potassium Dihydrogen Phosphate Crystal
HU Zhitao, LI Mingwei, YIN Huawei, LIU Hang
Key Laboratory of Low-Grade Energy Utilization Technologies and Systems of Ministry of Education, College of Power Engineering, Chongqing University, Chongqing 400030
下载:  全 文 ( PDF ) ( 2770KB ) 
输出:  BibTeX | EndNote (RIS)      
摘要 利用光学显微镜实时观测磷酸二氢钾(KDP)晶体柱面及锥面薄表面层的生长过程,测得不同过饱和度下薄表面层前端不同倾角的非正常棱边推移速度。结果表明:倾角越小,非正常棱边推移速度越慢,薄表面生长终止于其前端的正常棱边处;随着过饱和度的增大,非正常棱边推移速度线性增加。计算得到柱面及锥面薄表面层前端非正常棱边推移动力学系数,由于Eslice(010)> E slice(101),因而柱面薄表面层的生长动力学系数大于锥面。建立了基于非奇异面上台阶生长机制下的薄表面层生长体扩散模型。应用该模型解释了薄表面层生长速度随其厚度及前端非正常棱边倾角的变化关系,并讨论了溶液流动对薄表面层生长的影响。结果发现薄表面层生长存在一个使其以恒定厚度向前推移的临界厚度。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
胡志涛
李明伟
尹华伟
刘杭
关键词:  薄表面层  生长动力学  光学显微镜  磷酸二氢钾晶体  体扩散    
Abstract: The growth processes of the thin {010} and {101} layers of potassium dihydrogen phosphate (KDP) crystals were observed in real time by optical microscopy. The displacement velocities of the abnormal crystallographic edges with different inclination angles on the growth front of the thin surface layers were measured under different supersaturations. Results showed that the smaller the inclination angle was, the slower the displacement velocity of the abnormal crystallographic edge was. The growth process of the thin surface layer terminated at normal crystallographic edges on the growth front. With increase of supersaturation, the displacement velocity of the abnormal crystallographic edge increased linearly. In addition, the kinetic coefficients for abnormal crystallographic edges on the thin {010} and {101} layers were calculated. Compared with the thin {101} layers, the thin {010} layers had a larger kinetic coefficient because of the bigger slice energy Eslice(010). A volume diffusion model based on the motion of a parallel sequence of elementary steps on the growth front of thin surface layer was established. This model was not only used to explain the change of the advanced velocities of thin surface layer with its thickness and the inclination angle of its abnormal crystallographic edge on the growth front, but also applied to discuss the effect of the flow on the growth of thin surface layers. At last, a critical thickness under which the thin surface layer would go forward with a constant thickness was found.
Key words:  thin surface layer    growth kinetics    optical microscopy    potassium dihydrogen phosphate (KDP) crystal    bulk diffusion
                    发布日期:  2018-10-18
ZTFLH:  O78  
基金资助: 国家自然科学基金(51476014)
通讯作者:  李明伟:男,1964年生,博士,教授,博士研究生导师,研究方向为材料制备中的热物理问题、界面现象及热力学相变机理 E-mail:aoweixia@126.com   
作者简介:  胡志涛:男,1988年生,博士,研究方向为功能材料制备及晶体生长机理 E-mail:huzhitao@cqu.edu.cn
引用本文:    
胡志涛, 李明伟, 尹华伟, 刘杭. 磷酸二氢钾晶体薄表面层生长动力学实时显微研究[J]. 材料导报, 2018, 32(18): 3116-3122.
HU Zhitao, LI Mingwei, YIN Huawei, LIU Hang. In Situ Micro-study on the Growth Kinetics of the Thin Surface Layer of Potassium Dihydrogen Phosphate Crystal. Materials Reports, 2018, 32(18): 3116-3122.
链接本文:  
http://www.mater-rep.com/CN/10.11896/j.issn.1005-023X.2018.18.004  或          http://www.mater-rep.com/CN/Y2018/V32/I18/3116
1 Zaitseva N, Smolsky I, Carman L. Growth phenomena in the surface layer and step generation from the crystal edges[J]. Journal of Crystal Growth,2001,222(1-2):249.
2 Zhong D G, Teng B, Yu Z H, et al. Investigation on the regeneration of Z-cut KDP crystals[J]. Crystal Research and Technology,2011,46(9):911.
3 Zhong D G, Teng B, Dong S M, et al. In-situ study on the effect of Fe3+ on the regeneration on kinetics of Z-cut ADP crystal[J]. Journal of Synthetic Crystals,2010,39(S1):59(in Chinese).
钟德高,滕冰,董胜明,等.实时研究Fe3+Z切向ADP晶体成锥动力学过程的影响[J].人工晶体学报,2010,39(S1):59.
4 Li G H. Rapid Z-plate seed regeneration of large size KDP crystal from solution[J]. Journal of Crystal Growth,2008,310(1):36.
5 Walker A C. Growing piezoelectric crystals[J]. Journal of the Franklin Institute,1950,250(6):481.
6 Zerfoss S, Slawson S I. Origin of authigenic inclusions in synthetic crystals[J]. American Mineralogist,1956,41(7-8):598.
7 Rosmalen R J, Linden W H, Dobbinga E, et al. The influence of the hydrodynamic environment on the growth and the formation of liquid inclusions in large potassium dihydrogen phosphate (KDP) crystals[J]. Crystal Research & Technology,2010,13(1):17.
8 Zhang B K, Yan M S, Wang M F. Notes on the growth of single crystal of ammonium dihydrogen phosphate[J]. Journal of Fuzhou University,1962(2):47(in Chinese).
张炳楷,颜明山,王曼芳.磷酸二氢铵单晶培养的一些问题[J].福州大学学报,1962(2):47.
9 Zaitseva N, Carman L. Rapid growth of KDP-type crystals[J]. Progress in Crystal Growth and Characterization of Materials,2001,43(1):1.
10 Deng W, Li M W, Wang P F, et al. Experimental investigation on the formation and growth characteristics of thin surface layer at Z-cut KH2PO4 plate by “coating method”[J]. Materials Review B:Research Papers,2016,30(12):108(in Chinese).
邓伟,李明伟,王鹏飞,等.涂覆法观测KH2PO4晶体Z切片薄表面层形成和生长特性[J].材料导报:研究篇,2016,30(12):108.
11 Cheng G, Li M W, Yin H W. Effect of edge angles on growth of thin surface layer of Z-cut NH4H2PO4 crystal[J]. Journal of Inorganic Materials,2016,31(11):1177(in Chinese).
程高,李明伟,尹华伟.棱角对NH4H2PO4晶体Z切片薄表面层生长影响的研究[J].无机材料学报,2016,31(11):1177.
12 Teng B, Zhong D G, Yu Z H, et al. Growth from the edges and inclusion defect of KDP crystal[J]. Journal of Crystal Growth,2009,311(3):716.
13 Rashkovich L N. KDP-family single crystals[M]. Bristol:Adam Hiler,1991:19.
14 Liu B, Fang C S, Wang S L, et al. Research on the growth kinetics of (101) faces of KDP crystal[J]. Journal of Synthetic Crystals,2008,37(5):1045(in Chinese).
刘冰,房昌水,王圣来,等.KDP晶体(101)面生长动力学研究[J].人工晶体学报,2008,37(5):1045.
15 Alexandru H V, Berbecaru C, Grancea A, et al. KDP prismatic faces: Kinetics and the mechanism of their growth from solutions[J]. Journal of Crystal Growth,1996,166(1):162.
16 Lu G W, Li C X, Wang Z H, et al. A study on the step growth kinetics of KDP crystal by Michelson laser interferometer experiment[J]. Chinese Journal of Chemical Physics,2003,16(4):289(in Chinese).
卢贵武,李春喜,王子镐,等.KDP晶体台阶生长动力学的激光干涉实验研究[J].化学物理学报,2003,16(4):289.
17 Sangwal K, Borc J, Pałczyńska T. On the growth hillock vicinality and normal growth rates of the (101) face of KDP crystals[J]. Journal of Crystal Growth,1998,194(2):214.
18 Xu D L, Xue D F. Chemical bonding theory of the crystal growth[J]. Journal of Synthetic Crystals,2006,35(3):598(in Chinese).
许东利,薛冬峰.结晶生长的化学键合理论[J].人工晶体学报,2006,35(3):598.
19 Hartman P. The morphology of zircon and potassium dihydrogen phosphate in relation to the crystal structure[J]. Acta Crystallographica,1956,9(9):721.
20 闵乃本.晶体生长的物理基础[M].上海:上海科学技术出版社,1982.
21 Cheng M. Research on the microscopic thermodynamics and kinetics of potassium dihydrogen phosphate nucleation and growth with different pH values[D]. Chongqing: Chongqing University,2010(in Chinese).
程旻.不同pH值下磷酸二氢钾晶体成核及生长的微观热动力学研究[D].重庆:重庆大学,2010.
22 Chernov A A. The spiral growth of crystals[J]. Soviet Physics Uspekhi,1961,4(1):116.
23 Thomas T N, Land T A, Martin T, et al. AFM investigation of step kinetics and hillock morphology of the {100} face of KDP[J]. Journal of Crystal Growth,2004,260(3-4):566.
24 Robey H F. Numerical simulation of the hydrodynamics and mass transfer in the large scale, rapid growth of KDP crystals part 2: Computation of the mass transfer[J]. Journal of Crystal Growth,2003,259(4):388.
25 Chernov A A. Step bunching and solution flow[J]. Journal of Optoelectronics and Advanced Materials,2003,5(3):575.
26 Yu X L, You J L, Wang Y, et al. Microprobe of structure of crystal/liquid interface boundary layers[J]. Science in China Series E Technological Sciences,2001,44(3):265.
27 Burton J A, Kolb E D, Slichter W P, et al. Distribution of solute in crystals grown from the melt. Part Ⅱ. Experimental[J]. Journal of Chemical Physics,1953,21(11):1991.
[1] 韩银娜, 张小军, 李龙, 周德敬. 铝基层状复合材料界面金属间化合物的研究现状[J]. 材料导报, 2019, 33(7): 1198-1205.
[2] 胡志涛,李明伟,尹华伟,肖林海. 非完整形态KH2PO4晶体薄表面层生长特性[J]. 《材料导报》期刊社, 2018, 32(2): 272-277.
[1] Bingwei LUO,Dabo LIU,Fei LUO,Ye TIAN,Dongsheng CHEN,Haitao ZHOU. Research on the Two Typical Infrared Detection Materials Serving at Low Temperatures: a Review[J]. Materials Reports, 2018, 32(3): 398 -404 .
[2] Huimin PAN,Jun FU,Qingxin ZHAO. Sulfate Attack Resistance of Concrete Subjected to Disturbance in Hardening Stage[J]. Materials Reports, 2018, 32(2): 282 -287 .
[3] Siyuan ZHOU,Jianfeng JIN,Lu WANG,Jingyi CAO,Peijun YANG. Multiscale Simulation of Geometric Effect on Onset Plasticity of Nano-scale Asperities[J]. Materials Reports, 2018, 32(2): 316 -321 .
[4] Xu LI,Ziru WANG,Li YANG,Zhendong ZHANG,Youting ZHANG,Yifan DU. Synthesis and Performance of Magnetic Oil Absorption Material with Rice Chaff Support[J]. Materials Reports, 2018, 32(2): 219 -222 .
[5] Ninghui LIANG,Peng YANG,Xinrong LIU,Yang ZHONG,Zheqi GUO. A Study on Dynamic Compressive Mechanical Properties of Multi-size Polypropylene Fiber Concrete Under High Strain Rate[J]. Materials Reports, 2018, 32(2): 288 -294 .
[6] XU Zhichao, FENG Zhongxue, SHI Qingnan, YANG Yingxiang, WANG Xiaoqi, QI Huarong. Microstructure of the LPSO Phase in Mg98.5Zn0.5Y1 Alloy Prepared by Directional Solidification and Its Effect on Electromagnetic Shielding Performance[J]. Materials Reports, 2018, 32(6): 865 -869 .
[7] ZHOU Rui, LI Lulu, XIE Dong, ZHANG Jianguo, WU Mengli. A Determining Method of Constitutive Parameters for Metal Powder Compaction Based on Modified Drucker-Prager Cap Model[J]. Materials Reports, 2018, 32(6): 1020 -1025 .
[8] WANG Tong, BAO Yan. Advances on Functional Polyacrylate/Inorganic Nanocomposite Latex for Leather Finishing[J]. Materials Reports, 2017, 31(1): 64 -71 .
[9] HUANG Dajian, MA Zonghong, MA Chenyang, WANG Xinwei. Preparation and Properties of Gelatin/Chitosan Composite Films Enhanced by Chitin Nanofiber[J]. Materials Reports, 2017, 31(8): 21 -24 .
[10] YUAN Xinjian, LI Ci, WANG Haodong, LIANG Xuebo, ZENG Dingding, XIE Chaojie. Effects of Micro-alloying of Chromium and Vanadium on Microstructure and Mechanical Properties of High Carbon Steel[J]. Materials Reports, 2017, 31(8): 76 -81 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed